Professional Documents
Culture Documents
36
35
42 1
2
3
32
28
27 33
43 32
33 25
25 33
29 25
25 34 27
28 28 4
27 26 28
25 27
30 5
29 31
22 6
28
27
26
25 22
24 7
9
8
23
9
10 9
16
15
17 13
18
Front Hole for Dozer Applications 21
Rear Hole for Snowthrower Applications Front Pulley - Two-Stage Hydraulic 20
Snowthrower Application Lift
14
13 11
29
44 27
12 19
11 Early Manual
51 Lift Only
9 (See Instructions)
26
25 28
Figure 1. Contents 2
INITIAL ASSEMBLY
Assemble Hitch
1. Attach the support clamp (C, Figure 2) and hook
assembly (B) to the hitch. Secure with four 5/16-18 x A
1 carriage bolts (A), washers (D), lockwashers (E),
and nuts (F). Do not tighten the hardware at this
time. B
Change Pulley & Belt - Two-Stage Blower Conquest / 1700 /
A
Only 2700 &
1. If using this hitch with a two-stage snowthrower, the Prestige / 1800 / C
front idler pulley must be switched from the right hand 2800 Series
side of the hitch bracket, to the left, and an additional
3/8 x 1 x 1/2 spacer (B, Figure 3) and 3/8-16 x 2-1/4
capscrew (A) is required. Also install the 1703372
drive belt.
D
E
C
D
A Snowthrower
C B & Dozer E
Applications
D
A
B
Mower
A Applications
B
G
Figure 5. Early/Later Lift Links
A. Early Model Lift Link
A
B. Later Model Lift Link
4. Install the original flat head pin (B) and new flat head 5
pin (C) and secure with hair pin clips.
Install Hitch
1. Slide the hitch under the tractor.
2. Raise the rear of the hitch and place the hook (C,
Figure 8) over the lift shaft.
3. Connect the front of the hitch to the tractor J-hooks
(A) using the hitch rod (B) and a safety clip.
4. Push the clamp plate (D) backwards until the hook
(C) is snug against the lift shaft. Tighten the clamp
plate hardware.
B
C
B
C
Install Reflectors
1. Install the two reflectors on the rear of the tractor seat
deck.
Snowthrower
B Position
A. Hitch Rod
B. Lift Lever Extension
C. Lift Link (Manual)
D. Pressure Lock Plate
(Hydraulic)
E. Hook
Snowthrower Snowthrower
& Dozer & Dozer E
Applications Applications
A
B
C F
D E B C D
Mower Mower
Applications Applications G
B
F
G E F C D
Figure 13. Lift Lock Plate - Hydraulic Lift Models Figure 14. Lift Link - Manual Lift Models
A. Lift Cylinder A. Pin
B. Flat Head Pin (Original) B. Rear Hole of Lift Bar (Snowthrower Applications)
C. Flat Head Pin (New) C. Spacer
D. Lock Plate D. Hair Pin Clip
E. Hair Pin Clips E. Upper Hole (Snowthrower Applications)
F. Lift Shaft Assy. F. Slot of Lift Link (Mower Applications)
G. Washers G. Lower Hole (Mower Applications)
NOTES