3-85 An aluminum plate 25 mm thick (k= 235 Wim)
is etached to a copper plato with thickness of 10 mm, The
copperplate is heated electrically to dissipate uniform heat
flux of 5300 Wim’. The upper surface of the alurinum plate
is exposed to convection heat transer ina conditian such dha
the convection heat wansfer coeficient i 67 Wrat-K and the
surrounding soonn temperature is 20°C. Other surfazes ofthe
‘to attached plates ate insulated sich that heat only dissipates
through the upper surface ofthe akiminem plate. I the surface
‘of the copperplate that i attached tothe aluminan plate has 2
temperature of 100°C, determine the thermal contact cond
tance of the aluminum/copper interface.
foray’3.127 A 4-mm-diameter and 10-cm-long sluminum fin
(k=237 Wim) is attached to a surface. Ifthe heat transfer
coefficient is 12 W/mK, determine the percent error in the
rate of heat transfer from the fin when the infinitely long fin
is used instead of the adiabatic fin tip assumption.34128 Consider a very long rectangular fin attached to
flat surface such that the temperature at the end of the fin is
cssentially that ofthe surrounding air, i.2., 20°C. Its width is,
‘50 em: thickness is 1.0 mm; thermal conductivity is 200 Wim-K;
and base temperature is 40°C. The hect transfer coefficient is
[0 Wien!-K. Estimate the fin temperature a a distance of SO-em,
from the base ad the rate of heat loss from the entire fn
34129 Comider a very long, slender rod. One end of the
rad is attached to a base surface maintained at 7), while the
‘surface of the mod is exposed to an air temperature of 400°C.
‘Thermocouples imbedded in the rod at locations 25 and
120mm fromthe base surface registertemperatures of 325°C and,
375°C. respectively. (a) Caleulate the rod base temperature -C).
()) Determine the tod length (mm) for the case where the ratio,
‘of the heat transfer from a finite length fin to the heat transior
from a very long fin under the same conditions is 99 percent.
MixLLM? A hot surface at 100°C isto be cooled by atacing
‘Sem-long. 025cm diameter aluminum pin fins (k=237
‘Wim 16, witha cenerto-cemer distance of (16 em. The
temperature ofthe surounding medium js 30°C and the heat
trunvfercoe!icent on the saraces ie 33 Whn?.K. Determine
the at of hea tans from the sarace fra I-m.x Lom section
‘ofthe plate, Ao determine the overal effectiveness ofthe is.