You are on page 1of 6
DISTRIBUTED BY ANAKO PHILIPPINES CORPORATION Page 1 of 6 MICROFAST® QUICK RESPONSE HORIZONTAL, SIDEWALL SPRINKLER VK305 (K5.6) ‘The Viking Corporation, 210 N Industrial Park Drive, Hastings MI 49058 ‘Telephone: 269-945-9501 Technical Services: 877-384-5464 Fax: 269-818-1680 Email: techsvcs@vikingcorp.com 4. DESCRIPTION ‘The Viking Microfast® Quick Response Horizontal Sidewall Sprinkler VK305 is a small thermosensttive glass bulb spray sprinkler available with varus finishes and tempera ture ratings to meet design requirements. The special Polyester and Electroless Nickel PTFE (ENT) coatings can be used in decorative applications where colors are de- sired. In addition, these coatings have been investigated for installation in cortosive atmospheres and’ are listod/approved as corrosion resistant as indicated in Approval Charts, 2. LISTINGS AND APPROVALS <®x. cULus Listed: Category vAIv ‘ FM Approved: Cass 2020 Sefer to Approval chert 1 and Design Criteria for cULus Laing requirements, and refer to Approval Chart 2 end Deign Citta for FM Approval equrements tht must be olowed 3. TECHNICAL DATA Specifications: Minimum Operating Pressure: 7 psi (0.5 bar) Rated to 175 psi (12 bar) water working pressure Factory tested hydrostatically to 500 ps (34.5 bar) Nominal K-Factor: 5.6 U.S, (80.6 metric) * Metre Kfacor measurement shown i when pressure fs measured in Bar. When pressure Viking Technical Data may be found on is measured in KPa, cv the metre Kctor shown by 100 ‘Tha Vicig Corporation's Web ala at Overall Length: 2-3/4" (68 mm) httptwww.vikinggroupine.com. Material Standards: ‘The Wob site may include a more recent Frame Casting: Brass UNS-C84400 or QM Brass edition ofthis Technical Data Page. Deflector. Copper UNS-C19500 Bulb: Glass, nominal 3 mm diameter Bellavile Spring Sealing Assembly: Nickel Allay, coated on both sides with PTFE Tape Screw, Brass UNS-C36000 Pip Cap and Insert Assembly: Copper UNS.C11000 and Stainless Stee! UNS-S30400 For Polyester Coated Sprinklers: Bellevile Spring-Exposed For ENT Coated Sprinklers: Belleville Spring - Exposed, Screw and Pip cap - ENT plated, Ordering Information: (Also refer to the current Viking pricelist.) Order Viking Microfast® Quick Response Horizontal Sidewall Sprinkler VK305 by first adding the appropriate sufi forthe sprin- ler finish and then the appropriate suffix for the temoeretute rating to the sprinkler base part number. Finish Suffix: Brass = A, Chrome = F, White Polyester = MW, Black Polyester = MB, and ENT = JN Temperature Suffix: 135 °F / 68 °C =A, 155 °F /68 °C = B, 175 °F /79°C = D, 200°F / 93 °C = E, and 286 °F/ 141 °C=6 For example, sprinkler 12997 with @ Brass finish and a 155 °F /68 °C temperature rating = Part No. 12907AB Available Finishes And Temperature Ratings: Refer to Table 1 ‘Accessories: (Also refer tothe “Sprinkler Accessories” section ofthe Viking data book.) Sprinkler Wrenches: ‘A. Standard Wrench: Part No. 10896W/B (availabe since 2000), Wrench for recessed andlor wax coated sprinklers: Part No. 13655W/B"* (available since 2006) “A. ratchet is required (not avaible fom Viking) Sprinkler Cabinets: ‘A Sichead capacity: Part No. 01724A (available since 1971) B. Twelveshead capacity: Part No, 01725A (available since 1971) TECHNICAL DATA Form No. F_060914 Rev 14.2 (Added 12121) WTe Guezon Averue Cor Fara Quezon Cy (2) 808 6) 27 Ot | 62) 90089 162 NA | 28 Leading in Quality! DISTRIBUTED BY ANAKO PHILIPPINES CORPORATION Page 2 of 6 MICROFAST® QUICK RESPONSE HORIZONTAL ‘SIDEWALL SPRINKLER VK305 (K5.6) ‘The Viking Corporation, 210 N Industrial Park Drive, Hastings MI 