Professional Documents
Culture Documents
1093 Grohe WEP-I Product Listing Certificate '22-'23
1093 Grohe WEP-I Product Listing Certificate '22-'23
#43, 4th floor, PMR Towers, Beretena Agrahara, Near Hosa Road Junction,
Hosur Main Road, Bangalore – 560 100
C E R T I F I C A T E OF L I S T I N G
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
OF L I S T I N G
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1091 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
IDENTIFICATION: The manufacturer’s name or registered trademark, or, in the case of private labeling, the name of the customer for whom the fixture
was manufactured, shall be permanently applied so as to be legible and visible after installation. The model number of each water closet,
or bowl and tank model numbers (in the case of close-coupled water closets) shall be applied on each component so as to be legible and
visible after installation. Each water closet shall be marked, identifying the water consumption of the fixture.
Each Gravity flush tank shall be permanently marked by the manufacturer with a water level mark, or with the information necessary to
determine the water level in the tank needed to deliver the intended flush volume. This mark shall be applied to the vitreous body in the
tank, the tank liner, or the flush-valve overflow tube. The vertical distance between the water level mark and the lowest point of the tank
overflow channel shall not exceed 38 mm.
Water closet tanks shall have a label indicating at least the following:
a) the telephone number of a service department from which end-users can obtain replacement
parts
b) the serial or part number of the flush valve seal; and
c) information on procuring replacement parts for maintaining the original flush volume.
Fittings shall bear permanent legible markings to identify the manufacturer, the trade name, registered trademark, or other
mark(s) known to identify the manufacturer. All packaging for vitreous plumbing fixtures and each fitting shall be marked identifying
its water consumption expressed in terms of liters per minute or liters per cycle or liters per flush.
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 1
IAPMO India Pvt Ltd
#43, 4th floor, PMR Towers, Beretena Agrahara, Near Hosa Road Junction,
Hosur Main Road, Bangalore – 560 100
C E R T I F I C A T E OF L I S T I N G
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
OF L I S T I N G
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
IDENTIFICATION: Aerators used in the fittings shall bear permanent legible markings to identify the manufacturer, the trade name, registered
trademark, or other mark(s) known to identify the manufacturer. Each fitting and its packaging shall also be marked identifying its
water consumption expressed in terms of liters per flush or liters per cycle. All required markings shall be located where they can
be readily legible after installation is complete. Fittings and its packaging shall also bear the WEP-I Star rating certification mark.
CHARACTERISTICS: Fittings such as aerators shall be installed in accordance with the manufacturer's instructions for achieving water efficiency, and
these may be installed with bar, kitchen, lavatory metered/non-metered faucets, handheld spray heads and showerheads.
Sample products listed on this certificate were found compliant to Water Efficient Products – India (WEP-I) specification and
applicable sections of ASME A112.18.1-2018/CSA B125.1-18, IGBC Green Pro Rating Systems, LEED V4-2019 and
GRIHA compliance. Sample products were tested by an IAPMO India recognized laboratory that was found compliant to the
applicable requirements of ISO/IEC 17025
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 2
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Product Aerator
F
Water Consumption (Liters/flush; 2017
Green Points Rating
System
Liters/min; Liters/cycle) WEP-I
S.No Model Product Model Description Model
Star LEED V4 2019
Number Number
