Professional Documents
Culture Documents
IC-A24 A6 Brochure
IC-A24 A6 Brochure
(NAV & COM channels for U.S.A.) (NAV & COM channels for Europe)
And more...
• 200 memory channels (20 Ch × 10 banks) with
6 character names
• Dedicated 121.5MHz emergency key
• Side tone function allows you to hear your
own voice via an external aviation headset.
• Optional Ni-Cd battery pack
• NOAA weather channels (IC-A24/A6 only)
IC-A24 IC-A6
• Tag scanning and memory bank scanning
• ANL (Auto Noise Limiter) for noise reduction
• Low battery alert
VHF AIR BAND TRANSCEIVERS
SPECIFICATIONS
• Squelch sensitivity (at threshold) :
GENERAL TRANSMITTER
AM Less than 0dBµV
• Frequency range : • Output power (at 7.2V DC) : FM (weather Ch. only) Less than –5dBµV
IC-A24/E Tx (COM) 118.000–136.975MHz IC-A24/A6 (USA/GEN) 5.0/1.5W typ. (PEP/CW) • Selectivity : More than 7.5kHz/–6dB
Rx (COM, NAV) 108.000–136.975MHz IC-A6 (AUS) 3.6/1.0W typ. (PEP/CW) Less than 25kHz/–60dB
(Weather) 161.650–163.275MHz* IC-A24E/A6E (EUR) 3.6/1.0W typ. (PEP/CW) • Hum and noise : More than 40dB
IC-A6/E Tx/Rx (COM) 118.000–136.975MHz • Audio harmonic distortion : Less than 10% IC-A6 (AUS) More than 30dB
Rx (Weather) 161.650–163.275MHz* • Hum and noise ratio : More than 35dB • Spurious response :
* IC-A24/A6 USA/GEN only. • Spurious emissions : More than 46dB (Except IC-A24/A6 AM More than 60dB
• Mode : AM (6K00A3E) (IC-A24/A6 USA/GEN) operating freq. ±62.5kHz point) FM (Weather Ch) More than 30dB
Weather (IC-A24/A6) FM (16K0G3E) • Harmonic spurious emissions : IC-A24E/A6E AM More than 70dB
• Channel spacing : 8.33/25kHz
25kHz operation IC-A6 (AUS) Less than –26dBm • Audio output power : More than 500mW typ. with
• No. of memory channels : 200 (20 Ch × 10 banks) IC-A24E/A6E (EUR) Less than –36dBm (Except an 8Ω load, 30% modulation
• Power supply requirement : 7.4/7.2V DC (Battery pack) operating freq. ±1MHz point) • Ext. speaker connector : 3-conductor 3.5 (d) mm
11.0V DC (External DC Jack) • Frequency stability : ±5ppm (1/8”)/ 8Ω
• Current drain (at 7.2 V DC) : • Microphone connector : 3-conductor 2.5 (d) mm
Applicable U.S. Military Specifications
Tx 1.5A typical (1/10”)/ more than 100kΩ
MIL 810 F
Rx Max. audio 300mA typical Standard
Method Procedure
Stand-by 70mA typical Low Pressure 500.4 I, II
High Temperature 501.4
• Operating temp. range : RECEIVER Low Temperature 502.4
I, II
I, II
IC-A24/A6 (USA/GEN) –10˚C to +60˚C; +14˚F to +140˚F • Intermediate frequency : 1st/2nd 30.05MHz/450kHz Temperature Shock 503.4 I
Solar Radiation 505.4 I
IC-A6 (AUS) –10˚C to +50˚C • Sensitivity (typical) : Rain Drip 506.4 III
IC-A24E/A6E (EUR) –20˚C to +55˚C IC-A24/A6 (USA/GEN) Humidity 507.4 –
Salt Fog 509.4 –
• Dimensions (W×H×D) : 54×129.3×35.5 mm NAV (AM 6dB S/N) Less than –3dBµV Dust Blowing 510.4 I
(projections not included) ; 21⁄8×53⁄32×113⁄32 in COM (AM 6dB S/N) Less than –6dBµV Vibration 514.5 I
Shock 516.5 I, IV
• Weight (approx.) : 430g; 15.2oz WX (FM 12dB SINAD) Less than –13dBµV Also meets equivalent MIL-STD-810-C, -D and -E.
