Professional Documents
Culture Documents
Araco Flexible Tile Grout
Araco Flexible Tile Grout
Surface Preparation
Advantages All excess adhesive tiles shall be removed. All the
• Hydrophobic properties joints must be clean and free of all foreign or
• Non-Shrinkage material contaminating materials such as sharp edges;
• Abrasion resistance residues tile adhesive, oils, grease, and dust.
• Anti-microbial properties Adhesive should be left for 24 hours before applying
the grout.
• Thixotropic properties
• Good bond strength
Application
• Easily to apply
Mix ARACO FLEXIBLE TILE GROUTwith 1.3
• Good mechanical and physical properties
Liters of clean cool water mix with an electric drill
with low rotation speed (300rpm) with a suitable
Characteristics paddle for 2-3 min,until a lump free homogeneous
Appearance Colored Powder paste is obtained. Allow the mix to stand about 10
Max Agg. Size 0.35 mm minutes and remixed it for an additional 30 seconds
without adding any additional water.
Thickness 2 to 4 mm Spread the mixture over the tile joints and pressed
Pot Life 60 minutes it with a rubbing pad covered with sponge rubber
spatula.
Storage Condition Store In a dry shaded Excess grout shall be removed with the same tool
condition, at temperature After initial setting, clean the tile and remove all
between 2°C and 50°C excess materials with a wet sponge.
Shelf Life Original sealed package has a
shelf like of 12 months if stored
properly.
ARACO FOR ADMIXTURES & CONSTRUCTION MATERIALS S.a.l.
Lebanon, Beirut: Fax: +961 8 512413/ Tel:+961 1 562510
E 6.19 Version 2018 Email: aacm@araco-group.net / MOB:+961 3 104539
ARACO FLEXIBLE TILE GROUT
High Performance Cementitious Tile Grout with reduced water absorption
Requirement for
TECHNICAL DATA Results Standard