Professional Documents
Culture Documents
Fire Alarm Questionnaire CIVIL DEFENSE
Fire Alarm Questionnaire CIVIL DEFENSE
1) In the state of Qatar , what codes for Fire Alarm Systems designed to meet?
a) NFPA 70 d) NFPA 101
b) NFPA 72 e) A, B & D
c) NFPA 13
2) What other regulations, requirement must the fire alarm system designs must comply to?
a) Qatar Civil Defence Requirements d) NEMA Standards
b) ASTM Standards e) None of the above
c) British Standards
3) QCD Fire Safety Standard requires that each floor of every building shall as a minimum have a
_______________________ that clearly depicts using colors and symbols , the location of all fire zones,
the type and location of all initiating devices on that floor and a “YOU ARE HERE” indication.
a) Indicating MIMIC Panel d. Repeater Panel
b) Zone Chart e. None of the above
c) Fire Control Panel
4) If the total system Standby current of FACP and field devices is 0.18A and the total System Alarm Current
is 3.32A. Find the total required capacity in AH for the battery of FACP considering that Standby and
Alarm Hours are 24 hours and 0.16 hour ( 10 min) respectively/
a) 5.35 AH d. 6.52 AH
b) 4.52 AH e. None of the above (5.82AH) with 20% spare
c) 4.85 AH ( without 20% spare)
5) Any alarm caused by mechanical failure, malfunction, improper installation, or lack of proper
maintenance, or any alarm activated by a cause that cannot be determined.
a) False Alarm d. Fault Alarm
b. Nuisance Alarm e) None of the above
c) Maintenance Alarm
7) What is the minimum number of spot-type detectors required for a room 210 ft. Long by 150 Ft. Wide and
10 ft Height, if the detectors is listed at 30 ft maximum distance between detectors and 15 ft. maximum
distance from a wall?
a) 40 Detectors Area of room / Coverage of Smoke detector
b) 35 Detectors
c) 50 Detectors
d) 48 Detectors
e) None of the above
8) A fire alarm system component with discrete identification that can have its status individually identified
or that is used to individually control other functions.
a) Alarm Device d) Initiating Device
b) Control Unit e) None of the above
c) Addressable Device
9) The principal attended , or unattended location where the status of the detection, alarm communications
and control systems is displayed and from which the system(s) can be mutually controlled?
a) Fire Pump Room d) Electrical Room
b) Fire Command Center e) None of the above
c) Mechanical Room
10) In the absence of specific performance – based design criteria, the permitted spacing between smoke
detectors shall be:
a) 4.5 meters d) 10 Meters
b) 6.5 meters e) None of the above.
c) 9.1 meters
11) A system component that originates transmission of a change of state condition, such as in a smoke
detector, manual fire alarm box, or supervisory switch.
a) Control Unit d) Interface Module
b) Initiating Device e) None of the above
c) Notification Appliances
12) In compliance to NFPA 72, what are the classifications of fire alarm system in terms of application?
(Give at least 2)
Emergency Lighting shall maintain the illumination of means of egress throughout the exit route
Emergency illumination shall be provided for not less than 1 ½ hours in the event of
failure of normal lighting. Emergency lighting facilities shall be arranged to provide
initial illumination that is not less than an average of 1 ft-candle (10 lux) and, at any
point, not less than 0.1 ft-candle (1 lux), measured along the path of egress at floor
level. Illumination levels shall be permitted to decline to not less than an average of 0.6
ft-candle (6 lux) and, at any point, not less than 0.06 ft-candle (0.6 lux) at the end of the
1½ hours. A maximum-to-minimum illumination uniformity ratio of 40 to 1 shall not be
exceeded
The emergency lighting system shall be arranged to provide the required illumination
automatically in the event of any of the following:
1. Interruption of normal lighting such as any failure of a public utility or other outside
electrical power supply
2. Opening of a circuit breaker or fuse
3. Manual act(s), including accidental opening of a switch controlling normal lighting
facilities
15) How should the number and locations where 2- way hard wired telecommunications are required.
(List at least 3)
17) Is visible signal device required in exit stair enclosure and exit passageway? Why?
Signature : ________________
Time Finished : ________________