Emm) Service Bulletin 98 Issue Date: February 2001
Subject: Return line oil flow switch
Product: SBS and H-Series Gyrasphere Crushers, Models 52, 57 and 68
(Serial No. 10218 and above)
The return line oil flow switch used on earlier Gyrasphere crushers is no longer needed. Please
disregard the installation instructions for this switch in the crusher operation and maintenance
manual.
Refer to the reverse side of this page for updated alarm wiring diagram. Contact the Telsmith
Service Department if you have any questions regarding alarm switch installation or wiring.
Return Line
@ Oil Flow Switch
(not used)
Telsmith, Inc. Tel: (262) 242-6600
10910 N. Industrial Drive, P.O. Box 539 Fax: (262) 242-7861
Mequon, WI 53092
U.S.A. www.telsmith.comSaas 7 RELAY TRI
' system {te Tey Tt SET ATS SECONDS
Ivourage SH ee ao
SRR TIA
oueune | ' = :
woTon STARTER I 7
ce
! ton | U1 oe
' test 2
r | | Door 4
rangronmen TT dere] FS t
wo | At woRW
1 [Loan 4
7
---~~-~- tle-a
"ALARM PANEL,
(Con TEANESRE)| '
1S PROVIDED. \
CONNECT PARALLEL,
WITH OIL PUMP
‘STARTER COIL
NLY IF TRANSFORMER
1S NOT PROVIDED
NORMALLY
‘CLOSED
t20vac
LINE 4
NEUTRAL 2
WIRE A
°F Tove
‘TEMPERATURE SWITCH IN
RETURN OIL LINE TO TANK
5
(Return tine oit
flow switeh not
used)
FOR DEVICE FEEDING CRUSHER
aise aoe
NOTES:
* When transformer is provided, supply adequate
fuse of circuit breaker protection.
* wen transformer is not provided, parallel with oll
pump starter col (120 Volts only)
=When oil pur in ON, a
“When oll pump Is OFF, alarm power is disconnected.
FLOWSWHTCH Wine PRESSURE SWITCH WIRE
NORMALLY OPEN NORMALLY OPEN
ioe toed ine)
rowine2
Gar] LOCATE conTROL RELAY
(GRt)IN STARTER CABINET
| O™ siprep Loose)
pam cmscranraigi ed |e aaem Peta -
‘STOP | oo!
“FROM 1
ouruuP FRM |
StanTER HYDRAULIC!
RELIEF |
PANEL
TVPICAL CRUSHER STARTER CIRCUITRY
* Oil pump must be interlocked tothe crusher starter.
Alarm Wiring Diagram (Revised February 2001)