Professional Documents
Culture Documents
BMW R 1200 RT 2014 Owner's Diary
BMW R 1200 RT 2014 Owner's Diary
8 days
31/1/18 Went to Shah Alam to take back RT by ETS (RM73). Departed at 18:20. Reached KL Sentral at 2
1/2/18 Went to Padang Jawa Pindah hakmilik. Need old geran and owner's IC. RM3 was charged.
Went to AutoBavaria Glenmarie to take RT. Met Sheikh.
Sheikh explained briefly about the joystick etc.
Speedo starts at 5616km
Did the plat no for puspakom inspection RM25.44
Went to Glenmarie Puspakom for inspection with Pian
Went back to JPJ for roadtax but failed.
Back to Perlis close to 4pm. Stop twice at Tapah n Juru.
Arrived plant at 20:00
30 days
2/2/18 To check possibility of puspakom to settle the blacklist issue due to roadtax not renewed more
Unfortunately cannot
7/2/18 Go to BMW Hatyai n Speedplay. Checked price of top box. Not that much difference.
14/4/18 Ride with darling for the first time to tanyong po 19 days
All was good. Start ride 1145h. Back 1700h
22/4/18 Top Case Installation Project: Drilled rt plate to put shad bracket.
28/5/18 Ordered SHAD tank box for RM425. Same forgotten about no gst
20/6/18 Installed SHAD tank box. Needed 4 screws from SHAD to hold the box.Quite nice…
TO CHECK TIGHTNESS ALL ABOVE INSTALLED PARTS AND SHAD BOX RACK 2 weeks after i
5/7/18 Changed both tires at Ah Chun. RM1050. Front RM420 rear RM595. Service fee for installation R
Brigestone Battlax T31R 12 days
The old rear tire already cracked at side walls and mechanic said the rubber became very hard
30/7/18 Went to sunny cycle at 10am. Tires balancing RM100. To install hex-exScan for installing other
Stop at El Chong Jawi. Tires balancing can do for RM60
25/8/18 Managed to open the battery. Installed charger terminals for easy recharging point.
20 days
26/8/18 Recharged overnite. Still need to be recharged..
4/9/18 Fender extender arrived on 3/9/18. Installed on 4/9. Easy installation. Like it..
22/10/18 Replaced Hella horn with PIAA. RM15. Installed by Ah long Kuala Perlis
Noticed that sound system not functioning. May be was disconnected during horn installation d
15/11/18 Found out can not start. No light at all. Could be battery kaput
4/12/18 Very slow installation. Completed +5pm. Reached home at +10pm. Heavy rain before menora t
Tested the Denali… wor very bright spot…
Akra was awesome. Can feel more power even at gear 6.
Radio also back to normal. Actually found out that the sound was off. A bit puzzled coz though
Wunderlich screen bag screws also tightened.
21/12/18 Bought Vesrah brake pad front and rear from Wunderlich. Each set is rm220
El Chong quoted +rm300 for brembo pad ori
14/4/19 Notiecd that rear tire air pressure low, before starting the journey back - suspect leak but small
Me balik Malaysia. Others stay one more night in Hatyai
10am photo shoot at PBW
1300 sampai Trang PTT Amazon Café
Dinner at 2150
Sampai border around 2200
Sampai rumah 2300
Alhamdulillah
Mileage
Fuel
14/5/19 Air pressure only 1.9bar for the rear. Still got small leak. 11 days
13/6/19 Rear tire pressure maintained at 2.8bar. So the leak was solved
Washed bike. 17 days
Speedo at +17,000km
18/6/19 Went to Wang Sai Thong fo receeing cycling route for next GET RIDE
About 90km from the border.
Hit by storm midway
Lunch in Satun Fareeda Muslim Kitchen near the mosque
Back to border close to 4pm
Speedo at 17,500km
32 days
10/7/19 Ride office to home
29/7/19 Ride to El Chong Jawi. Cold air pressure 2.2 n 2.6. Hot 2.3 n 2.7
From air hitam 0810am. Reached Jawi 0945.
