Professional Documents
Culture Documents
EE 113: DC Circuits
Website: https://mavdisk.mnsu.edu/zhangq Æ teaching
Goals/Objectives: To develop the students ability to solve direct current problems. To develop the
students proficiency in the use of electronic test equipment in performing measurements. To provide a
foundation for more advanced courses in electrical circuits and electronics. To learn how to use circuit
simulation software.
Course Description: A study of DC electric circuits, Kirchhoff’s laws, series and parallel circuits,
capacitors, Thevinin’s equivalent circuit theorem, and other network analysis theorems, inductors (time
allowable) (Chapters 1 to 11, textbook)
Grading:
Homework/Quizzes – 25% Labs –25% Midterm Exam – 20% Final Exam – 30%
(The both exams will be in class and closed book with notes permitted)
Course grades:
No late homework will be accepted whatsoever.
No make-up exams will be given for missed midterm exams. 20% will be added to the Final Exam
percentage for a missed Midterm exam (final exam will be comprehensive so may be more challenging).
The Final Exam must be taken in order to pass the course.
Cheating:
Cheating will be dealt with in a manner that is consistent with the action. The severity of the penalty may
be a simple reprimand or may result in failure of the course. The goal is for you to learn the material. If
you are experiencing trouble in the course discuss it with the instructor – learning the material is easier and
far more satisfying than cheating.
1. Use Ohm's law to determine the current in a branch and a voltage between two nodes.
2. Use Kirchhoff’s laws to determine the current in a branch and a voltage between two nodes of a
circuit.
3. Use Thevenin's (Norton's) Theorem, node analysis, mesh analysis and the superposition
theorem to analyze a simple circuit with at least three components.
4. Be able to analyze circuits with independent as well as dependent sources and measure currents
and voltages.
7. Be able to measure resistances, voltages between two nodes and current through a branch using
a multimeter.
8. Conduct transient analysis on circuit with a single time constant (capacitor or inductor and two
or three resistors).