ELEKTRA SERIES
|.T GRADE ONLINE DOUBLE CONVERSION UPS
lsolation Transformer (Optional)
SLA and LIFE Po4 Compatible
1KVA ~ 10KVA (1/1)
[isso Critical &
1.1 Grade UPSElektra Series H.F range of On Line Double Conversion
UPS's uses microprocessor control technology intended
in particular for users of critical systems that require
reliability and high performance at the same time
(telecommunications equipment, critical industrial
applications, et.)
Elektra uses technology which delivers a perfect sinusoidal
output current and provides effective protection of critical
devices.
Elektra Series UPS's provides an upgraded power factor
reaching 0.9 and 2 for single phase systems, therefore
offer higher performance and improved efficiency for
Vital applications,
Pe Ate
hen loratenttrsmen nian
eres meer
race nwinerarace a
Tat theghielta
ere as
ree ies
me
feel eldd ol Joc
ee
ia
LN [dell yb bused
ees
ee
ee ie
Fer aaeignreceeate
ae
eae ehlatep dead
manually-activated battery tests).
ore
Ta,
fee ee
cierto
eee
sey, products pollution control management
2S
O22
using itONLINE DOUBLE CONVERSION UPS (EI
Active Input Power Factor Correction (Pfc)
With digital control of active power factor correction
technology, enables high input power factor 0.99 above
as to avoid contamination of electrical network
environment, saving energy and reducing system costs.
Compatible With Generators
Input voltage and frequency range is wide so can
effectively works on generator sets and thus provide
pure, safe and stable power.
Power Factor 0.9/1
‘Adapting the current most electrical devices type it
enhances the ability for supporting load of the
machine. 0.9 & 1 power factor.
Parallel Connecti
‘Output Switchboard
aes fe
Parallel! Configuration
N+X is currently the most reliable power supply
structure.
N represents the minimum required UPS number that
the total load needs; X represents the redundant UPS
number. The bigger the X is, the higher reliability of
the power system is. For occasions where reliability
Is highly required, N+X is the optimal mode up to 3
of them can be connected in parallel to support
output power sharing and power redundancy.
DSP Digital Control Technology
SP advanced digital control technology UPS, increases
performance, stability, quality and reliability.
Isolation Transformer (Optional)
New Concept and designing now allow for built in
Isolation Transformer at Input or Output make the
product reliable and ready for harsh environment.
High Quality Output Voltage
Even with non-linear loads (IT loads with a crest factor
of up to 3:1)
High short circuit current on bypass
High overload capacity: 150% by inverter (even with
‘mains failure)
Filtered, stabilised and reliable voltage (double
conversion on-line technology (VFI compliant with
EN62040-3), with filters for the suppression of
atmospheric disturbances.
Power factor correction: UPS input power factor close
to Land sinusoidal current uptake.
ktra Seri
Wide Input Voltage & Frequency Range
Very wide input voltage and frequency ranges,
even in harsh electrical environments will work
in stable mode,which reduces the number of
battery discharge resulting in extended battery
life
Powerful Extensibility Features
Smart slot provides rich scalable features, USB
can be selected, AS400 card, SNMP card, RS4BS
card and environmental monitoring card.
Standards
FOR 1/2/3 KVA UPS products comply with
£EN50081-1 / ENSS022 Class B - ENS0082-1 / 1EC8O1-
2 LEVEL 4 IEC8O1-3 LEVEL 3 - IEC8O1-4 LEVEL 4 -
IEC8O1-5 LEVEL 2(1) 1000VA, 2000VA, and 3000VA
(20/230V-version) products comply with: FCC Part
15 Class A - IEEESA7 Class A(2) The products of
300A (220/230V-version) are Class A digital devices,
Safety : Comply with GB4943-2001, 1EC62040-
Land CE requirements,
Industry Standard:
‘Comply with EN62040,¥0/T 1095-2000 requirements.
FOR 6K/10K/15K UPS products comply with:EN6204
(0-1-1 (Safety).Conducted Emission: ENSO091-2: Lim
its for UPS which have a rated output current excee
ding 25A (25°10)
Radiated Emission: ENS0091-2: Limits for UPS which
have a rated output current exceeding 254 (251008)
EMSENG1000-4-2(€SD). Level 4
EN61000-4-3/RS). Level 3
EN61000-4-4(EFT), = Level
£N61000-4-5 (Lightning Surge) Level 4
ENG1000-2-2 (Immunity to low frequency signal)
s
EY
E
|
Ei
&
F
5
fs
Fy
2
5
Ba
=
Fy
8
a
.
PH
3
a
a
Fs
&ONLINE DOUBLE CONVERSION UPS (Elektra Series)
TECHNICAL SPECIFICATION FOR SINGLE PHASE IN & SINGLE PHASE OUT
‘MODEL Si0i “IRATE “RATA | S10 “UAT | ESH06 “SIARTP| E10 “SIRT
wa 1A 2H HVA ava ana
ance
Warr 0000 3o00W7 onnw | **5a0ow)6000w | *"3000w/10000W
INPUT
Input stem Ingle Phase + Neural r Ground
ated Voge 200/208 220/ 130 / 260VAC
Voltage Range AIOWAC™300VAC_ I T20VAC~2B5VAC
Frequency 0-70
Power Factor 2038
Votage Range Bypa TS I90VAC HSH
joureur —— ——
[Output system Sngle Phase & Eat ground ‘| Sigl Phase + naval roond
Rated Voltage 200/208 /330/ 730 /2aDVAC
Power Factor
Voltage Precision
Frequency Normal 1. The output frequency synchronizes with the Input frequency when the Input
frequency isin the range of 47°53H2 or 57763 Kz
Frequency Battery 5$0/6020.1%
{1059-118 UPS transfer to bypass after 10 minutes when the utility is normal
Overload Capacity 110%~130%:UPS transfer to bypass after 5 minutes when the utility Is normal
130%~150%:UPS transfer to bypass after 1 minutes when the utility Is normal
>1508:UPS transfer to bypass immidiately when the utility is normal
Tansfer Time Ons (Normal modee-——->Battery mode), ms Normal mode <---> Bypass mode)
ees Factor da 4
BATTERY Tied ros Compute 3
voltage re a
Typical Recharga Time ‘hours recover 90% capa =
Charging Amperes TAPIA" 12M AUTO SETA cf
‘GENERAL
Short rul/Batery Low ‘System Feetes [ arm and Switched OF =
Over Heat Tine Made: Switch to bypass. dackup Mode: Shut dowa UPS immediatl &
70 Shut Down immediately rs
Ambient Temp. roare 5
Humility 20%30% (No condensation] 5
Altitude ‘Lower than 1000m: no detracting: Over 1000m 1% detracting for every 100m rise ts
Stroge Temp. asas'e &
oie Level 4084 3
‘Communication interface £5232, USB, [SNMP, Parallel card, Relay card and R45 are optional) et
Isolation Transformer ‘Galvani soltion Type ( Optional Bi
~fudibe & Visul Alara Tine Failure, Gattery low, Over Load, Syste Faull 8
STANDRADS: oa
Seafty TEC/ENED040-EC/ENSO9S0-4 FA
exc TEC feen0H0 CGI a-,[CHI000-4- 3156100044, FC61000-15 [ECCTOOD-L5 RCELOOOAR 2
ficenay 88°93% (AC Mode) 85 ~ 00% (Battery Mode). BA
En Fiter Filer nuded P=
Surge Capa 300 Joules ES
Harmonie DtorionTHOT HR (1005 Linear oad) a
Harmonic Dstorion HOw “BR THO[inar ia) ~