(with antenna and BP-210N) IC-A6 (AUS; with CCITT filter)
Supplied accessories: (* depending on version )
• Antenna impedance : 50Ω (BNC type) COM (AM 12dB SINAD) Less than –3dBµV • Battery pack, BP-210N or battery case, BP-208N*
Measurement made in accordance with FCC part 87 for USA versions. EN IC-A24E/A6E (EUR; with CCITT filter) • Belt clip, MB-103 • Carrying case, LC-159*
300-676 for Europe versions. AS/NZS 4583:1999 for Australia version. All NAV (AM 6dB S/N) Less than –3dBµV • Wall charger, BC-167* • Headset adapter, OPC-499*
• Antenna, FA-B02AR • Handstrap
specifications are subject to change without notice or obligation. COM (AM 12dB SINAD) Less than –3dBµV
OPTIONS * Some options may not be available in some countries, or unavailable due to no T/A. Please ask your dealer for details.
■ BATTERY
BATTERYCASE CASEAND PACKS
■ For rapid charging of up to 6 batteries simultaneously. Charging ■ BELT CLIPS AND LEATHER BELT HANGERS
AND PACKS • BC-121N MULTI-CHARGER
time: 1 to 1.5 hours.
■ BELT CLIPS AND LEATHER BELT HANGERS
• BP-208N BATTERY CASE (6 × AA (LR6) alkaline cells.) BC-157S
+ BC-121N AC220V
ADAPTER • MB-103 BELT CLIP: Aligator type. Same as supplied.
• BP-208N BATTERY CASE (6 × AA (LR6) alkaline cells.) *1 A24 available • MB-103 BELT CLIP: Aligator type. Same as supplied.
• BP-210N BATTERY PACK (Ni-MH: 7.2V/1650mAh) + BC-157S
AD-101 has CHARGER ADAPTER (6 pieces)BC-157S 09–220v •• MB-86
MB-86 SWIVEL BELT CLIP
• BP-209N BATTERY PACK (Ni-Cd: 7.2V/1100mAh) *2 two versions: BC-157S 07–110v, SWIVEL
A fast and easy wayBELT CLIPthe radio from your belt.
to remove
For rapid charging
• BC-121N MULTI-CHARGER of up to 6 batteries simultaneously. Six
■• BP-210N
CHARGERS BATTERY
AND POWERPACK (Ni-MH:
SUPPLY 7.2V/1650mAh)
CABLES • A fast and
MB-96N easy way
SWIVEL to removeBELT
LEATHER the radio from your belt.
HANGER
AD-101s are
+ BC-157S AC ADAPTERrequired. Charging time: 1 to 1.5 hours.
•■BC-167*
CHARGERS
1
WALLAND CHARGER
POWER SUPPLY CABLES • MB-96N SWIVEL LEATHER
MB-96F LEATHER BELT HANGER BELT HANGER
Used for regular charging of the connected battery pack. •+BC-144N DESKTOP CHARGER
AD-101 CHARGER ADAPTER (6 pieces) • MB-96F
Fixed typeLEATHER
leather belt BELT
hanger.HANGER
Use with MB-103.
BC-167*
• Same 1
WALLdepending
CHARGER + BC-145*
For AC ADAPTER
rapid charging
2
of up to 6 batteries simultaneously. Six
as supplied on version. OTHERS
■ Fixed type leather belt hanger. Use with MB-103.
Used for regular
• BC-119N DESKTOP charging of the connected battery pack.
CHARGER AD-101s are required. Charging time: 1 to 1.5 hours.
For rapid charging of battery pack, BP-209N or BP-210N.
•■HM-173
OTHERS SPEAKER-MICROPHONE
+Same as supplied
BC-145* 2 depending on version.
AC ADAPTER • BC-144N
The BC-145 DESKTOP CHARGER
is supplied with the charger depending on Provides convenient lightweight operation while setting the
•+BC-119N
AD-101 DESKTOP
CHARGERCHARGER ADAPTER BC-145*Charging
+ version. 2
AC ADAPTER
time: 1.5 to 2 hours. • HM-173 SPEAKER-MICROPHONE
transceiver in the cockpit or hanging it from your belt, etc.
For rapid charging of battery pack, BP-210N. ProvidesCARRYING
convenient lightweight
+ BC-145*
For rapid charging
2
AC ADAPTER
of battery pack, BP-210N. CP-20
•The CIGARETTE
BC-145 LIGHTER
is supplied with CABLE
the charger WITHonDC-DC
depending version.
• LC-159 CASE operation while setting the
+ AD-101
The BC-145CHARGER
is supplied with the charger depending on version.
ADAPTER transceiverHEADSET
• OPC-499 in the cockpit or hangingCABLE
ADAPTER it from your belt, etc.
ChargingCONVERTER
time: 1.5 to 2 hours.