Major Overhaul 20k km. Actual mileage 17,984km
Cost RM1,629 minus RM100 due to birthday voucher
Air pressure hot 2.6 n 2.9. To reduce front tire 0.1 bar
Rear tire to be changed soon. Current depth 1mm. Ft tire depth 1.5mm. Advised to change both
2/8/19 Current mileage 18,154km. Battlax T31 already run 8,154km. Rear tire not long…
25/9/19 Bought Michelin Pilot Road 4 for front and rear tires. 19 days
RM480 and RM580. Courier RM30
Got discount RM60 due to tire age 2016 not 2017
so front RM480 (2518) rear RM520 (1816)
1/10/19 Ride RT to home from office and back to the office. Air pressure was low for both sides
7/11/19 Ride from home to office. Rear tire air pressure dropped to 1.4bar ONLY. Pumped to 2.6bar
9/11/19 Ride from office to home. Rear tire pressure only 2.2bar. Did not pump.
11/11/19 Washed bike. Fairing right hand side difficult to pu into its slot. To repair
Pumped air to front and rear tire. But when ride the air pressure only 2.3 for both tires
Ride home to office
3/12/19 Changed new rear tire at Ah Long's workshop from Bridgestone T31 to Michelin Road Pilot
Balancing 40g vs 20g RM15
Tire replacement RM35
Front tire surface not balance smoothly.
Front brake pads also not much left
9/12/19 Changed front tire at Ah Long's workshop. Still got threads but surface not wear n tear properly
Changed front brake pads as well.
Balanced manually.
Charged RM80. Tire RM50, brakes RM15 each
‘29/2 Sent ADLI back to Maahad. 45" reached Kuala Ketil17 days
‘4/3 Open screws to remove panel from the box. Sent to Naim/Abat for repainting
‘23/3 Opened fairing panel left hand side to repair radio buttons. Only two screws needed to open to
Found out the panel is glued to the fairing. That’s the reason it fell down.
Put new glue and attached back. 19 days
‘18/5/20 Home to Alor Star. Alor Star to Kuala Ketil. To n Fro. Ride with Adli
‘31/5/20 Ride office to home. Installed phone at the new phone mount with charger. VG!!!
11 days
‘1/6/20 Office to home.
‘19/6/20 Contact Abab about the painting job. Still otw. Need to cement.
17 days
‘27/6/20 Went to plant from home. Back to home
‘27/6/20 Recharged battery
Alarm service came out because already reaching one year from last service although mileage
Resetted.
‘23/10/20 Office to JPJ and home. Mileage now more than 22k
‘28/10/20 Installed head lamp protector. Right hand side seems not glued enough
Used alcohol too much on the plastic until some spot looks blurred. ALAMAK!!!
‘30/10 Sent Adli to n fro. Start 540pm. Arrived 7.10pm. 1.5 hours
Mileage 22,300km
155km house to maahad. To n fro 310km
*Headlamp cover protector: Velcro right hand side not stick good enough. Use double tape
‘2/11 Velcro still detached even though put extra double tape
Home to office
‘18/12 See RT
‘21/12 Took bike at 6pm. Went to Kola Perlis to meet Loh and Rudy and later park at office.
RM700 for detailing and coating
All done in 4 days
‘14/1 Started bike to go home but failed. Battery kong. Too long not start. 24 days...
