Professional Documents
Culture Documents
BAYCOSEAL-1K
One Component Waterproofing Slurry
2163 - CPR - 0249
TS EN 1504-2
Description:
Compressive strength: 16,8 N/mm² at 28 d
BAYCOSEAL-1K is a cement based, one component,
(ASTM C 579)
rigid waterproofing material.
Rapid chloride
permeability: 23% reduction
Areas of Application: (ASTM-C 1202.97)
BAYCOSEAL-1K is used at both interior and exterior Initial surface absorption: Nil (BS 1881 Part 208:96)
applications as a waterproofing material on concrete,
masonry and plaster at,
Packaging:
Underground structures and basements,
25 kg sack
Heating pipes, pits, sewage work structures,
Tunnels and sluices,
Storage:
Pools and potable water tanks,
Unopened original sacks can be kept for 12 months in
Retaining walls,
a dry condition.
Old buildings which are not protected against
posterior moisture and soaking water.
Surface Preparation:
Properties/Advantages: The surface must be sound, mostly even, free of
It consists of quartz sand, portland cement additives. pockets, cracks and ridges. Any material which can
BAYCOSEAL-1K does not contain any materials which prevent adhesion shall be removed from the surface.
can negatively effect reinforcement. The advantages of The surface has to be moistened. Brick work areas
the material are: have to build with joints in cement mortar. Do not
BAYCOSEAL-1K has a strong resistance against begin to apply before repair work if needed.
negative water pressure. It can be applied on every
waterproofing application. Product Preparation:
It can be used to form a system with elastomeric BAYCOSEAL-1K is supplied in powder form. Mix on
waterproofing slurry BAYCOSEAL-2K/M. site with clean water in a clean container to a workable
The material is very economical. It can be used to consistency that can be sprayed or brushed.
level surfaces under waterproofing layers as a
primer. Method of Application:
It has perfect adhesion to concrete. BAYCOSEAL-1K can be sprayed or brushed in several
coats with 1-2 kg/m² consumption for each coat.
Technical Data: Earth moisture; apply 3,5 kg/m² (2 mm thickness)
Basis: sand/cement, polymer Ground water; apply 3,5 kg/m² (2 mm thickness
Color: grey Ground and back water; apply 4,5 kg/m²
Density: 1,85 kg/l (2,5 mm thickness)
Mixing ratio: 25 kg BAYCOSEAL-1K to
6,7 l tap water Cleaning:
Pot life: 60 minutes Clean the tools with appropriate cleaner after the
Light pedestrian traffic: at +20ºC 24 hours later application.
Substrate/Application
temperature: +5ºC to +35ºC
Adhesion strength: 0,5 N/mm²
(ASTM D 4541:2002)
Shore ‘D’: D/66/1 (ASTM D 2240:05)
Important Advices:
Freshly applied BAYCOSEAL-1K, should be
protected against rain, direct sunlight and frost.
After 3 hours from application, the material
becomes resistant to rain.
Avoid ponding during application and hardening.
Coarse-pored surfaces cause high consumptions.
Lower temperatures extend, higher temperatures
reduce curing times.
This technical data sheet is updated on regular basis. It is the user’s responsibility to obtain the most recent issue.
29/01/2017