Professional Documents
Culture Documents
UENR0668-01 SMCS - 1290-524 Injector Code Cal PDF
UENR0668-01 SMCS - 1290-524 Injector Code Cal PDF
Troubleshooting
C7.1 Industrial Engine
Media Number -UENR0668-01 Publication Date -01/10/2013 Date Updated -02/10/2013
i05085410
Injector codes are codes that are 30 hexadecimal characters in length that are supplied with each
injector. The code is on a plate on the top of the injector and a card is also included in the packaging for
the injector. The code is used by the Electronic Control Module (ECM) to balance the performance of
the injectors.
View Image
Illustration 1 g02854936
Label with the injector code
View Image
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2015
Service Information System Page 2 of 3
Illustration 2 g02132457
Sequence for recording the injector code
The electronic service tool is used to load the injector codes into the ECM.
The injector codes must be loaded into the ECM if any of the following conditions occur:
Note: Diagnostic code 630-2 will also become active if the engine serial number, FLS or FTS are not
entered into the ECM.
If the ECM is replaced, the injector codes are normally transferred to the new ECM as part of the "Copy
Configuration" procedure. If the "Copy Configuration" procedure fails, the injector codes must be
loaded manually.
2. Connect the electronic service tool to the diagnostic connector. Refer to Troubleshooting,
"Electronic Service Tools".
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2015
Service Information System Page 3 of 3
Service
Calibrations
7. Input the applicable injector code that was recorded in Test Step 1.
Exchanging electronic unit injectors can help determine if a combustion problem is in the electronic unit
injector or in the cylinder. If two electronic unit injectors that are currently installed in the engine are
exchanged between cylinders, the injector codes must also be exchanged. Press the "Exchange" button at
the bottom of the "Injector Trim Calibration" screen on the electronic service tool. Select the two
electronic unit injectors that will be exchanged and press the "OK" button. The tattletale for the
electronic unit injectors that were exchanged will increase by one.
Copyright 1993 - 2015 Caterpillar Inc. Mon Jan 26 10:37:17 CST 2015
All Rights Reserved.
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/content.jsp?calledpage=/sisweb/sisweb/fulltext/f... 1/26/2015