Professional Documents
Culture Documents
After Stopping Engine
After Stopping Engine
Previous Screen
Welcome: j065btl
Product: INDUSTRIAL ENGINE
Model: C13 INDUSTRIAL ENGINE RRA01544
Configuration: C13 Industrial Engine RRA00001-UP
i04137729
Note: After operation, allow 10 minutes for the engine oil to return to the oil pan before checking the engine oil
level.
Check the crankcase oil level. Maintain the oil level between the "ADD" mark and the "FULL" mark on
the oil level gauge.
Note: Only use oil that is recommended in this Operation and Maintenance Manual, "Fluid Recommendations"
article. Failure to do so may result in engine damage.
If necessary, perform minor adjustments. Repair any leaks and tighten any loose bolts.
Note the service hour meter reading. Perform the maintenance that is in the Operation and Maintenance
Manual, "Maintenance Interval Schedule".
Fill the fuel tank to prevent accumulation of moisture in the fuel. Do not overfill the fuel tank.
Allow the engine to cool. Check the coolant level. Maintain the cooling system at 13 mm (0.5 inch) from
the bottom of the pipe for filling.
Note: Only use coolant that is recommended in this Operation and Maintenance Manual, "Fluid
Recommendations" article. Failure to do so may result in engine damage.
If freezing temperatures are expected, check the coolant for proper antifreeze protection. The cooling
system must be protected against freezing to the lowest expected outside temperature. Add the proper
coolant/water mixture, if necessary.
Perform all required periodic maintenance on all driven equipment. This maintenance is outlined in the
instructions from the OEM.
Copyright 1993 - 2017 Caterpillar Inc. Wed Dec 20 2017 12:49:10 GMT+0600 (Bangladesh Standard Time)
All Rights Reserved.
j065btl
Private Network For SIS Licensees.
https://sis.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/productsearch/productheaderinfoframeset.jsp&calledpage… 1/1