Rating Factory
Baseline Rated Savings Homes1
Bldg2
SHOWER APPLICATION
2 27812IL1 NEW TEMPESTA0F TRIGGER SPRAY SET 58.8634.1 8 4.08 3.92 49% 4 4
8 40.1058.033 BAUCURVE OHM COLD WATER BASIN 32809000 8 3.64 4.36 55% 4 4
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 3
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
S.No
MATERIAL
CODE
MATERIAL
DESCRIPTION
PRODUCT
TYPE
Compatible
Aerator
F
or Liters/cycle - LPC) WEP-I
Star
System
LEED V4 2019
code
Rating Factory
Baseline Rated Savings Homes1
Bldg2
Euphoria Cube 152
1 27705000 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 9,5L
Euphoria 260 Headshower
2 26456000 Head Shower 5886451 10 5.7 4 43% 4 4
6, 6L
Euphoria 260 Headshower
3 26457000 Head Shower 5886451 10 5.7 4 43% 4 4
9, 5L
Euph Cosmopolitan 180
4 27492000 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 2.5Gpm
Euph Cosmopolitan 160
5 28233000 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 9, 5L
Ntempesta 210
6 26409000 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 6.6L
Ntempesta 210
7 26410000 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 9, 5L
Ntempcosmopolitan 200
8 27541001 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 4
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Material Description
S.No Material Code Product Aerator Baseline Rated Savings Star Homes1 Factory
Type Code Rating Bldg2
9 26410000
Ntempcomopolitan 100 I
Headshower 6,6L
Head Shower 5886451
F 10 5.7 4 43% 4 4
Ntempcosmopolitan 100 Iv
10 27541001 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower 9, 5L
Rain shower 310 Mono 9,
11 26564000 Head Shower 5886451 10 5.7 4 43% 4 4
5L
Head shower 310 Mono
12 26566000 Head Shower 5886451 10 5.7 4 43% 4 4
Eco Joy
Head shower Allure 230 Eco
13 27480000 Head Shower 5886451 10 5.7 4 43% 4 4
Joy 9, 5L
Tempesta 100 cosmopolitan
14 27869001 Head Shower 5886451 10 5.7 4 43% 4 4
Eco Joy 9, 5L
Ntempesta 100 Iii
15 26088001 Head Shower 5886451 10 5.7 4 43% 4 4
Headshower Set
Tempesta 100 cosmopolitan
16 27870001 Head Shower 5886451 10 5.7 4 43% 4 4
Eco Joy 9, 5L
Head shower F series 10"
17 27271000 Head Shower 5886451 10 5.7 4 43% 4 4
Eco Joy
Rainshower 310 Mono
Head Shower Set 1- Spray,
18 26558000 Head Shower 5886451 10 5.7 4 43% 4 4
Round, Wall-Mounted,
Chrome, 2.5GPm
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 5
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
S.No Material Code Material Description Product Type Aerator Code Baseline Rated Savings Star Rating Homes1 Factory
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
35 28034000 Sena stick Handshower Hand Shower 5886451 10 5.1 4.9 49% 4 4
Ntempesta 100
36 27799001 Hand Shower 5886451 10 5.1 4.9 49% 4 4
IIHandshower
set
Euphoria 110
37 27265000 Hand Shower 5886451 10 5.1 4.9 49% 4 4
MonoHandshower
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 7
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 8
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Star Rating
S.No Material Material Description Product Aerator Baseline Rated Savings Homes1 Factory
Code
Ntempcosmopolitan 100 II
Type Code F Bldg2
Ntempesta 100 II
49 27799001 Hand Shower 5886451 10 4 6 60% 4 4
Handshower set
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 9
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
MATERIAL PRODUCT
COMATIBLE FWater Consumption (Liters/flush;
Liters/min; Liters/cycle)
2017 System
S.No MATERIAL DESCRIPTION AERATOR WEP-I
CODE TYPE LEED V4 2019
CODE Star
Rating Factory
Baseline Rated Savings Homes1
Bldg2
Basin Mixer-
1 32898001 Essence New Ohm Basin S Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Basin Mixer-
2 23589001 Essence New Ohm Basin S Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Basin Mixer-
Eurodisc Cosmopolitan
3 23432000 Deck 401059000 8 1.9 6.1 76% 4 4
Ohm Vessel Basin
Mounted
Basin Mixer-
Eurodisc Cosmopolitan
4 23049002 Deck 401059000 8 1.9 6.1 76% 4 4
Ohm Basin
Mounted
Basin Mixer-
Eurodisc Cosmopolitan
5 33190002 Deck 401059000 8 1.9 6.1 76% 4 4