Charging
For rapidtime: 1.5 to of
charging 2 hours.
battery pack, BP-209N or BP-210N. For operation and charging • LC-159
Works withCARRYING
most aviationCASE
headsets. Provides side tone
*1 BC-167SA for 110 or 117 V AC. BC167ND for 220V AC. • CP-20 CIGARETTE LIGHTERwith CABLE a 12V/24V
WITH cigarette
*2The BC-145foris110V
BC-145SA supplied with the for
AC. BC-145SE charger depending on
220V AC. lighter CONVERTER
DC-DC socket. • OPC-499
function. Same as supplied
HEADSET with someCABLE
ADAPTER versions.
version. Charging
• BC-121N time: 1.5 to 2 hours.
A24*1 MULTI-CHARGER comes with the AD-101 •For operationDC
OPC-656 andPOWER
charging with
CABLEa 12V/24V cigarette lighter socket. • FA-B02AR
Works withANTENNA:
most aviation
Sameheadsets.
as supplied.Provides side
tone function. Same as supplied with some versions.
CHARGER ADAPTER (6 pieces) and the BC-157S* AC ADAPTER • OPC-656
* BC-167SA for 120V AC. SV for 240V AC. SD for 230V AC. 2
For usingDC thePOWER
BC-121NCABLE
1
* BC-145SA for 120V AC. SE, SUK for 230V AC. SV for 240V AC.
with a DC power supply.
For using the BC-121N with a DC power supply. (12–20 V DC required) • FA-B02AR ANTENNA : Same as supplied.
2
(12–20 V DC required)
BC-121N LC-159
+AD-101
(6 pcs.)
▼BC-145
▲BC-144N BC-157S
BP-208N BP-210N MB-96N HM-173 OPC-499
1-1-32, Kami-minami, Hirano-ku, Osaka 547-0003, Japan Phone: +81 (06) 6793 5302 Fax: +81 (06) 6793 0013 www.icom.co.jp/world Count on us!
2380 116th Avenue NE, 146A Harris Road, East Tamaki, Blacksole House, Altira Park, 6F No. 68, Sec. 1 Cheng-Teh Road, Your local distributor/dealer:
Bellevue, WA 98004, U.S.A. Auckland, New Zealand Herne Bay, Kent, CT6 6GZ, U.K. Taipei, Taiwan, R.O.C.
Phone : +1 (425) 454-8155 Phone : +64 (09) 274 4062 Phone : +44 (01227) 741741 Phone : +886 (02) 2559 1899
Fax : +1 (425) 454-1509 Fax : +64 (09) 274 4708 Fax : +44 (01227) 741742 Fax : +886 (02) 2559 1874
E-mail : sales@icomamerica.com E-mail : inquiries@icom.co.nz E-mail : info@icomuk.co.uk E-mail : sales@asia-icom.com
URL : http://www.icomamerica.com URL : http://www.icom.co.nz URL : http://www.icomuk.co.uk URL : http://www.asia-icom.com
Glenwood Centre #150-6165 Highway 17, Communication Equipment Zac de la Plaine, 10C07, Long Silver Mansion, No.88, Yong Ding
Delta, B.C., V4K 5B8, Canada Auf der Krautweide 24 1 Rue Brindejonc des Moulinais, BP 45804, Road, Haidian District, Beijing, 100039, China
Phone : +1 (604) 952-4266 65812 Bad Soden am Taunus, Germany 31505 Toulouse Cedex 5, France Phone : +86 (010) 5889 5391/5392/5393
Fax : +1 (604) 952-0090 Phone : +49 (6196) 76685-0 Phone : +33 (5) 61 36 03 03 Fax : +86 (010) 5889 5395
E-mail : info@icomcanada.com Fax : +49 (6196) 76685-50 Fax : +33 (5) 61 36 03 00 E-mail : bjicom@bjicom.com
URL : http://www.icomcanada.com E-mail : info@icomeurope.com E-mail : icom@icom-france.com URL : http://www.bjicom.com
URL : http://www.icomeurope.com URL : http://www.icom-france.com
Unit 1 / 103 Garden Road, Ctra. Rubi, No. 88 "Edificio Can Castanyer" 81-850 Sopot, ul. 3 Maja 54, Poland
Clayton, VIC 3168 Australia Bajos A 08174, Sant Cugat del Valles, Phone : +48 (58) 550 7135
Phone : +61 (03) 9549 7500 Barcelona, Spain Fax : +48 (58) 551 0484
Fax : +61 (03) 9549 7505 Phone : +34 (93) 590 26 70 E-mail : icompolska@icompolska.com.pl
E-mail : sales@icom.net.au Fax : +34 (93) 589 04 46 URL : http://www.icompolska.com.pl
URL : http://www.icom.net.au E-mail : icom@icomspain.com
04WS017M © 2004–2011 Icom Inc. Printed in Japan
URL : http://www.icomspain.com