Professional Documents
Culture Documents
Food Chemistry Practical
Food Chemistry Practical
Name of the experiment: Isolation of casein from milk by isoelectric precipitation by acidic
solution
Objective:
Principle
Milk protein consists of 80% casein and 20% whey protein. There are four major types of casein
molecules: alpha-s1, alpha-s2, beta, and kappa. Casein, like proteins, are made up of many
hundreds of individual amino acids. Each may have a positive or a negative charge, depending
upon the pH of the (milk) system. Milk, in its natural state, is negatively charged. The negative
charge permits the dispersion of casein in the milk. When an acid is added to milk, the H+
concentration neutralizes the negatively charged casein micelles. When milk is acidified to pH
4.7, the isoelectric point (the point at which all charges are neutral) of casein, an isoelectric
precipitate known as acid casein is formed. Cottage cheese and cream cheese manufacture
involves an acid precipitation of casein with lactic acid or lactic acid-producing microorganisms.
During the addition of acid to milk, the negative charges on the outer surface of the micelle are
neutralized (the phosphate groups are protonated), and the neutral protein precipitates.
Requirements
Milk, Heating arrangement, Steel vessel, citric acid, 95 % alcohol, electric pH meter, Whatman
No 1 filter paper, Hot air oven or dryer, Weighing balance
Procedure
Weight of curd: 47 gm
47
% curd: ∗100 = 9%
522
initial wt −final wt
% moisture content = ∗100
initial wt
10−4.68
= ∗100
10
=53.2%
23.55−23.19
% moisture content= ∗100 = 1.5%
23.55
⸫ total moisture content=53.2%+1.5%= 54.7%
W 2−w 1
% fat content= 100 %
s
125.20−125
= ∗100
5.1
=3.92%
For % casein
Also;
19.46
% casein= ∗100 %
522
=3.72%
Objectives
Background
Chlorophylls are found in virtually all photosynthetic organisms. They occur in several distinct
forms: chlorophylls a and b are the major types found in higher plants and green algae;
chlorophylls c and d are found, often with a, in different algae; chlorophyll e is a rare type found
in some golden algae; and bacterio-chlorophyll occurs in certain bacteria. In green plants
chlorophyll occurs in chloroplasts, approximately in the ratio 3a:1b. The determination of
chlorophylls has great importance in food technology as well as other disciplines. In food
technology, chlorophyll is related to esthetic quality of fruits and vegetables. It is also
extensively used as a parameter in studying maturation and ripening of fruits and vegetables. In
aquatic ecology, chlorophyll determination is used for biomonitoring. Chlorophylls are very
sensitive pigments. They are readily degraded by oxygen and acid. Any activity (e.g., grinding)
that frees the intracellular chlorophyllase enzyme also leads to rapid destruction of chlorophylls.
This warrants great care in sample preparation. The quantitative analysis of chlorophyll is
universally carried out by spectrophotometric method. Depending on the purpose of analysis and
the nature of sample, some variations, particularly with respect to absorbance wavelength and
extraction solvent, are also observed. Different investigators have used wavelengths of 600, 630,
642.5, 645, 663, 660, 665 and 750nm. The solvents commonly used are 80% acetone, acetone-
methanol (90% acetone), or 100% acetone. The centrifugation speed ranges from 2,500 to 5,000
rpm.
Principle
Chlorophyll is extracted in 80% acetone and the absorption at 663 and 645nm are read in a
spectrophotometer. Using the absorption coefficients, the amount of chlorophyll is calculated
using the empirical formula:
Requirements
Procedure
2. Take 1 g of sample and grind it to a fine pulp in mortar and pestle with about 10ml of 80%
acetone
5. Scrap the sediment in the centrifuge tube and grind it again in the same mortar and pestle with
a small amount of 80% acetone to extract the residual chlorine
6. Centrifuge the mixture as done earlier and pool the extract in the 50-ml volumetric flask
(containing the previous supernatant)
8. Add 80% acetone to the pooled extract to make up the volume (i.e;50ml)
10. Read the absorbance of the extracts in spectrophotometer at 663 and 645 nm using 80%
acetone as the blank
Calculation
Absorbance of sample B
At 645 nm At 663 nm
0.082 0.172
0.092 0.223
0.092 0.217
Avg 0.095 Avg 0.204
Absorbance of sample A
At 645 nm At 663 nm
0.091 0.213
0.097 0.211
0.109 0.211
Avg 0.099 Avg 0.211
=2.66 mg/g
=2.218 mg/g
=2.578 mg/g
=2.127 mg/g
iii. Total chlorophyll, mg/g tissue = chl a +chl b
= 2.578 + 2.217
= 4.705 mg/g