Before riding found that side box came off but able to close. During riding found the box opene
Can not reset abs pump due to phone was updating at that time. To do next time
Speedo at 23908km
Tried to open handlebar torx screw to install ram ball socket but could not be done. Screw size
Matin to office
Speedo close to 24k
Already 18,384km since purchased on 1/2/2018 (3 years)
‘25/2 Sent box fairing for coating carbon fibre. RM80 per box = RM160
Torque
‘-wheels bolts: 60Nm
‘-brake bolts: 24
‘-drain oil gear torx screw:
‘-top oil Allen screw:
‘-Spline torn screw:
‘-Exhaust to footrest bracket: 19
‘-Exhaust tightening bolt: 22
‘-abs sensor: 5
Completed job on 30/5. To do every 10,000km
To find moly gear grease, silicone grease
‘31/5 Tested bike. So far so good. To tighten all torx screws according to torque level
Bought extension 1/2" to 1/2". Brand Kadon - RM35
‘28/7 Office-home
TP cold: 2.2/2.6
TP hot: 2.3/2.7
‘29/7 Home-matin-home
To replace missing screw fairing lower right side
‘6/8 Office-home
‘9/8 Home-office
TP: 2.4-2.5/2.7
Office-Home-Office
Mileage at 25,360km
‘2/9 Office-Matin-Home
Voltage around 12V
‘3/9 RT difficult to start. 2nd time ok. Went for breaksfast. After that can not start RT.
Called for help. Mis came with cable and tools.
Managed to jump start RT.
‘21/9 Home-office
‘30/9 Home-Matin
Sound something burning... oil??
‘1/10 Matin-Office-Home-Office
Still smell the same... to monitor
TP: 2.2-2.3/2.6
Top-up air front n rear: TP: 2.5/2.8. To check TP in the dash
‘21/10 Found exhaust Akra slip-on loose at connection. retightened with torx screw size 40. Now ok
Home-office
‘1/11 Matin-office-Matin
TP: 2.5/2.6-2.7
‘24/11 Office-Home
‘29/11 Home-office
TP: 2.3/2.6 - 2.4/2.7
To top-up air
Speedo at 26,249km
‘30/11 Office-Matin
‘1/11 Matin-Zaidi
‘2/11 Zaidi-Matin
‘3/11 Home-Office-Home
Pumped tires
Noticed cover for lock left bag was missing... Happened yesterday from Matin to Home with Zai
‘20/12 Office-Matin
‘22/12 Matin-office
‘27/12 Office-Home
Measure battery: 13.13V. At Dash 12.9V
Mileage: 27,164km
‘3/1 Home-Office
Mileage:
Battery:
TP: 2.3/2.7. After ride: 2.4/2.7
Top-up air for both tires. To check air pressure
‘7/1 Office-Home
Home-Matin
TP: 2.5/2.8??
Rear tire seems worn out a bit. Still can ride
‘8/1 Matin-Zaidi
17/1 Home-office
Mileage: 28,110
TP:2.5/2.8
29/5 3M-Matin
RM80 for cleaning and spa
30/9 Home-Aimat-Office
Pumped to 2.5-2.8
12/10 Home-office
2.4/2.7
Mileage: +28,700km
20/11 Kulai-Kangar
30/12 Office-Home
2.4/2.6
4/1 Home-Office
2.3/2.7 - 2.4/2.8
18/2 Bought SHAD tank bag; E10P for RM510 for RT to replace the old one E04P
Size is ok, but no outlet for cabling etc. 3 days
25/2 Installed the new tank bag. Can use old metal plate7 days
26/2 Home-Betong 1 day
1/3 Home-PakNanPenaga-Office
Mileage: 32800
Matin-Home
18/4 Home-Office
Pumped air 2.5 ft - 2.8 rr. But in the dash only registered 2.3/2.6. Ft tire cap missing
8/5 Home-Office
Mil: 33,000km
19/5 Home-Matin
But Azam told, got oil leak during the fell down. To check again boxer right hand side
8/6 Checked RT engine after fell down during freak storm on 16/5. ALHAMDULILLAH no sign of lea
10/8 Office-KGP-Home
2.4/2.7 - 2.5/2.8
11/8 Home-Santan-Matin-Office
Rear TPMS on and off
Office-Seriab,lunch-Office
Mil: 33,360km
2.2/2.6 - 2.3/2.7
12/10 Home-Office
2.2/2.6. Rear TPMS not reading at first, later ok
18/10 Office-Home
2.1/2.5-2/2-2/6
20/10 Home-Office
2.1/2.6-2.2/2.6
Bat: 12.9V
34,521
26/10 Office-Home
3/11 Home-Office
34,569
2.0/2.5
12.9
9/11 Office-Home
10/11 Home-Office
34,618km
2.1/2.5
16/11 Office-Home
2.5/2.7
21/11 Home-Office
Top-up fuel
13.0V
34,639km
5/12 Home-Office
13.0V
2.4/2.7
2018
Areas covered:
Handover on 24/8/2015
Geran
Tshirt; one collar and one roundneck
manual
warranty book
uch difference. 2 keys
BIKE COVER
NAVIGATOR
###
SHAD TOPBOX
SHAD TANK BAG
x.Quite nice…
ACCESSORIES
- big foot (lost already)
ervice fee for installation RM20 per tires. NEW TIRES BATTLAX T31
RM420/RM595
rubber became very hard already.