Ohm Basin
Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 10
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Basin Mixer-
11 32819000 Bauedge Ohm Basin Deck Mounted 401059000 8 1.9 6.1 76% 4 4
Basin Mixer-
12 32858000 Bauedge Ohm Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 11
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
S.No Material Code Material Description Product Type Aerator Code Baseline Rated Savings Star Rating Homes1 Factory
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 12
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
S.No Material Code Product Aerator Code Baseline Rated Savings Star Rating Homes1 Factory
Material Description
Type
F Bldg2
Basin Mixer-
Eurostyle 2015 Ohm Basin
20 23707003 Deck 401059000 8 1.9 6.1 76% 4 4
S- Size
Mounted
Basin Mixer-
21 33558003 Eurostyle 2015 Ohm Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Basin Mixer-
22 23719003 Eurostyle XL Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Basin Mixer-
23 23570003 Eurostyle XL Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Basin Mixer-
24 32851000 Bauflow Ohm Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Bauflow Ohm Cold water Basin Pillar
25 32813000 401059000 8 1.9 6.1 76% 4 4
Basin tap
Basin Mixer-
26 32848000 Baucurve Ohm Basin Deck 401059000 8 1.9 6.1 76% 4 4
Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 13
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Star Rating
S.No Material Product Aerator Baseline Rated Savings Homes1 Factory
Code
Material Description
30 36265000 Euroeco Ct Self- Clos. Basin Basin Pillar tap 401059000 8 1.9 6.1 76% 4 4
Basin Pillar tap
31 20236000 Baucurve Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
32 20281000 Baucurve Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
33 20235000 Bauflow Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
34 20280000 Bauflow Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
35 20238000 Bauedge Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
36 20284000 Bauedge Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Basin Pillar tap
37 20237000 Bauloop Wall Tap Basin 401059000 8 1.9 6.1 76% 4 4
Wall
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 14
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Sink Mixer
Code F Bldg2
50 31222000 Bauloop Pillar Tap sink Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
51 31223000 Bauedge Pillar Tap sink Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
52 31226000 Baucurve Wall Tap sink Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
53 31225000 Bauflow wall tap sink In Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
54 31227000 Bauloop Wall Tap Sink Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
55 31228000 Bauede Walll Tap sink Sink Tap wall 401059000 8 1.9 6.1 76% 4 4
Euroeco Ct SetConc.Shower
56 36268000 Tap 401059000 8 1.9 6.1 76% 4 4
Euroeco Ct Self-Clos.Shower
59 36267000 Tap 401059000 8 1.9 6.1 76% 4 4
Exp
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 16
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Basin Mixer-
Code F Bldg2
60 23324001 401059000 8 1.9 6.1 76% 4 4
Smooth Body M Deck Mounted
BauClassic OHM basin smooth Basin Mixer-
61 32863000 401059000 8 1.9 6.1 76% 4 4
body Deck Mounted
Basin Mixer-
62 32868000 BauClassic OHM Vessel Fitting 401059000 8 1.9 6.1 76% 4 4
Deck Mounted
Basin Mixer-
63 32898001 Essence New Ohm Basin S 4010580230 8 3.8 4.2 53% 4 4
Deck Mounted
Basin Mixer-
64 23589001 Essence New Ohm Basin S 4010580230 8 3.8 4.2 53% 4 4
Deck Mounted
Eurodisc Cosmopolitan Ohm Basin Mixer-
65 23432000 4010580230 8 3.8 4.2 53% 4 4
Vessel Basin Deck Mounted
Eurodisc Cosmopolitan Ohm Basin Mixer-
66 23049002 4010580230 8 3.8 4.2 53% 4 4
Basin Deck Mounted
Eurodisc Cosmopolitan Ohm Basin Mixer-
67 33190002 4010580230 8 3.8 4.2 53% 4 4
Basin Deck Mounted
Eurodisc Cosmopolitan Pillar Basin Pillar
68 23051002 4010580230 8 3.8 4.2 53% 4 4
Tap Basin Tap
Basin Mixer-
