Professional Documents
Culture Documents
Strength Assignment
Strength Assignment
NB: This is an Individual assignment copying from one another will result in zero mark.
1 A beam is loaded by a couple of 1400 N.m at each of its ends, as shown in Fig 1. The beam is
. of steel and has a rectangular cross section, as shown. Determine the maximum bending stress
in the beam and indicate the variation of bending stress over the depth of the beam.
4 cm
2 cm
Figure 1.
3 Reconsider the question No. 2 for the case where the rectangular beam is replaced by an I- beam
. with cross section shown in Fig. 2. Determine the maximum tensile and compressive bending
stresses.
4cm
1cm
3cm
N.A.
1cm
3cm
1cm
Figure 2.
4 A plane element is subject to the stresses shown in Fig. 3. Determine (a) the principal stresses
. and their directions and (b) the maximum shearing stresses and the directions of the planes on
which they occur. Use the equations
y 30𝑀𝑃𝑎
90𝑀𝑝𝑎
x
40𝑀𝑃𝑎
Figure 3.
5 A plane element is subject to the stresses shown in Fig. 4. Using Mohr’s circle, determine (a) the
. principal stresses and their directions and (b) the maximum shearing stresses and the directions of the
planes on which they occur.
y 30𝑀𝑃𝑎
90𝑀𝑝𝑎
x
40𝑀𝑃𝑎
Figure 4.
6 A simply supported beam is subjected to a uniform load of 2kN/m over the region shown in Figure 5.
. Determine the maximum shearing force and bending moment in the beam by drawing SFD and BMD.
2 kN/m
1m 1m
2m
Figure 5.
7 For the cantilever beam loaded as shown in figure 6. Draw the shearing Force and bending moment
. diagrams.
2.4 kN 1.2 kN
A
B
2m 1m 1m
1.5 kN
Figure 6.