Professional Documents
Culture Documents
Safety Data Sheet Ultra Coolant China English
Safety Data Sheet Ultra Coolant China English
Product name: Ingersoll Rand Ultra Coolant Date of first issue: 19.03.2019
SDS Number: Issue Date: 19.03.2019
Print Date: 02.04.2019
INGERSOLL RAND encourages and expects you to read and understand the entire
(M)SDS, as there is important information throughout the document. We expect you to follow the
precautions identified in this document unless your use conditions would necessitate other appropriate
methods or actions.
COMPANY IDENTIFICATION
Distributed By
INGERSOLL RAND
800D BEATY ST
DAVIDSON, NC 28036
UNIITED STATES
2. HAZARDS IDENTIFICATION
Emergency Overview
Appearance Liquid.
Color Brown
Odor Mild
This product is not hazardous per the Globally Harmonized System of Classification and
Labelling (GHS).
Page 1 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
GHS Classification
This product is not hazardous per the Globally Harmonized System of Classification and Labelling
(GHS).
Health hazards
Not classified based on available information.
Environmental hazards
Not classified based on available information.
Other hazards
No data available
3. COMPOSITION/INFORMATION ON INGREDIENTS
Fatty acids, C5-C10, esters with 68424-31-7 > 25.0 - < 30.0 %
pentaerythritol
Page 2 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
Eye contact: Flush eyes thoroughly with water for several minutes. Remove contact lenses after the
initial 1-2 minutes and continue flushing for several additional minutes. If effects occur, consult a
physician, preferably an ophthalmologist.
5. FIREFIGHTING MEASURES
Extinguishing media
Suitable extinguishing media: Water fog or fine spray. Dry chemical fire extinguishers. Carbon
dioxide fire extinguishers. Foam. Alcohol resistant foams (ATC type) are preferred. General purpose
synthetic foams (including AFFF) or protein foams may function, but will be less effective.
Unsuitable extinguishing media: Do not use direct water stream. May spread fire.
Unusual Fire and Explosion Hazards: Container may rupture from gas generation in a fire situation.
Violent steam generation or eruption may occur upon application of direct water stream to hot liquids.
Page 3 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
Environmental precautions: Material will float on water. Prevent from entering into soil, ditches,
sewers, waterways and/or groundwater. See Section 12, Ecological Information.
Methods and materials for containment and cleaning up: Contain spilled material if possible.
Collect in suitable and properly labeled containers. See Section 13, Disposal Considerations, for
additional information.
Conditions for safe storage: Store in the following material(s): 316 stainless steel. Carbon steel.
Glass-lined container. Polypropylene. Polyethylene-lined container. Stainless steel. Teflon. This
material may soften and lift certain paint and surface coatings. Use product promptly after opening.
Store in original unopened container. Unopened containers of material stored beyond the
recommended shelf life should be retested against the sales specifications before use. Additional
storage and handling information on this product may be obtained by calling your sales or customer
service contact.
Storage stability
Shelf life: Use within
5 year
Exposure controls
Engineering controls: Use local exhaust ventilation, or other engineering controls to maintain
airborne levels below exposure limit requirements or guidelines. If there are no applicable exposure
limit requirements or guidelines, general ventilation should be sufficient for most operations. Local
exhaust ventilation may be necessary for some operations.
Page 4 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
Page 5 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
NOTE: The physical data presented above are typical values and should not be construed as a
specification.
Incompatible materials: Avoid contact with: Strong acids. Strong bases. Strong oxidizers.
Hazardous decomposition products: Decomposition products depend upon temperature, air supply
and the presence of other materials. Decomposition products can include and are not limited to:
Aldehydes. Alcohols. Ethers. Hydrocarbons. Ketones. Organic acids. Polymer fragments.
Acute toxicity
Acute oral toxicity
Very low toxicity if swallowed. Harmful effects not anticipated from swallowing small amounts.
Page 6 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
At room temperature, exposure to vapor is minimal due to low volatility; single exposure is not
likely to be hazardous. For respiratory irritation and narcotic effects: No relevant data found.