69 32805000 Baucurve Ohm Basin 4010580230 8 3.8 4.2 53% 4 4
Deck Mounted
Basin Mixer-
70 32810000 Bauflow Ohm Basin 4010580230 8 3.8 4.2 53% 4 4
Deck Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 17
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
71
Code
32814000 Bauloop Ohm Basin
Basin Mixer- Deck
Code
4010580230
F 8 3.8 4.2 53% 4
Bldg2
4
Mounted
Basin Mixer- Deck
72 32854000 Bauloop Ohm Basin 4010580230 8 3.8 4.2 53% 4 4
Mounted
Basin Mixer- Deck
73 32819000 Bauedge Ohm Basin 4010580230 8 3.8 4.2 53% 4 4
Mounted
Basin Mixer- Deck
74 32858000 Bauedge Ohm Basin 4010580230 8 3.8 4.2 53% 4 4
Mounted
Basin Mixer- Deck
75 32860000 Bauedge Ohm Vessel 4010580230 8 3.8 4.2 53% 4 4
Mounted
Fitting
76 32856000 Bauloop Ohm Vessel
Basin Mixer- Deck
Fitting 4010580230 8 3.8 4.2 53% 4 4
Mounted
Eurosmart Cosmopolitan Basin Mixer- Deck
77 3282500E 4010580230 8 3.8 4.2 53% 4 4
OhmBasin Ecojoy Mounted
Eurosmart Cosmopolitan Basin Mixer- Deck
78 32825000 4010580230 8 3.8 4.2 53% 4 4
OhmBasin S Mounted
Eurosmart 2015 Ohm Basin Mixer- Deck
79 23322001 4010580230 8 3.8 4.2 53% 4 4
BasinM-Size Mounted
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Basin Pillar
Code F Bldg2
92 36265000 Euroeco Ct Self-Clos. Basin 4010580230 8 3.8 4.2 53% 4 4
Tap
Basin Pillar
93 20236000 Baucurve Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
94 20281000 Baucurve Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
95 20235000 Bauflow Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
96 20280000 Bauflow Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
97 20238000 Bauedge Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
98 20284000 Bauedge Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
99 20237000 Bauloop Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Basin Pillar
100 20283000 Bauloop Wall Tap Basin 4010580230 8 3.8 4.2 53% 4 4
Tap Wall
Euroeco Ct Self-Clos. Basin Basin Pillar
101 36266000 4010580230 8 3.8 4.2 53% 4 4
Exp Tap Wall
Eurosmart 2015 Ohm Basin Basin Mixer-
102 32467002 4010580230 8 3.8 4.2 53% 4 4
Smooth Body S Deck Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 20
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Sink MixerDeck
Code F Bldg2
103 31221000 Baucurve Pillar Tap Sink 4010580230 8 3.8 4.2 53% 4 4
Sink MixerDeck
104 31220000 Bauflow Pillar Tap Sink 4010580230 8 3.8 4.2 53% 4 4
Eurosmart 2015 Ohm Sink Sink MixerDeck
105 3328120E 4010580230 8 3.8 4.2 53% 4 4
Low Spout
Costa L, Wall Mixer Spout Sink MixerWall
106 31191001 4010580230 8 3.8 4.2 53% 4 4
Above
Bauflow Sink OHM Sink Swivel Sink MixerWall
107 31230001 4010580230 8 3.8 4.2 53% 4 4
Spout
Baucurve Sink OHM Sink Sink MixerWall
108 31231001 4010580230 8 3.8 4.2 53% 4 4
Swivel Spout
Bauloop Sink OHM Sink Swivel Sink MixerWall
109 31232001 4010580230 8 3.8 4.2 53% 4 4
Spout
Bauedge Sink OHM Sink Sink MixerWall
110 31233001 4010580230 8 3.8 4.2 53% 4 4
Swivel Spout
Sink MixerWall
111 32482002 Eurosmart 2015 Ohm Sink Exp 4010580230 8 3.8 4.2 53% 4 4
112 31222000 Bauloop Pillar Tap Sink Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
113 31223000 Bauedge Pillar Tap Sink Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 21
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Star Rating
S.No Material Material Description Product Aerator Baseline Rated Savings Homes1 Factory
Code Type Code F Bldg2
114 31226000 Baucurve Wall Tap Sink Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
115 31225000 Bauflow Wall Tap Sink In Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
116 31227000 Bauloop Wall Tap Sink Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
117 31228000 Bauedge Wall Tap Sink Sink Tap Wall 4010580230 8 3.8 4.2 53% 4 4
118 36268000 Euroeco Ct Sect Conc. Shower Tap 4010580230 8 3.8 4.2 53% 4 4
119 36265000 Euroeco Ct Self - Clos. Basin Tap 4010580230 8 3.8 4.2 53% 4 4
Euroeco Ct Self - Clos. BasinExp
120 36266000 Tap 4010580230 8 3.8 4.2 53% 4 4
Euroeco Ct Self - Clos. Shower
121 36267000 Tap 4010580230 8 3.8 4.2 53% 4 4
Exp
