Professional Documents
Culture Documents
Energy Meter 1phase
Energy Meter 1phase
Maevi Dinrail
Electrical Contacts
Connector Id Description
1 L Line
3 N Neutral
5 - Relay COM
6 - Relay NO
7 CT Current Transformers Red Wire
8 CT Current Transformers Black Wire
L LED Network Status/relay LED
B Button/Reset Machine interface Button
LED Indicator
LED Indicators
1. Install the Energy Meter at your electrical distribution board (DB) per the above diagram.
2. Open Maevi Smart Home App and go to "Home Automation" tab, click "+" button at the
bottom right corner of the app to start the pairing process.
3. The Gateway will now start searching for new devices to be paired with. Immediately, single
press the Reset button on the Energy Meter to complete the process.
To Pair Device
Tip: You can also press and hold the “Z” button on the gateway for 2 seconds until LED
indicator turns steady blue to permit joining device. Single press “Reset” button on the Energy
Meter to pair with the Gateway.
4. The Energy Meter is successfully paired with the Gateway when LED Indicator turns solid.
5. In the App, go to "Energy Monitoring" page and pull it down and release to refresh it.
The Energy Meter should now appear in the App as Meter #.
6. Click on the Meter # to verify the setup and make sure the Energy Meter is correctly
installed. The Active Power value should be in positive.
Note: If any of the value is negative, switch the polarity of the respective clamp. Make sure the
arrow is always directing towards the load. (Do not proceed if you do not know what you are
doing and get help from a qualified electrician instead).