As product: The LC50 has not been determined.
Skin corrosion/irritation
Brief contact is essentially nonirritating to skin.
Repeated contact may cause severe skin irritation with local redness and discomfort.
Sensitization
Did not cause allergic skin reactions when tested in guinea pigs.
Carcinogenicity
No specific, relevant data available for assessment.
Teratogenicity
No specific, relevant data available for assessment.
Reproductive toxicity
No specific, relevant data available for assessment.
Mutagenicity
No specific, relevant data available for assessment.
Aspiration Hazard
Based on physical properties, not likely to be an aspiration hazard.
Page 7 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
Ecotoxicity
Acute toxicity to fish
Material is practically non-toxic to aquatic organisms on an acute basis
(LC50/EC50/EL50/LL50 >100 mg/L in the most sensitive species tested).
LL50, Oncorhynchus mykiss (rainbow trout), static test, 96 Hour, > 100 mg/l, OECD Test
Guideline 203 or Equivalent
Incubation BOD
Time
5d 5%
10 d 8%
20 d 10 %
28 d 31 %
Bioaccumulative Potential
Page 8 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
Mobility in Soil
No specific, relevant data available for assessment.
Page 9 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
The following statutes, regulations and standards have the related prescribes on chemicals in terms of
safe use, storage, transportation, loading and unloading, classification and symbol etc.
Provisions on the Environmental Administration of New Chemical Substances.
The Regulation on Chemicals Safe Use at Working Site
Law on Prevention and Control of Environmental Pollution Caused by Solid Waste.
Occupational Exposure Limits for Hazardous Agent in The workshop Chemical Hazardous
Agents(GBZ 2.1).
Revision
Identification Number: / A145 / Issue Date: 19.03.2019 / Version: 12.0
Most recent revision(s) are noted by the bold, double bars in left-hand margin throughout this
document.
Legend
ACGIH USA. ACGIH Threshold Limit Values (TLV)
GBZ 2.1-2007 Occupational exposure limits for hazardous agents in the workplace - Chemical
hazardous agents.
PC-STEL Permissible concentration - short term exposure limit
PC-TWA Permissible concentration - time weighted average
TWA 8-hour, time-weighted average
Page 10 of 11
RELEASED 17/Sep/2019 21:16:43 GMT
IMDG - International Maritime Dangerous Goods; IMO - International Maritime Organization; ISHL -
Industrial Safety and Health Law (Japan); ISO - International Organisation for Standardization; KECI -
Korea Existing Chemicals Inventory; LC50 - Lethal Concentration to 50 % of a test population; LD50 -
Lethal Dose to 50% of a test population (Median Lethal Dose); MARPOL - International Convention for
the Prevention of Pollution from Ships; n.o.s. - Not Otherwise Specified; Nch - Chilean Norm;
NO(A)EC - No Observed (Adverse) Effect Concentration; NO(A)EL - No Observed (Adverse) Effect
Level; NOELR - No Observable Effect Loading Rate; NOM - Official Mexican Norm; NTP - National
Toxicology Program; NZIoC - New Zealand Inventory of Chemicals; OECD - Organization for
Economic Co-operation and Development; OPPTS - Office of Chemical Safety and Pollution
Prevention; PBT - Persistent, Bioaccumulative and Toxic substance; PICCS - Philippines Inventory of
Chemicals and Chemical Substances; (Q)SAR - (Quantitative) Structure Activity Relationship; REACH
- Regulation (EC) No 1907/2006 of the European Parliament and of the Council concerning the
Registration, Evaluation, Authorisation and Restriction of Chemicals; SADT - Self-Accelerating
Decomposition Temperature; SDS - Safety Data Sheet; TCSI - Taiwan Chemical Substance Inventory;
TDG - Transportation of Dangerous Goods; TSCA - Toxic Substances Control Act (United States); UN
- United Nations; UNRTDG - United Nations Recommendations on the Transport of Dangerous
Goods; vPvB - Very Persistent and Very Bioaccumulative; WHMIS - Workplace Hazardous Materials
Information System
Page 11 of 11