Professional Documents
Culture Documents
Presentation 4-2 Troubleshooting
Presentation 4-2 Troubleshooting
Presentation 4-2 Troubleshooting
S600+ Troubleshooting
Power Issue
Check the wiring connections at terminal block TB1 on the CPU back plate
and the wiring at the power source.
After initialization, if the Startup menu appears instead of the Main menu, select
the Warm Start option. If a warm start does not occur:
Check jumper J2 on the CPU module. If it is in the closed (cold start) position,
then move it into the open (warm start) position to allow a warm start. This
also allows the unit to bypass the Startup menu in the future.
Check the display for text and numbers. If the screen is entirely blank, contact
your local sales representative or technical support.
Front Panel LED Issue
If the LED on the front panel indicates alarm and malfunction states:
If the LED is orange, power down the S600+, remove and reseat the boards,
and then re-apply power to the S600+.
Note: The LED is orange while at the Startup menu. If it is still orange when the
configuration is running, contact your local sales representative or technical
support.
IO LED Issue
If the red or green LEDs on the backplate of the I/O module do not blink while
the S600+ is operating:
Check the I/O module connections. Power down, remove and reseat the I/O
module, and then re-apply power.
Check the front panel display and LED. If they are not lit, you may have a
power issue.
Check with the person who configured the unit whether you have the correct
I/O module fitted.
Check the running configuration for any BAD TX or BAD RX messages. From
the Main menu, select TECH/ENGINEER > COMMUNICATIONS > SERIAL
PORTS > PORT 08.
IO Fail Message
If the front panel displays an I/O Fail message:
Check the communication port settings from the front panel display.