PHENOM 100NORMAL CHECKLIST
Cease
Courtesy Light. KD
NOTE: Only required for fights with landings after sunset.
Emergency Door Locking Pin. REMOVE
Emergency Door. ‘SECURED AND LOCKED
Water Barrier ‘AS REQUIRED
Documents, Manuals and Charts... CKD ON BOARD.
Maintenance Status kD
Emergency Equipment CKD
‘Oxygen Bottle Valve Handle....... PUSH TO RESTORE
Oxygen SUPPLY CONTROL Knob PAX AUTO.
‘Oxygen Mask Regulator... CKD 100%
GEN 1 & 2 Switches... AUTO
GPU Button.. AS REQUIRED
BUS TIE Knot “AUTO
BATT 1825: OFF
If Ice Detector is applicable:
TEST Panel
CKO ALLIN
AUTO
“PUSHED OUT
ARMED
PUSHED OUT
‘AUTO
Circuit Breakers...
FUEL PUMP 1 & 2 Switches.
FUEL XFR Button.
ELT Switch.
PUSHER CUTOUT Button ..
HYD PUMP Knob.
Gust Lock Pin. REMOVE
Rudder Gust Lock. RELEASE
WSHLD 1 & 2 Switches. OFF
ADS/AOA Knob ‘AUTO
ENG 1 & 2 Switches. OFF
WINGSTAB Switch OFF
INSP LIGHT Switch OFF
LDG GEAR Lever
PRESN MODE Switch .
BLEED Knob.
DUMP Button.
AIR CONDITI .
‘SHUTOFF 1 & 2 Buttons...
BOTTLE Switch...
STARTISTOP Knobs ..
Flap Lever.
SPEED BRAKE Switch (if available).
Parking Brake.
Seats and Belts ‘CONDITION
eae
“PUSHED OUT
WAS REQUIRED
BATT 1 &2 Switches ON
GPU Button ‘AS REQUIRED
CVDR Panel (if operative) CKD
Transponder/TCAS Il (if applicable)... AS REQUIRED
Set transponder to ALT mode or as required by local
rules.
If airplane is equipped with TCAS Il, verify TCAS II in
STBY mode.
For operations requiring ADS-B Out, the transponder
should be in ALT mode.
Electronic Checklist (if operative) KD
EE nasal
‘Oxygen Mask Flow and Microphone KD
SIGNS/OUTLET Switch BELTS/ON
External Lights ‘AS REQUIRED
Fuel Quantity and Balance CKD
Oxygen Pressure for Dispatch. CKD
TEST Panel (except ice detector TEST
‘TEST Panel . OFF
ENG IGNITION Switches AUTO
Thrust Levers IDLE
SET
‘CLOSED
aia
GPU (if applicable). ..DISCONNECT
ELEC EMER Button .. PUSHIN
Batteries 1 & 2 Voltage. ve CKD
CAUTION: EACH BATTERY VOLTAGE MUST BE AT
LEAST 23.8 VOLTS,
NOTE: The parking brake must be applied and the main
brake must be released for batlery voltage check.
ELEC EMER Button PUSH OUT
External Lights AS REQUIRED
AFCS Control Unit SET
Altimeters (pilots and IES!)
Transponder/TCAS Il (if applicable)
Set transponder CODE and Flight
If airplane is equipped with TCAS Il, verify TCAS II in
STBY mode.
For operations requiring ADS-B Out, the transponder
should be in ALT mode.
‘Takeoff Speeds (Vs, Vay Vay Ves) SET
CAUTION: SET THE SPEEDS IN SEQUENCE. IF IT IS
NECESSARY TO CORRECT ONE OF THE
SPEEDS OUT OF THE SEQUENCE, ALL THE
OTHERS MUST BE VERIFIED.
Engine Takeoff Data
SET
LFE “SET
Flight Controls .. CKD FREE
Trims ‘CKD & SET
NOTE: It is recommended that the selected pitch trim
Position (digital readout) is equal to the CG %MAC,
Flap SET TIO
Ice Protection AS REQUIREDBEFORE TAKEOFF
Takeoff Configuration. CKD
CAS Messages .. CKD
SIGNS/OUTLET Switch .. “PED-BELTSIOFF
SHORTLY BEFORE TAKEOFF.
Passengers ADVISE
Lights .. ‘AS REQUIRED
Paes)
LDG GEAR Lever...
Flap.
Thrust Levers
Altimeters (pilots and IES!)
Yaw Damper.
Icing Conditions,
Flight Director.
SIGNS/OUTLET Switch
External Lights ..
Weather Radar (if installed)
Airspeed...
WSHLD 1 & 2 Switches.
AS REQUIRED
AS REQUIRED
AS REQUIRED
AS REQUIRED
AS REQUIRED
P=
Landing Speeds (Vrer, Vacy Vrs) ~
CAUTION: SET THE SPEEDS IN SEQUENCE. IF IT IS
NECESSARY TO CORRECT ONE OF THE
SPEEDS OUT OF THE SEQUENCE, ALL THE
OTHERS MUST BE VERIFIED.
... VERIFY
BELOW 10000 F’
SIGNS/OUTLET Switch .. .-» PED-BELTSIOFF
Tae
External Lights. AS REQUIRED
Passengers sens ADVISE
FUEL XFR Button. PUSHED OUT
Altimeters (pilots and IESI)... SET & X-CKD
Icing Conditions. VERIFY
WSHLD 1 & 2 Switches AS REQUIRED
es
Yaw Damper... sess OFF
LDG GEAR Lever. DN AND CKD
Flap SET
Airspeed Maer
La OP
Flap ZERO
Lights. AS REQUIRED
Transponder. AS REQUIRED
For operations requiring ADS-B Out, the transponder
should be in ALT mode.
Err
Thrust Levers IDLE
Emergency/Parking Brake ‘APPLY
WSHLD 1 & 2 Switches. OFF
ADSIAOA Knob. ‘AUTO
ENG 1 & 2 Switches. OFF
WINGSTAB Switch OFF
STARTISTOP Knobs ‘STOP
Check MFD status page for engine message.
SIGNS/OUTLET Switch. OFFION
Ae ee
‘Oxygen Bottle Valve Handle. PULL To CUTOUT
BATT 1&2 Switches OFF
Gust Lock Pin. INSTALL
Rudder Gust Lock. Lock
Lights. OFF