Model SHP-361
Brown Leatherette
‘Model SHP-362
@g) RcAVicTOR 4b
Stereophonic Record Players
Models SHP-361, SHP-362
Record Changer Collaro Stereo Conquest
SERVICE DATA
— 1958 No. 12—
ISSUED BY
SERVICE DIVISION
RCA VICTOR COMPANY, LTI
MONTREAL, CANADA
ELECTRICAL AND MECHANICAL SPECIFICATIONS
TUBE COMPLEMENT
(1) RGR 12AUB. Lelt Chan. AF. Amplifier
(2) RCA 12A05 Right Chan. AF. Ampliter
(3) RGA a3cs Left Channel Output
(4) RCA 38c5 Right Channel Output,
A gelonium recier is used
POWER SUPPLY RATING
11S volts, 60 cycles 50 wate
POWER OUTPUT
Undisterted 23waite Meximum 25 watte
FREQUENCY RESPONSE, 70 to 20,000 eyclew
‘LOUDSPEAKERS
One 614" PM "wooler”
Two 33s" PM “tweeters
32 chm impedance
6-8 ohm impedance
RECORD CHANGER
Tamtable speed
Record capacity
16%, 9344, 43 oF 78 rpm.
Up to filleen 7 Inch
or twelve 10 inch
or ton 12 inch
or fon 10 in. and 12 in, intermixed,
Pickup (Stock No. 108771) Stervophoniec Ceramic
GENERAL DESCRIPTION
‘Tho "Model SHP-362" is a storsophonic high-idelty consalete
‘model, phonograph vowed ina modem style wood. cablael
‘evallable in ow finisher,
‘The "Medel SHP.361" le « storeophonlc highiidelty phonograph
housed in a brown leatherette carrying case having @ wotone
‘woven giile cot
[A fourapeed automatic record changer, equipped with «
stareophonic coramic pickup, is used. One §ls-inch nd two
SMningh spedkers are’ weed. The frequency response is fom
70 cycles to 20,000 cycies.
The amplifier har four tubes and at selenium sectilier; it is
designed for operation on a 10S v, to 125 v. 60 cycle. power
supply. The three controle marked “LOUDNESS,” “BASS!” and
“TREBLE” operate in c clockwise direction fot. maximum ter
sponse. Tho loudness control kaob is numbered from 0 to 10
‘with the top tap setting between 6 and 7. Normal position of
the bass antl treble control knobs i indicated by the letter "N
fon each control knob. These tone control knabe are cleo marked
‘with numbers 1 fo 5 an both sides of the "N for 7
Either {ntirament may be used alone at o mona
graph or It may be used in conjunction with an ext
speaker system as a sloreophonic phonograph. A slide-type
Ewilch is used fo select between thase two modes of operation
‘The amplifer has two separate single-ended output chars
When the instrument is used alone. (without fell chanel
ternal specter rystom), the slide-type avitch ie set fo place the
ccutput ttamalormer secondaries in parallel,
SUPPLEMENTARY INFORMATIONSPEAKER CONNECTIONS
‘SHP-961, SHP-962
‘The three speakers must be connected cx shown in the dustrations be-
low, Improper connections may reault In datoried oF weak reproduction.
Speaker Connection Diageann
CHANNEL GAIN EQUALIZATION
Those equalization controls (RIS and R2S) are located on
front of the chastis and are accessible upon removal ef the con
tela esculeheon. The LEPT CHANNEL gain control (RIS). is Io.
Ssled between the loudness control cand the base tone cont
‘The RIGHT CHANNEL gain control (RZS) is located between the
thro tone controle,
‘When adjusting these controls, three conditions must exist
1. A monaural signal input must be uted. This can be @ mi
‘witch (S2) must be in the “INT. &
This is necessary for the two chan:
ystems must be con-
y with resistors. If oat.
ut ie measured with can output meter, @ channel having no
seaman nacren wen
RESIST So,
ete, atti
BSeS8ebsel
ofesssesess)
cerrevan SR
(eads
speakers connected will have an abnormally high output
‘oltage reading
4 Adjust BOTH equalization controls to the maximum clock:
‘esiion
5, Tum counter-clockwise only the gain control of the chan
nelhaving the grecter tpt uni the point of equ cutpt
the. equalization adjustmer
hhad by listening. This is best done by playing @ monaural record
with the leit chumnel speaker placed for teres listening. Adjust
‘one balance contral to thatthe combined sound ol the two speakers
‘appears to come from «point midway between 1
the external speak
tance, the output ‘vllage
output
‘not be equal for equal power
CRITICAL LEAD DRESS
1. Dress heater leads close to chanss
2. Dress ail leads away from phono input socket
3. Keep leads of C4 and C7 as short as possible and dress all
‘other componente away irom these capacitor.
