Professional Documents
Culture Documents
For example, Ethernet 0/1 does not need to connect to Ethernet 0/1 on the other side of the link.
🔄 The port channel number does not need to match between the switches on the opposite side of
the link. 🚥
Speed and duplex: Configure all interfaces in an EtherChannel to operate at the same speed and
Interface mode: Because the port channel interface is a routed port, the no switchport command
was applied to it. The physical interfaces are, by default, switched, which is a mode that is
incompatible with a router port. The no switchport command was applied also to the physical
ports, to make their mode compatible with the EtherChannel interface mode. 🔄
Note 📝
In some IOS releases, you can only statically configure Layer 3 EtherChannel using Link
Aggregation Control Protocol (LACP) or Port Aggregation Protocol (PAgP) because the
negotiation protocol might result in a nonfunctional link.
Verifying the EtherChannel configuration: After EtherChannel is configured, use the following
Use the EtherChannel technology to bundle ports of the same type for better
On Layer 3 switches, switched ports can be converted to routed ports. 🔄 These ports
do not perform switching at Layer 2 anymore but become Layer 3 ports that are
similar to those found on router platforms. 🔄 EtherChannel links can also be created
on Layer 3 links. 🔄 Layer 3 switches must connect through an aggregated link. Two
physical ports on each side are converted to routed ports and are then aggregated
into a Layer 3 EtherChannel link. 🔄 the typical Layer 2 EtherChannel between the
between switches. 🔄🌐
Activate to view larger image,
🔄🌐
Activate to view larger image,