You are on page 1of 1

Home Community 4G6x Swap Other Info F.A.Q.

Wiring Information
If you need to check ECU or relay pinouts, this page should have all the
info you'll need.

DSM ECU Pinout

Connector A (C-66) (Biggest)


Pin Connection Pin Connection
1 Self-Diagnosis Output (Y) Control Relay (Fuel Pump Relay Control)
13
2 Diagnosis/Data Transfer (W) (BW)
3 Boost Gauge (BR) 14 Idle Switch (G)
4 Oxygen Sensor (W) 15 EGR temperature sensor (CA only) (LY)
5 Power Steering Oil Pressure Switch (BY) 16 Barometric Pressure Sensor in MAFS (GY)
6 Resistor in MAFS (GW) 17 Sensors Ground (GB)
7 Air Conditioner Switch (BG) 18 Vehicle Speed Sensor (YW)
8 Intake Air Temperature Sensor (GO) 19 Throttle Position Sensor (GW)
9 Knock Sensor (W) 20 Coolant Temperature Sensor (YG)
10 Air Flow Sensor in MAFS (GL) 21 Crank Angle Sensor (RPM) (B)
11 ABS Control Unit (AWD, ABS Only) (RL) 22 Top Dead Center Sensor (Cam Signal) (W)
Ignition Timing Adjustment Connector 23 Sensor Power (+5v) (GR)
12
(YR) 24 Sensors Ground (GB)
Connector B (C-65) (Middle)
Pin Connection Pin Connection
51 Cylinder 1 Injector (YG) 60 Cylinder 3 Injector (Lg)
52 Cylinder 2 Injector (YB) 61 Cylinder 4 Injector (LgW)
53 EGR Control Solenoid Valve (CA) (BY) 62 Purge Control Solenoid Valve (BW)
54 Power Transistor for #1 & #4 Coil (Y) 63 Control Relay Pin 8 (BL)
55 Power Transistor for #2 & #3 Coil (YR) 64 Engine Warning Light (CEL) (RG)
56 Control Relay (Fuel Pump Control) (WR) 65 Air Conditioner Relay (RL)
57 Fuel Pressure Control Valve (W) 66 Control Relay Pin 8 (BL)
58 Coil "A1" for ISC Servo (L) 67 Coil "B1" for ISC Servo (W)
59 Coil "A2" for ISC Servo (Y) 68 Coil "B2" for ISC Servo (B)
Connector C (C-64) (Smallest)
Pin Connection Pin Connection
101 Ground (B) 106 Ground (B)
102 Power (+12V) (R) 107 Power (+12V) (R)
103 Backup Power (+12v) (BR) 108 Ignition Switch - ST terminal (start signal) (BY)
104 Inhibitor Switch (A/T) / Ground (M/T) (B) 109 Ignition Pulse Detect (Tach) (W)
105 Wastegate Solenoid (O) 110 Ignition Switch - IG terminal (on signal) (BW)

DSM Main (Control) Relay

Pin Connection
Pin Connection
1 No Connection 6 Ground (B)
2 Fuel Pump (BG) 7 ECU pin 56 (Fuel Pump Signal) (WR)
3 Ignition (BW) 8 ECU pin 63 and pin 66 (BL)
4 Power (+12V) (R) 9 Starter Signal (BY)
5 Power (+12V) (R)
10 Constant +12 V Power Supply (R)

Starion ECU Pinout

Connector A (B-37) (Yellow)


Pin Connection Pin Connection
Engine Speed Sensor ( IGN Coil (-) Ignitor Advance Control Signal (YB) / Test
1 13
Terminal) (W) Connector (RY)
2 Air Flow Sensor (WB) 14 Sensor Power - MPS Backup (LY)
3 Motor Position Sensor (LR) 15 Throttle Position Sensor (GW)
4 Sensor Ground (B) 16 Barometric Pressure Sensor (BW)
5 Intake Air Temperature Sensor (GR) 17 No Connection
6 Coolant Temperature Sensor (YG) 18 No Connection
7 Idle Switch (YR) 19 Vehicle Speed Sensor (LgB)
8 No Connection 20 Secondary Air Control Solenoid Valve (RG)
9 No Connection 21 Diagnosis Output (BR)
10 Sensor Power (+5V) (GR) 22 Control Relay (Fuel Pump Relay Control) (WR)
11 Oxygen Sensor (W) 23 ISC Servo (for extension) (YL)
12 ISC Servo (for retraction) (YB) 24 Air Conditioner Power Relay (??)
Connector B (B-36) (Green)
Pin Connection Pin Connection
51 Power (+12V) (R) 57 Power (+12V) (R)
52 Ground (B) 58 Inhibitor Switch (A/T) / Ground (M/T) (BY)
53 Ground (B) 59 Boost Gauge (YG)
X 60 Injector 1 (Primary) (YB)
54 EGR control solenoid valve (RW) 61 Knock Sensor (Br)
55 Ignition Switch - ST terminal (start signal) (BY) 62 Injector 2 (Secondary) (YL)
56 Air Conditioner Switch (BW) 63 Backup Power (+12V) (RB)

Starion Main (Control) Relay (B-30)

Pin Connection Pin Connection


1 Fuel Pump (BW) 2 ECU pin 22) (Fuel Pump Signal) (WR)
3 Injector Power (BR) 4 Ground (B)
5 ECU pin 52 (Ground) (R) 6 Ignition Switch - ST terminal (start signal) (BY)
7 Battery +12 V Direct (20A Fused) (B) 8 Ignition Switch - IG terminal (on signal) (L)

© 2012 Bowman Cybernetics

You might also like