Professional Documents
Culture Documents
Assignment
Assignment
Project (1)
10 Marks
Project description:
Resistor starting is one of the methods employed to reduce the amount of starting current. It is
accomplished by connecting resistors in series with the motor during the starting period (Figure 1). Some
control circuits sense motor speed to determine when to shunt the resistors out of the power line e (Figure
2). In the illustration, permanent magnets are attached to the motor shaft, and a Hall effect sensor
determines the motor speed. When the motor speed reaches a predetermined level, contactor R
energizes and shunts the resistors out of the line
Figure 1 Figure 2
Requirements
1- Use automation studio software to draw and simulate both power and *An indication lamp
control circuit diagrams for this system (using push buttons, timer relays for each motor mode
of operation should
circuit breakers, overloads, and contactors) to do the whole job.
be included.
2- If PLC is recommended to be used, define the required PLC *An overload for each
inputs/outputs then use Zelio software PLC program to define the ladder motor should be
diagram and simulate the system operation. provided.
3- Explain in detail the theory of operation of the HALL EFFECT SENSOR.
Good luck
Page 1 of 1