Engineering
Standards
S
Name PRO Engineering Standard Number
‘ANDARD.
MATERIALS SPECIFICATION 71053
(HARDENED,SURFACE)
Ieatifer
1. Scope
This procedure details a cyaniding or carbonitriding process for parts such as screws and nuts made
of steel Materials Specifications CES 30004, 30007, 30018 and 30020 hot rolled bars and cold
drawn bars.
2. Applicable Documents
Applicable documents listed below may be obtained from the respective organizations listed in
CES 10054, Standards Organizations Addresses.
CES 10054, Standards Organizations Addresses
CES 10056, Glossary
c. CES 16000, Inspection Standards
. CES 16019, Depth, Case
CES 30004, Steel, Carbon
CES 30007, Material Specification
CES 30018, Material Specification
|. CES 30020, Steel, Resulfurized
Definitions
There are no unique definitions in this standard. Terms used in this standard that have a general
definition for usage in Cummins Engineering Standards are defined in CES 10056, Glossary.
4. Procedure
4.1. Rough machine including threads.
4.2. Cyanide or earbonitride parts so as to produce a total ease depth of 0.002 to 0.010" (0.05-
0.25 mm). A temperature range of 1500 to 1525 °F (815 to 830 °C) is suggested.
4.3. Quench in oil or water.
4.4, Wash throughly in hot water if parts are oil quenched.
4.5. Temper parts at a minimum of 350 °F (175 °C) for a minimum of 2 hours at temperature.
4.6. Inspect as follows:
‘Gamrent Release Number] St Revision Level
152020-083 007 Page 1 of 2
‘CUMMINS CONFIDENTIAL
‘This document (andthe informacion shown theteon) is CONFIDENTIAL AND PROPRIETARY and shal not be disclosed to ote in hard copy
‘or electronis form reproduced by tay meas or wed Tor at purpote without widen conseat of Camas neEngineering
Standards
Name PROCESS.
‘ANDARD. Engineering Standard Number
rdcutiier MATERIALS SPECIFICATION 71053
(HARDENED,SURFACE)
4.6.1, Surface shall be file hard using a test file per Inspection Standards CES 16000
4.6.2, Case depth shall be 0.002 to 0.010" (0,05-0,25 mm) as determined following
procedures outlined in Inspection Standard CES 16019.
4.7. Dip in soluble oil bath for rust protection.
4.8, If hard wearing surfaces are finished ground, case depth to be 0.002" (0.05 mm)
minimum,
‘Gamrent Release Number] St Revision Level
152020-083 007 Page 2 of 2
‘CUMMINS CONFIDENTIAL
‘This document (andthe informacion shown theteon) is CONFIDENTIAL AND PROPRIETARY and shal not be disclosed to ote in hard copy
or electronic form, rerodced by ay mean, oF wed Tor ty purpose without writen consent of Canin ne