Eurosmart 2015 OHM Basin Basin Mixer-
122 23324001 4010580230 8 3.8 4.2 53% 4 4
Smooth Body M Deck Mounted
BauClassic OHM BasinSmooth Basin Mixer-
123 32863000 4010580230 8 3.8 4.2 53% 4 4
Body Deck Mounted
Basin Mixer-
124 32868000 BauClassic OHM vessel Fitting 4010580230 8 3.8 4.2 53% 4 4
Deck Mounted
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 22
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
Product/ Model
F
Water Consumption (Liters/flush; Liters/min; 2017
Green Points Rating System
Liters/cycle) WEP-I
Star LEED V4 2019
Rating
Product/ Factory
S.N Product Description Aerators Baseline Rated Savings Homes1
Customer Code Bldg2
NEW SKU’s
Eurosmart OHM basin
1 23537003 6.00 1.82 4.18 70% 4 4
L
Alira OHM vessel
2 24246001 6.00 3.76 2.24 37% 2 4
basin XL IN A5904210000
Eurosmart OHM basin
3 23743003 A5904110000 6.00 3.75 2.25 38% 2 4
chain L
Eurosmart OHM basin 40205800002
4 23965003 6.00 3.68 2.32 39% 2 4
XS
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 23
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
7
Customer Code
29338003
Eurosmart OHM trimset basin
6.00
F
3.7 2.30 38% 2 4
2-h L
Eurosmart OHM
8 29337003
trimset basin 2-h M
6.00 3.67 2.33 39% 2 4
Eurosmart OHM basin
9 32467003
smth b S
6.00 1.27 4.73 79% 4 4
Eurosmart OHM basin
10 23967003 6.00 3.62 2.38 40% 4 4
smth b S
Eurosmart OHM basin M A5904210000
11 23322003 6.00 3.62 2.38 40% 4 4
Eurosmart OHM basin A5904110000
12 23324003
smth b M
6.00 1.79 4.21 70% 4 4
BauEdge OHM basin S 40205800002
13 32819001 6.00 3.45 2.55 43% 4 4
BauLoop pillar tap
14 32857001
basin smth b XS
6.00 3.63 2.37 40% 4 4
Alira OHM vessel basin
15 24249001 6.00 2.59 43% 4 4
3.41
16 20615001 Alira pillar tap 6.00 3.61 2.39 40% 4 4
Alira OHM set basin
17 24254001 6.00 3.42 2.58 43% 4 4
2-h M IN
BauEdge OHM basinsmth
18 32858001 6.00 1.72 4.28 71% 4 4
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 24
z
C E R T I F I C A T E OF L I S T I N G
OF
IAPMO India Private Ltd. (aka IAPMO India) is a product certification body which lists and inspects samples taken from the supplier's stock or from the market or a combination of both to verify compliance to the requirements of applicable
codes and standards. This activity is coupled with periodic surveillance of the supplier's factory and warehouses as well as the assessment of the supplier's Quality Assurance System. This listing is subject to the conditions set forth in the characteristics below and is not
to be construed as any recommendation, assurance or guarantee by IAPMO India of the product acceptance by Authorities Having Jurisdiction.
Licensee: Grohe India Pvt Limited, Baani, Address One, 10th Floor, Golf Course Road, Sector-56, Gurgaon – 122011, Haryana, INDIA
File : 1093 Products: Aerators in compliance with WEP-I star rating system Valid till: May 2024
S.N
Product/Customer
Code
Product Description
Star Rating by water consumption (1 Star/ 2 Star / 3 Star) Tested @ 4 bar pressure. Also tested as per LEED V04-2019 pressure rating of 4.15 Bar, Shower @ 5.5 bar.
Faucet (Non metered) – 8LPM/ 5.7LPM / 4.5LPM, Faucet (Metered) – 1L/Cycle, 1L/Cycle (Electronic), 0.5L/Cycle (Mechanical/Electronical),Faucet – Sink & Handheld Spray – 8LPM,
5.7LPM, 4.5LPM, Shower Head – 9.5LPM, 7.5LPM, 5.7LPM, European Water Closet (High Efficiency) – 4.8 LPF, <4.8LPF, <4.0LPF, Urinals - <3.8LPF, 2LPF, <1LPF.
This listing period is based upon the last date of the month indicated on the Effective Date and Void After Date shown above. Any change in material, manufacturing process, marking
or design without having first obtained the approval of IAPMO India, or any evidence of non-compliance with applicable codes and standards or of inferior workmanship, may be deemed
sufficient cause for revocation of this listing. Production of or reference to this form for advertising purposes may be made only by specific written permission of IAPMO India. Any
unauthorized alteration of this certificate will be grounds for revocation of this listing.
Page | 25