Professional Documents
Culture Documents
MS-E07/F07: Instruction Manual
MS-E07/F07: Instruction Manual
Important It indicates cautions and limitations that must be followed during Part Names
operation.
−V
Point It indicates additional information on proper operation.
DC output terminals
Reference It indicates tips for better understanding or useful information. Connect the load cable
+V
MS-E07: 5 VDC
MS-F07: 12 VDC
Output indicator
Safety Information for MS Series Illuminates when DC output (+V,
-V) is ON.
• Do not use this product for the purpose to protect a human Output voltage adjustment trimmer
body or a part of human body. Adjusts output voltage within the
• This product is not intended for use as explosion-proof range of ±5%.
product. Do not use this product in a hazardous location and/
or potentially explosive atmosphere. FG terminal
• Do not perform any electrical wiring while electric current is Connect the grounding cable.
applied. Failure to follow this may result in an electric shock or
fire.
• Be sure to connect the grounding cable. Failure to follow this
may result in an electric shock or fire. AC input terminals
WARNING
• Do not touch this unit within 1 minute after AC input is turned Connect the input cable (100 to
off. Failure to follow this may result in an electric shock. 240 VAC)
• Do not modify or repair this unit. Failure to follow this may Note: This terminal is N.C. (not connected) unless otherwise specified.
result in an electric shock, accident, or product failure. Do not use this terminal.
• Do not touch any terminal of this unit while electric current is
applied.
Use the unit with the terminal cover installed to avoid an Installation Method
electric shock.
Surrounding area
• When this unit is used in a system that may cause a serious For heat dissipation, leave the following space between this unit and
accident or damage if the unit fails, be sure to install a safety control console walls or other devices.
device. Every direction: 10 mm min. 10 mm or more
• Pay attention to prevent foreign matter such as metal particles,
dust, paper, or wood chips from entering the inside of this
unit. Failure to follow this may result in a fire or product failure. 10 mm or
CAUTION more 10 mm
• Do not touch any metallic part while electric current is applied or more
or immediately after input is shut off. Failure to follow this may MS-E/F
result in a burn due to a high temperature.
• If a failure or abnormality occurs while this unit is in use,
immediately shut off AC input and stop operation of this unit.
Failure to follow this may result in a fire or accident.
10 mm or more
1 MS-E07/F07-IM_E
Installation orientation
Standard and upward installationis available as shown below. Output Derating Characteristic
100
* The characteristic data shown above are
90
80
obtained when this unit is installed as
• The ambient temperature for this unit should not exceed the upper temperature
limit (refer to the derating characteristic). When the upper temperature limit may 22 70.7
Mounting hole
2 x ø5
be exceeded, install a forced fan or cooler so that the ambient temperature is 30 75
MS-E07/F07-IM_E 2