QUAD LOCK
harging point.
FENDER EXTENDER
Stopped at RR Tapah for fuel n dinner. Raining after Ipoh until KL.
ck to Abg Awi's house at 8pm. Drizzling
h. Reached Besut at 4pm.
0pm. About 3 hours for 300km. Refuel. Reached home at 7.40pm. Alhamdulillah
BATERY KAPUT
DEKA BATTERY
DENALI DR1
Selected Denali DR1 for better distance ofAKRAPOVIC
sp EXHAUST SLIP-ON
2019
1ST REPLACEMENT
REAR BRAKE PAD
SERVICE
AT 17,984KM @20K
ENGINE PROTECTOR
1st REPLACEMENT
Still got plenty but too long
already since 2014
2020 2017
screws needed to open to access.
NORMAL SERVICE
AT 21,790KM
RT SPA
park at office.
2021 2018
BATTERY CHARGED
ding found the box opened suddenly.
e other options.
BATTERY KAPUT
BATTERY CHARGED
ob done at el Chong, jawi DRIVE SHAFT
MAINTENANCE
at 25,129km
Next 35,129km
CHARGE BATTERY
MISSING SCREW FAIRING
RIGHT SIDE LOWER
ady damaged.
CHARGE BATTERY
EXCHANGED BATTERY
engine is ON
CHARGE BATTERY
NEW BATTERY
MOTOBATT
2022 2019
0. Rear tire back to 180/55/17 NEW TIRES AT 27500
NEW REAR BRAKE PAD - ori BREMBO
FRONT BRAKE PAD 50%
UPGRADED SOFTWARE
2018-2021
SPA
ENGINE SERVICE
DRIVE SHAFT OIL CHANGE
. Dark colour 29,351km
2023 2014
e cap missing
2015
battery
Tank both sides
fairings except windshield
forks
dashboard screen
bags
light screen
ver on 24/8/2015
NEW EZHEXCAN
NEW DENALI DR1
NEW AKRAPOVIC
REWIRING PIAA HORN
RADIO CAN BE ON
10,000. Now: 18,154. Diff: 8,154km
ARMO BOX
TO PURCHASE
tool set
tire gauge
quick shifter
big foot
new tire for rear - done 1/4/2016
PURCHASED
KOYOKO 420
DEKA
I
NAME BMW R 1200 RT - K52
RT9967 old number BFQ262
DATE OF REGISTRATION 25/8/2015
YEAR OF MANUFACTURE 2014
ENGINE NO. 122EN28144099
CASIS NO WB10A0300EZ238195
CC 1170
COLOUR Ebony Meta / Red wine
PRICE RM96000
INSURANCE RM1705.7
INSURANCE: POLICY NO Liberty Insurance
AMOUNT INSURED RM90000
Insurance: Cert no PGMA-189513
REGISTRATION FEES (RM)
TRANSFER FEES (RM)
LOAN AMOUNT (RM)
INTEREST AMOUNT (RM)
HIRE PURCHASE PRICE (RM)
AGREEMENT NO.