49058 Telephone: 269-945-9501 Technical Services: 877-384-5464 Fax: 269-818-1680 Email: techsvcs@vikingcorp.com 4, INSTALLATION Refer to appropriate NFPA Installation Standards, 5. OPERATION During fre conditions the heat sensitive fusible Ink disengages, the pip cap and spring are released, and the waterway is opened Water flowing through the sprinkler orifice strikes the sprinkler deflector, forming a uniform spray pattem fo extinguish or control the fre 6. INSPECTIONS, TESTS AND MAINTENANCE Refer to NFPA 25 for Inspection, Testing and Maintenance requirements, 7. AVAILABILITY Viking Microfast® Quick Response Horizontal Sidewall Sprinkler VK30S is available through a network of domestic and interna tional distributors, See The Viking Corporation wed site forthe closest distributor or contact The Viking Corporation. 8. GUARANTEE For details of warranty, refer to Vking’s current list price schedule or contact Viking directly, Bert Ne) VED) Wrench Flat’ Figure 1 Standard Sprinkler Wrench 10896WB, Form No. F_060914 Rev 14.2 WTe Guezon Averue Cor Fara Quezon City Te 8) 84005 [62 027 OSD | 39205 ez} 2 anan ezse 62) 928 4808 Leading in Quality! DISTRIBUTED BY ANAKO PHILIPPINES CORPORATION NIKING ‘The Viking Corporation, 210 N Industrial Park Drive, Hastings MI 49058 Telephone: 269-945-9501 Technical Services: 877-384-5464 Fax: 269-818-1680 Email: techsvcs@vikingcorp.com Page 3 of 6 MICROFAST® QUICK RESPONSE HORIZONTAL ‘SIDEWALL SPRINKLER VK305 (K5.6) TECHNICAL DATA Core eo una ens Ordinary 135 *F (67 °C) 100 *F (38°C) Orange ‘Ordinary 185 °F (68°C) 100 °F (38°C) Red Intermediate 175 *F (78°C) 150 *F (65°C) Yellow Intermediate 200 °F (93°C) 150 °F (65°C) Green| High 286 °F (141°C) 225 F (107°C) Bue ‘Sprinkler Finishes: Brass, Chrome, White Polyester, Black Polyester, and ENT Corrosion-Resistant Coatings”: White Polyester, Black Polyester, and ENT Footnotes "The sprinkler temperature rating is stamped on the defector. 2 Based on NFPA3. Other ints may apply, depending on fire loading, sprinkler locaton, and other requirements of the Authority Having Jurisdiction, Refer to spect insallaion standards » The coreson-esistant coatings have passed the sindard corrosion tes required by the approving agencies indicated inthe Approval Charts. These tests cannot and donot represent al possible corosiveenvronments, Prior to instalation, vl tough the end-use tha the coatings are compat ibe with or suitable forthe proposes envicrment For automatic sprinkles, the coatngs indicated are applied to the exposed exterior surfaces cnly Fer ENT coated sprirkers, the waterway is coated. Note thatthe spring is exposed on sprinklers wth Polyester, and ENT coatings. Step 1: Carefully slide the wrench sideways around the deffector, ensuring en agement with the sprinkler wrench Mat. > @ 2 = > Sprinkler wrench 1365816" Trust be used for instaling | wax coated spies. I “A 112" ratchet is required ‘Step 2: Carefully press the wronch onto the (not available from Viking) sprinkler wrench fats Figure 2: Wrench 13855WIB for Recessed Sprinklers Forni No, F_06001% Rav 14 Te Guezon Averue Cor Fara Quezon Cy (2) 8s 6) 27 Ot 63) 90089 ez) ana os 62) 9284008 Leading in Quality! DISTRIBUTED BY ANAKO PHILIPPINES CORPORATION Page 4 of 6 MICROFAST® QUICK RESPONSE HORIZONTAL use eh SIDEWALL SPRINKLER 'VK305 (K5.6) The Viking Corporation, 210 N Industrial Park Drive, Hastings MI 49058 sphone: 269-945-9501 Technical Services: 877-384-5464 Fax: 269-818-1680 Email: techsvcs@vikingcorp.com Listings and Approvals® Rete sso to Design Cera on page 43) Nominal K-Factor | Overall Length ase Par | Thread Size Base