4. Record changer motor leade must be twisted to minimize hum.
ACCESS TO TUBES AND CHASSIS
Mode! SHP-262
Turn cabinet on ite side and remove ten wood
screws holding the bottom cover to the ‘eabinel
Model SHP-361
Remove inside front panel hold by screws. Re:
move control knobs. Remove screws at edges of
record changer mounting board tit board upward,
FOR RECORD CHANGER
SERVICE INFORMATION—
REFER TO
COLLARO STEREO CONQUEST
ON PAGE 15 THIS VOLUME
View of Amplifier Chassis Showing Location of Tuber and Major Components‘SHP-961, SHP.962
(CL % peyouuco jou siexDede fouunyo-ye1) poem soqidiam ow 04 pond og
‘9m Aqwo sroxpeds fousoiNy HOG 1 NOLLISOd. Yo} samod 205 ,O,, O4 HH sOBuDYD prooaL ORL, TosIUOD
fq wnor (28) HOLIMS NOWONN HDAVIAS 84, sumgoa oy) Jo Hod 10m Hf HOHIMS .J4O-NO, CL —BLONSHP.961,
SHP-362
REPLACEMENT PARTS LIST
Insist on Genuine Factory Tested Parts, which ate reodih
identified and may be purchated from Authorid Dealers
ssyatpot | st0CK No. DESCRIPTION svmpot| st0CK No. DESCRIPTION
cr Capacitor .0047 mfg, 20% 400 V Belt Resistor ~ $3,000 ohms, 10%, 1/20
2 Capacitor 047" mld, 20% 400 V Reig Resistor - 15 ohms, 108, 1"
3 Capacitor ‘047 mtd. 20% 400V Rod Resistor ~ 15 onms, 10%, tw
ca Capacitor [01 mfd, 10% 200 B20 Resistor - 100 ohms, 104, 29
c5 Capacitor ‘0018 mid, 10%, 600v Rat | + 106400 Resistor -Wirewound - 150 ohms, 10%, 4m
Capacitor 1033 md. 10%, 2007 R22 Resistor - 4700 onms, 10%, 1/20
or Capacitor ‘01 md, 10%, '200V R23 Resistor —
cs Capacitor [0018 mid, 10%, 600v Rm Resistor -
oo Capacitor '0035 mtd, 10%, 200¥ 8-25 | + 108210 Contzol - mt, cnannel gain equalization
G10 | + sosrre | Eectroiyic = 1 mta, 80V control
eu Capacitor .0022 mfé, 10%, 600¥
en Capacitor 1022 md. 20%, «00V 82 46160 | suiten - speaker Selector Switeh
en Capacitor 147 ral, 20% 400V
ci Capacitor [0022 mtg, 10% 600v T1u2 | + 108504 | Transformer - Audio Output Transformer
eis Capacitor 122 mtd, 0%, 400
cis Capacitor [047 mia, 20%, 400V ee
cit | s-224e2 | Capacitor 11 mia, 20%, 400. ss-2244s_ | speaker - 3-1/2" Pa speaker (2 rea'd)
mis | s-22482 | Electroiytic - 90/30/86/25 mata, 100464 | Speaker ~ 6-1/2" PM speaker
150/150/180/25V. 100509 | Capacitor = electrolytic » 8 mfa, 10V
cs Capacitor ~ .0086 md. 10%, 400v + 00467 | Housing - Plastic mounting base for
20 Capacitor - 10088 mid. 10%, 400¥ S+1/2" Speaker SHPSBL
cm Part of Speaier Assembly “MISCELLANEOUS ASSEMBLY
cra 100854 | Rectifier ~ Selenium Rectifier MODEL SHP-261
+3-22645, | Cabinet ~ Palimino Cabinet & Speaker
et 38653 | Connector 4 Contact female 15-22548, | Cabinet - Extension Speaker Cabinet
Ss-22847 | Eseatheon = Cabinet Air Vent
Bs 39514 | Connector - Dual female Connector for s5-22548, | Foot = Cabinet Foot
‘external speaker 3-22549 | Handle - Carrying Handle & Supports
ca a9s1s | Connector ~ Daal female Connector for 5222850 | Hinge ~ Lid Hinge
‘ternal speaker, 5222851 | Lateh ~ Latch for Lia ninge
5222817 | Clotn~ Grille Clots
Pa soitgt | Connector ~ 4 contact male $5-22227 | Support = Cabinet Lid Support
Par insaTt | Connector 3 contact female s:22652 | Plate = Trim Plate
Pan 08044 | Connector = 3 contact male
ITEMS COMMON TO BOTH MODELS
Rea Resistor ~ 100,000 ohms, 10%, 1/20 : ey
Ra Resistor ~ 12,600 ohms, '10%,'1/20 Sass | (suai eeeenorenaee
BS Resistor = 189,000 ohms, 104, 1/2 41s-22450 | Escutcheon - Knob Escutcheon
Ra Resistor - 100,000 ohms, 10%, 1/2 ‘s-aze7_| Emblem = Dog Emblem
RS Resistor = 12,000 ohms, 10%, 1/2 104123 | Knob Ase'y - Bass or Treble Tone Com
RS Resistor ~ 180,000 ohms, 10%, 1/26 rol Knob
neta/e | ee-22447 | Control. Dual Bass Tose Control 104122 | Knob Ass'y - Volume Control Knob
R-6a/B | *8-22445 | Control = Dual Loudness Tone Control 612508. | Moti= Stereo Orthopnonie High Fidelity
RD Resistor = 3900 ohms, 10%, 1/2 101766 | Retainer ~ "46" spindle Retainer Clamp
R-10A/8} *8-22446 | Control. - Dual Treble Tone Coutrol 13808, | Spring ~ Knob Retaining Spring
Ra Resistor = 470,000 ohms, 10%, 1/2 ‘13584 | Shield~ Tube Shield for Vi, V2
Ri Resistor ~ 820,000 ohms, 10%, 1/2 101600 | Socket ~ 7 pin miniature socket for V1,
os Resistor - 470,000 ohms, 10%, 1/2 V2, V3 and Vi
Ru Resistor ~ 830,000 onms, 10%, 1/2 +s-22441 | Manual * Customers Instruction Manual
R15 | + 105210 | Control. = Left’ehannel gain eqialization
control 8.22028 | Logs - Sot of 4 (SHP-382)
R68 Resistor ~ 82 ohms, 10%, 1
‘TTndicales Now Slock Rema.
‘Only items listed under stock numbers are available os Replacement Parts,
All patts subject to change or withdrawal without notice.
SPEAKER PHASING
For additional information on speaker phasing, refer tothe Supplementary Information atthe front ofthis volume,