Professional Documents
Culture Documents
AH-SA-A Serial Solar Airfield Light - User Manual - Medium Height
AH-SA-A Serial Solar Airfield Light - User Manual - Medium Height
AH-SA-A Serial
User Manual
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401
2/6 User Manual - AH-SA-A serial
Unit:MM
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401
3/6 User Manual - AH-SA-A serial
Specifications
Weight 5.5kgs
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401
4/6 User Manual - AH-SA-A serial
Installation
Light Operation
Light is activated by ON/OFF button on the top of plate. Factory setting mode is steady.
1. Place the light where needed, ensure that the unit is bolted to an even, flat surface. The
solar panel could get good sunshine without shadow on it.
2. Push ON/OFF button to ON mode. Light will be turned ON and remote controlled by
AH-HP-RC remote controller and VHF remote controller.
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401
5/6 User Manual - AH-SA-A serial
Maintenance
Designed to be maintenance free, the AH-SA-A Serial requires minimal attention, though
the following maintenance and servicing information is provided to help ensure the life of
your ANNHUNG product.
1. Cleaning Solar Panels - occasional cleaning of the solar panels may be required. Using a
cloth and warm soapy water, wipe off any foreign matter before rinsing the panels with fresh
water.
2. Battery Check - inspection of batteries should be performed every one year to ensure
that the charger, battery and ancillary electronics are functioning correctly.
The AH-SA-A serial lights are the compact aviation light with a sealed battery compartment.
This provides the user with the ability to change the battery after years of operation.
1. Push ON/OFF button to OFF mode.
2. Unscrew 4 small screws on the top of the battery box to remove the cover..
3. Disconnect the battery leads and remove battery from the box.
4. Discard old battery in a safe manner.
5. Reattach “+”“-”leads to new battery and place back into box.
6. Refit 4 small screws on the top of battery box.
7. Push ON/OFF button to ON mode, light will come.
Care must be taken to observe the polarity of the battery before the leads are
re-connected, and ensure the replacement battery is correctly fitted. Always discard
old batteries in a safe manner.
If the AH-SA-A serial is to be placed in storage for an extended period, being more than 3
months, please follow the below steps.
All batteries will discharge over time and the rate of discharge is dependent on temperature.
If the light is being stored in temperatures greater than 40°C the battery will discharge
faster.
Please check battery every 3 months and recharge if necessary.
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401
6/6 User Manual - AH-SA-A serial
Place in front of a halogen lamp for 2-3days. (Do not place the halogen light too close to the
solar panel or the panel may be over heated) OR
Check the battery voltage regularly to make sure the unit is charging correctly.
Trouble Shooting
SHENZHEN ANHANG TECHNOLOGY CO., LTD Shenzhen, China www.annhung.com Tel: +86-755-89589401