Professional Documents
Culture Documents
Mf15 Wiring Eged525
Mf15 Wiring Eged525
NOTE: The EOL sensor may or may not be ENGINE WIRING DIAGRAM FORM WARNING
To prevent personal injury or death, read all
controlled, depending on the engine build. ECM controlled, depending on the engine build.
safety instructions in the "Safety Information"
Air Management System Lube System Fuel System Timing System MAXXFORCE ® 15 section of Engine Diagnostics Manual EGES-
Beginning with 2011 Model Year 515 before doing any diagnostic procedures.
Air Control Valve
Information on this form was current at the time of
Engine •Turbocharger 1 Wastegate Charge Air Intake Intake Turbocharger 2 Engine Oil Engine Oil Engine Oil Fuel Rail Fuel
Throttle Valve Control (TC1WC) Cooler Outlet Manifold Manifold Compressor Temperature Pressure Level Pressure Delivery Crankshaft 2 publication. Updates may have been made to
(ETV) •Turbocharger 2 Wastegate Temperature Pressure Temperature Inlet Sensor (EOT) (EOP) (EOL) (FRP) Pressure Position (CKP) introduce product improvements and technical
Control (TC2WC) (CACOT) (IMP) (IMT) (TC2CIS) (FDP) 1 advancements. See correct truck service manual
•Turbocharger 1 Turbine ECM 96-Pin
Outlet Pressure (TC1TOP) for chassis wiring.
Camshaft
E1 connector
2
Position (CMP) (300 series) For detailed circuit information, refer to the
1 CKP-L E1-16 following Truck documents:
CKP-H E1-40 Chassis Electrical Circuit Diagram Manual
Fuel Pressure CMP-H E1-17
4 2 Control Valve (FPCV) 2 CMP-L E1-41 Electrical System Troubleshooting Guide
4 2 4 2 4 2 2 1 Note: FPCV is part of FPCV 12V E1-25
1
5 1 1 4 Color code for schematic lines
3
the HP Fuel Pump 1 FPCV E1-73 Red B+ (Battery Voltage)
2
1 3 SIG GND E1-22 Red High side driver control
6 1 2 1 FDP E1-35
4
10 6 3 1 3 1 3 1 3 4 3 1 3 Purple Injectors (48 Volts)
VREF5 E1-81 Blue VREF (5 Volts)
VREF6 E1-88 Green Signal
FRP E1-34 Green PWM - Signal
SIG GND E1-21 Brown Data Communication
EOL E1-64 Black GND (Ground)
SHD GND E1-70 Black Low side driver control
SIG GND E1-45
SIG GND E1-46
SIG GND E1-19
EOP E1-10
VREF5 E1-82 58-Pin C2 58-pin C1
SIG GND E1-63 Chassis Chassis
EOT E1-36 (200) (100)
PayStar Additional
C2-22 COO
MAXXFORCE ® 15 C2-26 TSA
C2-27 ACD_SW
Inputs
Beginning with 2011 Model Year C2-33 BNO
C2-36 CP_SW
C2 connector
For detailed circuit information, refer to the C2-39 PB_SW
ECM 58-Pin
C2-40 EB_SW1
following Truck documents:
Chassis Electrical Circuit Diagram Manual
C2-53 EB_SW2 Fuel Cooling Down Stream Injection (DSI) Other CAN Exhaust Sensors
Electrical System Troubleshooting Guide System System AFT Fuel Pressure 2 AFT Fuel Shutoff Connections
1-H (AFTFP2) Sensor Valve (AFTFSV)
Color code for schematic lines
B+ (Battery Voltage)
1-A
Water In Fuel
DPF Sensors
Red Installed in the
(200 series)
Purple Injectors (48 Volts) C2-10 XCS 2-G Temp Temp Differential Temp
C2-13 AES 2-H
(Conn. # - Pin #)
Blue VREF (5 Volts) (DOCIT) (DOCOT) Pressure (DPFOT)
Green Signal C2-15 WTSL 2-F AFT Fuel (DPFDP)
Green PWM - Signal
C2-17 WEL 2-D ECL Sensor Doser
Brown Data Communication C2-23 RAS 1-E (AFTFD) MPH RPM
Black GND (Ground) C2-28 RSL 2-E Instrument Cluster
Black Low side driver control C2-30 VSS CAL 1-F
C2-35 RVAR 1-C AFT Fuel Inlet Sensor Body
C2-46 RPAS (AFTFIS) Controller
C2-48 RPRE 1-B 1 3
C2-52 SCS 1-D 2 1 2 1 2 1
Ambient Air Temp
(AAT)
2-B AFTFSV AFTFP2 AFTFD AFTFIS
2-A 1 2 1 3 1 2 1 4
5 1
1 2-C 1 2 1 2 34 7 8 9 5 6
2
SIG GND C2-43 1-J 2 1 10 6
C2-16
C2-37 WIF
C2-34 SIG GND
C2-49 ECL
C2-07 AFTFS-H
21-Way On/Off C2-20 AFTFS-L
Engine Harness C2-08 VREF4
C2-42 SIG GND
Interface C2-50 AFTFP2
Connector C2-41 SIG GND
C2-55 APP2
C2-54 APP1 120 Ω Transmission Connector
15 AAT C2-01 B+
14 EGRP C2-02 GND
10 AFTFD-H
11 AFTFD-L
12 VSS-H
13 VSS-L
3 SWBAT - -
4 SWBAT In-Cab Diagnostic
1 GND C1-02 GND
Connector 120 Ω
2 GND C1-04 GND Megafuse + +
5 EOT2 C1-06 GND E D
C1 connector
C1-57 MIL C
ECM 58-Pin
7 MAF 10A F
ECM PWR OUT 1
C1-37 VREF4 BATTERIES A
8 C1-13 RPS G B
9 MAF GND C1-24 SIG GND H J
21 CSRE C1-56 ERO
19 CSRD C1-17 SWBAT Stand Alone Real Time Clock
20 CSRC C1-01 B+
C1-03 B+ (SART)
C1-05 B+ A To SWBAT
C1-19 TIMER 42-Way Cab B GND To GND
C1-15 Interface C J1939-H
C1-44 Connector
D J1939-L
C1-54 Engine Fan Control
C1-21 (EFC) - 2 Speed 11
17
B 5A Ignition Switch
(100 series)
5 C1-18 EFC 38
C1-30 ECM PWR OUT 3 A 37 10A
8 25A
9 F
42
2 1 24 Accelerator Pedal
7 6 C1-23 SIG GND 29 Position (APP)
C1-36 VREF1 30
Cold Start 3
Cold Start C1-50 VREF5 22
Fuel Relay C1-11 SIG GND 23
Igniter (CSR) 28
(CSFI) A
C1-47 J1939-L
C1-34 J1939-H
C1-42 ECM PWR OUT 2
C1-52 PUMPCUR Oxygen Sensor (O2S)
C1-53 TRIMRES 5 1 Located in the
C1-46 O2SH-L Engine Exhaust
58-Pin C2 58-pin C1 C1-33 ECM PWR OUT 1
Chassis Chassis C1-39 NVOLT 6 2
(200) (100) C1-40 VIRGND