Professional Documents
Culture Documents
** The UAV number is the reported number from the background. The same UAV serial number
Product Profile in a short time is regarded as one.
Specifications
Rx1: Type 1 receiver status indicator
Introduction Rx2: Type 2 receiver status indicator Link: Monitor connection status indicator Safety and Standards
Rx3: Type 3 receiver status indicator This is used to indicate the connection status between the processor and monitor.
AEROSCOPETM Mobile detects UAVs flying within a particular surveillance area.* Aeroscope Rx1 Drone Model AS-P1800
Drone: UAV information capture indicator
receives UAV broadcast information in various formats, and then sends the data to the DJI Rx2 Link
Indicator Description Ingress Protection Rating IP54 (Folded)
Rx3 MB Link: Monitor connection status indicator
CRYSTALSKYTM monitor, displaying the aircraft type, Home Point, current position, flight Solid green Connected normally and communicating with the monitor. Aeroscope meets electromagnetic compatibility
MB: Processor module status indicator
speed, and flight height. requirements and the below criteria:
Solid red Disconnected from the monitor.
* Refer to the Specifications section for a list of supported aircraft. Europe:
EN 55032: 2015
MB: Processor module status indicator
Electromagnetic Compatibility EN 55024: 2010+A1: 2015
In the Box This is used to indicate the processor’s working status. EN 61000-3-2: 2014
Aeroscope ×1 Indicator Description EN 61000-3-3: 2013
Battery ×2 Green blinking Functioning normally or firmware updated successfully. United States:
Antenna ×2 47 CFR Part 15, Subpart B: 2016
Yellow blinking Checking consistency when powered on or updating firmware.
Power Cable×1 Electrical Specifications
Red blinking Firmware update failed.
Power Consumption *** Approx. 70 W
Solid on/off Functioning abnormally.
Input Voltage Voltage range: 100 to 240 V AC
2 3 4 5
Compliance Information
Aeroscope Mobile
Working Environment
Operating Temperature Range -4° to 104° F (-20° to 40° C) FCC Compliance Notice
This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may
Recommended Storage
71.6° to 86° F (22°C to 30° C) not cause harmful interference, and (2) This device must accept any interference received, including interference that may
Temperature cause undesired operation.
CAUTION: RISK OF EXPLOSION IF BATTERY IS REPLACED BY AN INCORRECT TYPE. DISPOSE OF USED BATTERIES
ACCORDING TO THE INSTRUCTIONS
6 7 YC.BZ.SS000264.02