Professional Documents
Culture Documents
Avee Mic Add On User Guide V1 3
Avee Mic Add On User Guide V1 3
Connector headphone
Bose™ QC25™ & QC35™ 2.5mm four pin audio
Sony WH-1000XM3
™ ™
3.5mm four pin audio
Connector AC interface cable USB 3.1C
Bias voltage accepted 10-16VDC
Microphone type Noise reduction
Microphone output signal 0.7 V RMS @ 1khz / 74dB SPL
Adjustable in 10 steps 20-100%
Maximum level is 1.5V RMS
Minimum level is 0.2V RMS
Speaker audio level Adjustable in 6 steps / 10-100%
Mono/stereo detection Automatic (default setting)
Configurable with the Avee Bluetooth Controller*
Stereo detection signal level 0.2V RMS
Adjustable using the Avee Bluetooth Controller*
Firmware Upgradeable with the Avee Bluetooth Controller*
AVEE COMBINATION KIT
DEFAULT SETTINGS
USER GUIDE
Version 1.3 April 5 - 2019
Output volume 60% (step 4)
Microphone output signal 0.7V RMS (step 6) By following the simple instructions in this user guide,
you will safely install the avee add-on to your headphones.
Start-up mode Use last setting
By appying a magnetic adhesive strip to the headphones, the avee add-on
is securely attached to the headphones.
DISCLAIMER
Avee is an unlicensed third-party accessory and is not affiliated with Bose™ or Sony™.
Bose™ does not approve or endorse the products manufactured by Avee.
SETUP INSTRUCTIONS GENERAL USE
Follow the simple general function commands below to adjust your audio settings.
In your shipment you should have received the following components:
All settings will be stored in the avee add-on.