This document outlines an assignment for a sheet metal works and pipes fabrication course. It includes 4 questions asking students to: 1) Define sheet weathering and draw diagrams of canopy and dormer weathering; 2) Draw the development of pipes joined to make a tee piece; 3) Illustrate types of sheet metal joints including lap, single lock welt, double lock welt, standing seams, and batten roll; 4) Describe properties of materials used for sheet weathering and give examples; and 5) Describe functional requirements for flashings. The assignment is due on September 25th, 2023.
This document outlines an assignment for a sheet metal works and pipes fabrication course. It includes 4 questions asking students to: 1) Define sheet weathering and draw diagrams of canopy and dormer weathering; 2) Draw the development of pipes joined to make a tee piece; 3) Illustrate types of sheet metal joints including lap, single lock welt, double lock welt, standing seams, and batten roll; 4) Describe properties of materials used for sheet weathering and give examples; and 5) Describe functional requirements for flashings. The assignment is due on September 25th, 2023.
This document outlines an assignment for a sheet metal works and pipes fabrication course. It includes 4 questions asking students to: 1) Define sheet weathering and draw diagrams of canopy and dormer weathering; 2) Draw the development of pipes joined to make a tee piece; 3) Illustrate types of sheet metal joints including lap, single lock welt, double lock welt, standing seams, and batten roll; 4) Describe properties of materials used for sheet weathering and give examples; and 5) Describe functional requirements for flashings. The assignment is due on September 25th, 2023.
Question 1 a. Define sheet weathering [2] Draw neat and fully labelled diagrams to illustrate the following: I. Canopy weathering [4] II. Dormer weathering [4] Question 2 Draw development of two pipes joined at the center to make a tee piece the diameter of the pipes it's 40mm measurements of pipes it's 90mm (10) Question 2 a. Illustrate the following types of joints i. Lap joint [2] ii. Single lock welt joint [2] iii. double lock welt joint [2] iv. Standing seams joint [2] v. Batten roll joint [2] Question 3 Describe the properties of materials used for sheet weathering. Give examples. [10] Question 4 Describe the functional requirements for flashings. [10]