You are on page 1of 8

58630-1 '8

UNITED STATES ENVIRONMENTAL PROTECTION


AGENCY
WASHINGTON, D.C. 20460
\
OFFICE OF CHEMICAL SAFETY
AND POLLUTION PREVENTION

Mark Mongiovi 12011


Woodstream Corporation
69 N. Locust Street
Lititz, PA 17543

Subject: Notification to add alternate brand names and label claims


EPA Registration No. 58630-1
Primary Brand Name: Dr. T's Snake-A-Way Snake Repelling Granules
Decision No.: 478077
Submission Date: April 19.2013

Dear Mr. Mongiovi:

The Agency is in receipt of your Application for Pesticide Notification under PRN 98-10
dated and.fmds that the action requested falls within the scope of PRN 98-10. The following
alternate brand names have been added to the record:

Alternate Brand Names: Havahart® Since 1940™ Dr. T's Snake-A-Way

Havahart® Since 1940™ Dr. T's Snake-A-Way Snake


Repelling Granules

Snake-A-Way Snake Repelling Granules

The label submitted with the application has been stamped "Notification" and will be
placed in our records. If you have any questions, please contact Gene Benbow at (703) 347-0235
or via email at benbow.gene@epa.gov.

Sincerely,

Gene Benbow
Wildlife Biologist
Insecticide-Rodenticide Branch
Registration Division (7505P)
Please read instructions on reverse before competing form. Form Approveu, OMB No. 2070-0060, Approval expires 05-31-98
United States D Registration OPP Identifier
SLEPA Environmental Protection Agency D Amendment
Number

Washington, DC 20460
Ex] Other: NOTIFICATION
Application for Pesticide - Section I
1. Company/Product Number 2. EPA Product Manager 3. Proposed Classification
John Hebert
58630-1

4. Company/Product (Name)
Dr. T's Snake-A-Way Snake Repelling Granules
PM#
07
None D Restricted
5. Name and Address of Applicant (Include ZIP Code) 6. Expedited Review. In accordance with FIFRA Section 3(c)(3)
Woodstream Corporation (b)(l), my product is similar or identical in composition and labeling
69 N. Locust Street to:
Lititz, PA 17543-0327 EPA Reg. No.
Check if this is a new address Product Name
Section - II
I I Amendment - Explain below. I I Final printed labels in response to Agency letter dated.
I I Resubmission in response to Agency letter dated_ I I "Me Too" Application
iXl Notification - Explain below. LJ Other - Explain below
Explanation: Use additional page(s) if necessary. (For Section I and Section II.)
Notification of Label Action Per PR-Notice 1998-10: Please reference the attached explanation
This notification is consistent with the provisions of PR NOTICE 98-10 and EPA Regulations at 40 CFR 152.46, and no other
changes have been made to the labeling or the confidential statement of formula of this product. I understand that it is a
violation of 18 USC Sec. 1001 to willfully make false statements to EPA. I further understand that if this notification is not
consistent with the terms of PR NOTICE 98-10 and 40 CFR 152.46, this product may be in violation of FIFRA and I may be
subject to enforcement action and penalties under sections 12 and 14 of FIFRA.
Section - III
1. Material This Product Will Be Packaged In:
Child-Resistant Packaging Unit Packaging Water Soluble Packaging 2. Type of Container
D Yes* D Yes D Yes [H Metal
KI No IEI No IEI No [3 Plastic
If "Yes" No. per If "Yes" No. per D Glass
Unit Packaging wgt. container Package wgt. container
*Certification must [~1 Paper- c t c
be submitted D OtheV(Specifiy) _
3. Location of Net Contents Information 4. Size(s) Retail Container 5. Location of Label Directions1"
Label Container [SonLabel
p==: t ccccc t
1.75lb, 4lb, 28lb, 236lb I [ On^abe'iind, accompanying product
C C Q
6. Manner in Which Label is Affixed to Product Lithograph D Other.
Paper glued
D Stenciled
Section - IV
1. Contact Point (Complete items directly below for identification of individual to be contacted, if necessary, to process this application)'
Name Title TelephonevNo. (Include Area Code)
Chad Mateer Regulatory Affairs Manager 717416-2125 x426
Certification 6. Date Application
I certify that the statements I have made on this form and all attachments thereto are true, accurate and complete. I Received
acknowledge that any knowingly false or misleading statement may be punishable by fine or imprisonment or both (Stamped)
under applicable law.
2. Signature 3. Title
Regulatory Affairs Specialist
4. Typed Name 5. Date
Mark Mongiovi 4-19-13
EPA Form 8570-1 (Rev. 8-94) Previous editions are obsolete White- EPA File Copy (original) Yellow- Applicant Copy
69 N. Locust Street

woodstream
C O R P O R A T I O N
P.O. Box 327
Lititz, PA 17543-0327
(717)626-2125
Fax: (717)626-5350
www.woodstreamcorp.com

April 19,2013

Document Processing Desk [MOTIF]


Office of Pesticide Programs (7504P)
U.S. Environmental Protection Agency
Room S-4900, One Potomac Yard
2777 South Crystal Drive
Arlington, VA 22202-4501

ATTN: Notification Division


SUBJECT: Woodstream Corporation
Notification of Label Action Per PR-Notice 1998-10
Dr. T's Snake-A-Way Snake Repelling Granules (EPA Reg. No. 58630-1)

Enclosed please find a Notification of Label Action Per PR-Notice 1998-10 for Additional Brand Names
and Other Minor Revisions for the subject product. Also enclosed, please find a copy of our revised
master label with changes highlighted and a clean copy for your records.

