Professional Documents
Culture Documents
LCD Lift Manual
LCD Lift Manual
*High definition 1080p LCD Screen *Light and thin Aluminum case
Product Introduction
LCD Lift is mainly use for Multi-functional conference and training room. The monitor can be
hidden in the desk when not in operation. Rising up automatically by Touch switch or Remote
controller when needed.
LCD lift Could be individual control or networking control according to different requirements.
Functional Characteristics
* Product can be control by panel button ,remote controller, or central controller.
*The monitor will elevate automatically when the model rising to the height.
*Monitor shell will be closed automatically after come down
*When the monitor is falling down, the lift Turn-over door opening safe function.
*The lcd lift could achieved remote control function by RS232,RS485 communication agreement.
Packing List
1x LCD monitor Lift
1x Remote controller
1x Power Cable
Technical Parameters
1.Control Mode:
a.Panel manual control
b.Wireless 315M remote control
c.Central control system RS232,RS485 control.
Installation instructions
1.Vertically place the LCD lift into desk hold.
2.Installation troubleshooting:
a.Check if the LCD lift is Power on
b. Check if the connection panel indicator light turns on
c. Check if the remote controller with battery. Can test with Panel button at first.
Intelligent Control manual
1.LCD lift panel button control
2.Remote control Manual
a. Click Panel Stop button for a few second after the LCD lift is power on, move hands from the
button when the LCd lift is coming down and then Rise little, the Lift will be in remote control
model. Then use a needle to click the setup button which in the little round hold back of remote
controller.
b. Click Panel Stop button till the LCD lift falling down a little then rise twice, Clear the control
code of remote controller.
b. Click remote controller Rise, Down, Stop buttons before the LCD lift rise to the height, the
Model will perform the action.
A: Connect way:
RJ45 , 6 pin is 485+, 8 pin is 485-
B: Data Transmission port:
Baud Rate: 2400
Data bits: 8 bit
Parity bit: None
Stop bit: 1 bit
C: Hex Control Code
Full-control versatility code:
Rise: FF EE EE EE DD
Down: FF EE EE EE EE
Stop: FF EE EE EE CC
Group control need to Setup
FF D1 D2 D3 Function Code (DD=Rise, EE=Down, CC=Stop) D1, D2,D3 is Custom address
code.
Code setup:
Click the Stop button till the LCD lift down a little (Same as remote controller setup way), Use
series assistant software sending code: FF D1 D2 D3 AA(D1,D2,D3is cutom address code), For
example, If sending code FF 10 11 01 AA, then central control code will be FF 10 11 01 function
code (DD=Rise, EE=Down, CC=Stop).
Software Setup:
Group Control:
Set up the LCD lifts to the same address code, Use public address code for all-control.
D.LCD lift control line series connection