Professional Documents
Culture Documents
Drinking Water Inspection Report 02
Drinking Water Inspection Report 02
Date 08/12/2009
Drinking water Inspection Report
Page No 1
Inspection process
Inspection Photographs
The primary source of drinking water for the main branch water was identified as supplyed water.
Sampling Process
Water samples were collected at the main branch drinking water station. One sample was collected directly
from a drinking water tap, while the second sample was obtained from the primary filter inlet connected to
the drinking water tank.
sample water taken in according with EPA Standards
1-At the drinking water tap, first, flush the tap for a few minutes to remove any stagnant water.
2-Sterilize the tap by wiping it with a disinfectant.
3-Open the tap to a moderate flow rate.
4-Collect the sample in a clean, sterile sample container, ensuring that the container does not touch the tap or
any surfaces.
Sample Collection at Primary Filter Inlet:
At the primary filter inlet, inspect and clean the sampling point if necessary.
Collect the sample from this point using a separate clean and sterile container.
Analysis:
Conduct the PH analysis on the samples in accordance with the relevant standards and EPA guidelines.
Test result
Environmental Protection Agency recommends that the pH level of water sources should be at a pH
measurement level between 6.5 to 8.5 on a scale that ranges from 0 to 14.
0 1 2 3 4 5 6 7 8 9 10 11 12 13 14
PH VALUE
The PH value of drinking water =7 neutral