If you have any questions and/or need any additional information, please contact me at (717) 626 -2125
ext: 219 or email mmongiovi@woodstream.com.

Sincerely,

Mark Mongiovi
Regulatory Affairs Specialist C
C CC t
C
C C C C
Woodstream Corporation C t t C
t
<_ t C c

0 C C
C C t- I

Enclosures:
Notification of Label Action
Copy of revised master label with changes highlighted
Clean copy of revised master label
EPA Reg. No. 58630-1
EPA Label Notification - Additional Brand Names/Other Minor Revisions - Revised per Agency request
May 1,2013
Page 1 of 5

MASTER LABEL - FRONT PANEL (Page 1 of 1)

DRT'S SNAKE-A-WAY SNAKE REPELLING GRANULES

[Additional Brand Names}

Dr. T's Rat-A-Way Rat and Mice Repelling Granules


Havahart® Since 1940™ Dr. T's Snake-A-Way
Havahart® Since 1940™ Dr. T's Snake-A-Way Snake Repelling Granules
Snake-A-Way Snake Repelling Granules

[Optional Logos/Marketing Claims}

Dr. T's Nature Products The Repellent Co. [logo]


Professional Tested
Havahart® Since 1940™

ACTIVE INGREDIENTS: BY WT.


Naphthalene 7.0%
Sulfur 28.0%
OTHER INGREDIENTS 65.0%
TOTAL 100.0%

KEEP OUT OF REACH OF CHILDREN


CAUTION I (See side/back panel for additional precautionary statements &firstaid)

Net Contents: 1.75 Ibs (0.794 kg), 41bs (1.814 kg), 281bs (12.700kg), 2361bs (107.047kg)
'8
EPA Reg. No. 58630-1
EPA Label Notification - Additional Brand Names/Other Minor Revisions - Revised per Agency request
May 1,2013
Page 2 of 5

MASTER LABEL - BACK PANEL (Page 1 of 3)

PRECAUTIONARY STATEMENTS:
HAZARDS TO HUMANS & DOMESTIC ANIMALS
CAUTION: Harmful if swallowed or absorbed through skin. Harmful if inhaled. Causes moderate eye irritation. Avoid
contact with skin, eyes or clothing. Avoid breathing dust.

FIRST AID
Have label with you when obtaining treatment advice.
Call a poison control center or doctor immediately for treatment advice.
If swallowed: Have person sip a glass of water if able to swallow.
Do not induce vomiting unless told to do so by the poison control center or
doctor.
Do not give anything by mouth to an unconscious person.
Take off contaminated clothing.
If on skin or clothing: Rinse skin immediately with plenty of water for 15-20 minutes.
Call a poison control center or doctor for treatment advice.
Move person to fresh air.
If inhaled: If person is not breathing, call 91 1 or an ambulance, then give artificial
respiration, preferably mouth-to-mouth, if possible.
Call a poison control center or doctor for further treatment advice.
Hold eye open and rinse slowly and gently with water for 1 5-20 minutes.
If in eyes: Remove contact lenses, if present, after first five minutes, then continue
rinsing eye.
Call a poison control center or doctor for treatment advice.
NOTE TO PHYSICIAN
If breathing is difficult, give oxygen.
Have the product container or label with you when calling a poison control center or doctor or going for treatment.
You may also contact the National Pesticides Information Center at 1-800-858-7378, 6:30 AM to 4:30 PM Pacific
Time (PT), seven days a week for emergency medical treatment information. During other times, call the poison
control center at 1-800-222-1222.

ENVIRONMENTAL HAZARDS:
This product is toxic to fish. Do not apply directly to water, or to areas where surface water is present or to intertidal areas
below the mean high water mark. Do not contaminate water when cleaning equipment or disposing of equipment
washwaters or rinsate.

DIRECTIONS FOR USE:


It is a violation of federal law to use this product in a manner inconsistent with its labeling.

IMPORTANT: Keep out of reach of children. Do not place in areas accessible to children.

SNAKES:
USE RESTRICTIONS: FOR OUTDOOR USE ONLY. APPLY ONLY AS DIRECTED ON LABEL. To repel rattlesnakes
(Genus Crotalus) and garter snakes (Genus Thamnophis) from areas around houses, cabins, trailers, garages, utility houses,
barns, woodpiles, sand piles, trash cans, and flower beds. This product may also be used around the periphery of flower
gardens. Do not use this product at sites where snakes are believed to be already present.
EPA Reg. No. 58630-1
EPA Label Notification - Additional Brand Names/Other Minor Revisions - Revised per Agency request
May 1,2013
Page 3 of 5

MASTER LABEL - BACK PANEL (Page 2 of 3)


Use in spring, summer, and fall when outdoor temperatures are conducive to snake activity.