a/c
ACCESSORIES RM
OPTIONAL Name
NUMBER PLATE Policy No
METALLIC PAINT Deadline
TOTAL -
NAZA TO HANDOVER
1. SPARE KEY DONE
2. MANUAL GOT FROM WEB - PDF
3. SERVICE BOOK
4. ORIGINAL SEAT WITH TOOLS
30,525.05
17
18
19
20
21
22 Bridgestone Battlax T30 Evo 180/55/17 565.00
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39 ESE Healtech
40 Deposit SC Project Titanium exhaust A13-01T deposit RM1k on 22/2 2,340.00
paid full on 4/5/2017
41 Bridgestone Battlax T30 Evo 120/70/17 420.00
42 300.00
64,675.10
5-Jan
6/2/23
5/2/18-4/2/19 All riders
1st -2018 2nd -2019 3rd - 2020 4th - 2021 5th - 2022
90,000.00 80,000.00 75,000 75,000 70,000
350.00 350.00 350.00 350.00 150
2,204.60 1,360.00 1,135.00 1,188.00 1,678.00
2,554.60 1,710.00 1,485.00 1,538.00 1,828.00
2,554.60 4,264.60 5,749.60 7,287.60 9,115.60
NCD 25%
Shah Hadany
‘20/5/20 Arrived. Shav Right purchase. Mount and charger as one unit
21.00
21.00 gdgd
20.00
1/4/2016
150.00
1,300.00
140.00
120.00
2,187.57
106.05
250.00
22/2/17 2,340.00
6,735.62
14/8/17
14/10/17
8/9/2015 NO NEED
8/9/2015 NO NEED
8/9/2015
Oct-15
17/11/2015 Jawi
Oct 2015
Oct 2015
Nov-15
Nov-15
Nov-15
2016
2016
2016
2016
august 2016
august 2016
May-17
10/2/23
Single Rider
6th - 2023 7th - 2024 7th - 2024
70000 55000 50000
150 150 150
1060 700 500
1,210.00 850.00 650.00
10,325.60 11,175.60 11,825.60
no charger
Total #VALUE!
Total
total
Grand Total #VALUE!
53km
1/1/19 - +14000km
disc 50%
disc 30%
disc 30%
disc 30%
disc 30%
Or Oct'2021
Nov'2022
Nov 2023
Dec 2023 Shaft service??
49k/50k
yearly monthly
#VALUE! #VALUE!
Sheikh met manager bmw motorrad glen
Metzeler Roatec Z8
1st replacement - (Thursday) 2nd replacement; Michelin Pilot 4
Balancing on 30/7/18 - Sunny Cycle RM100. Balancing on 3/12/19 - Kedai Tayar RM15. Upah RM50
Quotation
OEM
Metzeler M5 Roadtec Z8 Sportec M5
F 320 350 330
R 485 520 500
805
120/17R17 ( 58W)
PIRELLI ANGEL GTII
Made in
Replaced on 11/1/2022
180/55R17 (73W)
PIRELLI ANGEL GT II GRAN TURISMO
Made in ...
Replaced on 11/1/2022
5. Upah RM50
n 2018 [2518]
n 2016 [1816]
n 2019 (4419)
n 2019 (4419)
ACTIVITIES
To change name 1/2/18
To purchase top box, backrest n rear light; options GIVI, SHAD, ORI 17/4/18
To put paint coating n sticker at the box (place that normally being hit by shoes) 17/4/18
To check price at Bike Nation in Alor Star price for balancing 14/8/18
Alarm battery low charge came out in December ‘2019 “Dec ‘19
Found out remote battery already drained ‘Jan 2019
To put proper screws for right fairing the lowest one 17/1/22
Remarks Date
JPJ Pdg Jawa 1/2/18 ? fee
SHAD 2602.3
28/5/18
28/5/18 Installed
2021 Bought at mixed shops; torx screws, portable pumps, puncture kits, ratchet and impact drives;
7/7/18 LSH Done
2240
1190
3430
25/8/18
2020 Mecinda
9/12/19
Contact
Boss Rahma Yahil 0193337725
Eddie Kelate
DJ Mie
AD Doc Amir
Wan Stoner
Waris kak Pah