Part | gy | Sprinkle fore Sule [wer | BSP, US. | metre’ | Inches | mm | cULus' | upca | (€ | © ae? | vaos| usw | v2 | 1smm| so | coe |onne| os | MVE | 7 3 CW, Daz " " i ANY. B1K, waar [vnsos] sw | 2 | 5mm] 56 | one [inne] oo | MV BK ‘Approved Temperature Ratings ee |W Installed wth standard surface mourtedeszutcheons JA = 138 °F (67 °C), 155 °F (68 70), 175 X- installed with stancaré surface mounted escuteheans or “F (79 *C), 200 “F (83 °C), and 286 “F aap Approved Finishes the Viking Microfat? Modi F-1 Ajustable Escutcheon, B= 195 -F 57 °C), 185 “F (68°C), 175 F| 1 = Brass, Chrome, White Polyester, or recessed with he Viking Miromatic® Model Et, €:2 ar hl and Black Polyester* 0F G-1 Recessed Escutcheon j2-ENT YY-nstallee wih stancars surface-mounted escutcheons or Jo 185 °F (68 °C), 175 °F (78 0), 200° (93°C), and 206 (141 °0) D155 °F (68°C), 175 °F (79°C), and 200 $F 83") the Viking Micofast* Model F-1 Adjustable Escutcheon Z- nsaled with standard surface-mounted escutcheons or recessed with the Viking Micromatic Model E-1 Footnotes "Base pat number shown. For complete part number, refer to Viking’ cutent price schedule etc Ktactor measurement shown s when pressure is measured in Bar. When pressure is measured KPa, dhde the metic K ator shown by 10.0 This table shove the lings and approvals avalabe atthe time of printing. Other approvals may be in proces, “Listed by Underwriters Laboratories Inc. or use n the U.S. and Canada eULus Listed as coroslon resistant. * other colors are avaiable on request with the same Listings and Approvals as the standard colors, ‘cULus Listing Requirements: (Quick Response Horizontal Sprinkler VK305 i cULus Listed as indicated in Approval Chat 1 for instalation in accordance with the latest econ of NFPA 13 for sidewal slandara spay spines + Designed for use in Light and Ordinary Hazard occupancies + Locate withthe deflector 4" to 12" (102 mm to 305 mm) below the cling + Protecton areas and maximum spacing shall bein accordance withthe tables provide in NFPA 13, + Minimum spacing allowed is 6 f. (1.8 m) + Align the top of the defector parallel withthe ceiling, + Locate no less than 4 (102 mm) from end walls + Maximum distance rom end walls shall be no more then one-half of he ellowable dsiance between sprinklers, The dstance shall be measured petpendiular tothe wal, +The eprnklerietllaton and obetructon rules contained in NFPA 13 for sidewall standard spray epinlers must be fllowed IMPORTANT: Always refer to Bulletin Form No. F_091699 - Care and Handling of Sprinklers. Also refer to page QR1-3 for general care, installation, and maintenance information. Viking sprinklers are to be installed in accor- dance with the latest edition of Viking technical data, the appropriate standards of NFPA, LPCB, APSAD, VdS. or other similar organizations, and also with the provisions of governmental codes, ordinances, and standards, ‘whenever applicable. Form No. F_060914 Rev 14.2 “We Guezon Avenue Gor Fea Quezon Gly (2) 808 6) 27 Ot | 62) 90089 (2 SANA | 8 Leading in Quality! DISTRIBUTED BY ANAKO PHILIPPINES CORPORATION Page 5 of 6 MICROFAST® QUICK RESPONSE HORIZONTAL seit S bis SIDEWALL SPRINKLER VK305 (K5.6) Base Pat | gy Thread Sie | Nominal KFactor | Overall Length FM Approvals Number’ net | ssP_| us. | metrct | inches | mm (Rete sto to Beslan Criteria below) “2007 36 | aoe | 216 | 68 AY. BK 12121 os | 21016 ANY BK ‘Approved Temperature Ratings Approved Escutcheons. Fepeeeesanieaceentnbennte| fier ete eee a 1-7 7"0, 18 F08°0.75] — aensarnen | etm senate Weg re) ca Mice niaee ts esas manne ostionn : sae eens on testes

You might also like