Do not apply this product in gardens or in fields of crops grown for food or feed. Do not use this product near streams, ponds
pools, or water supplies.

APPLICATION DIRECTIONS: Using gloves, apply SNAKE-A-WAY IN BANDS SURRONDING THE AREA TO BE
PROTECTED. Use bands 4 to 5 inches wide to repel garter snakes. For rattlesnakes, use bands 8 to 12 inches wide. In yards,
lightly sprinkle Snake-A-Way over the area within the treatment band.

When the odor of Snake-A-Way becomes faint, its effectiveness may be diminished. If this occurs during the season when
snakes are active, retreat with enough of the product to restore the original odor intensity. Retreatment may also be necessary
after heavy rains.

RATS AND MICE:


USE RESTRICTIONS: FOR OUTDOOR USE ONLY. APPLY ONLY AS DIRECTED ON LABEL. This product may be
used to limit damage by house mice (Mus musculus). Norway rats (Rattus norvegicus). or roof rats (R. rattus) to garbage
bags placed near residences and other buildings or to garbage bags placed along streets or alleys for garbage collection.

Do not use this product in gardens or in fields of crops grown for food or feed. Do not use this product near streams, ponds
pools, or water supplies, or sewers.

APPLICATION DIRECTIONS: Using gloves, apply in a lightly sprinkled band around the area where garbage bags are
placed. Beginning no more than one foot out from the outermost bags, lightly broadcast until band of product is 24 inches
wide. When the odor becomes faint, its effectiveness may be diminished. Retreatment may also be necessary after heavy,
washing-type rains.

STORAGE & DISPOSAL: [For Non-Refillable Containers Weighing 50 Ibs. or Less]


PESTICIDE STORAGE: Store only in original container, in a cool, dry, and well-ventilated location inaccessible to
children, and pets.
PESTICIDE DISPOSAL AND CONTAINER HANDLING: Non-refillable container. Do not reuse or refill this
container. If Empty: Place in trash or offer for recycling if available.
If Partly Filled: Call your local solid waste agency for disposal instructions. Never place unused product down any indoor
or outdoor drain.
STORAGE & DISPOSAL: {For Non-Reflllable Containers Weighing More than 50 Ibs.]
Do not contaminate water, food or feed by storage or disposal.
STORAGE: Store in original container in a cool, dry, and well-ventilated location inaccessible to children, domestic
animals, and pets.
PESTICIDE DISPOSAL: Pesticide wastes are toxic. Improper disposal of excess pesticide, spray mixture, or rinsate is a
violation of Federal Law. If these wastes cannot be disposed of by use according to label instructions, contact your State
Pesticide or Environmental Control Agency, or the Hazardous Waste representative at the nearest EPA Regional Office for
guidance.
CONTAINER HANDLING 1 : Triple rinse (or equivalent). Then offer for recycling if available or reconditioning if
appropriate, or puncture and dispose of in a sanitary landfill, or incineration, or if allowed by state or local authorities, by
burning. If burned, stay out of smoke.

1
This "Container Handling" statement is for a "plastic container". For product in another type of container, use
the proper text listed in EPA PR Notice 83-3, Appendix A (Container Disposal Statements).
EPA Reg. No. 58630-1
EPA Label Notification - Additional Brand Names/Other Minor Revisions - Revised per Agency request
May 1,2013
Page 4 of 5

MASTER LABEL - BACK PANEL (Page 3 of 3)


Note: Seller warrants that this product complies with the specifications expressed in this label. To the extent
consistent with applicable law, Seller makes no other warranties, and disclaims all other warranties, express or
implied, including but not limited to warranties of merchantability and fitness for the intended purpose. To the extent
consistent with applicable law, Seller's liability or default, breach or failure under this label shall be limited to the
amount of the purchase price. To the extent consistent with applicable law, Seller shall have no liability for
consequential damages.

Distributed By:
Woodstream Corporation
69 N. Locust St
Lititz,PA 17543
(717)626-2125

EPA Reg. No. 58630-1

EPAEst. No. 69208-MO-001

©
Copyright 2009 Woodstream Corp.
Made In USA
EPA Reg. No. 58630-1
EPA Label Notification - Additional Brand Names/Other Minor Revisions - Revised per Agency request
May 1,2013
Page 5 of 5

MASTER LABEL - OPTIONAL CLAIMS (Page 1 of 1)

[Additional- Optional Marketing/Advertising Claims]

• Look for other Dr. T's products at www.drtsnatureproducts.com.


• Repels Rattlesnakes!
• Snake Repellent
• Snake Repelling Granules
• Rat Repellent
• Mice Repellent
• Mouse Repellent
• Use around houses, cabins, trailers, garages, utility houses, barns, woodpiles, sand piles, trash
cans, and flower beds
• Use around garbage bags
• University Tested
• Independently Tested
• Ready-To-Use
• Made in the USA

You might also like