Blink code (on vehicles up to chassis No.8383302ID187233)
With the key tumed off, press the diagnosis button.
‘Twa sets of flashes of the EDC warning light with a short pause In between Indicate the code number
of the first error stored in memory
Press the button again to pass on to the next error
After reaching the last error, the firstone is repeated,
The list of errors contains a't the errors stored in memory and not only the active ones
‘The order of presentation of the errars respects the chronological order in which they appeared.
The table gives the error codes.
To delete the list of errors from the control unit memary, follow this procedure:
with the key turned off, press the diagnosis bution;
keeping the button pressed, turn the key on,
keep the button pressed for 5 seconds;
let go of the button:
tum the key off.Blink cade _| Indicator light Fault description Power reduction
_ VEHICLE
i ‘On Vehicle speed
12 Off {not used)
13 (| Cruise Control buttons
14 Blinking Throttle pedal :
‘Ciuteh switeh
ke ity
18 ‘Off Main EDC / diagnosis indieator light
i) OFF ‘Air-conditioner control contactor
ENGINE
2A Banking ‘Water temperature sensor a
22 ‘Off Air temperature sensor
23 On Fuel temperature sensor
24 Blinking Turbocharging pressure sensor
25 Off Almospheric pressure sensor
a7 On Fuel motor pump control contactor
28 ie Fuel filter heater control contactor
28 ‘On Fan control contactor
ENGINE 2
af Off ‘Cylinder 1 balancing
32 Off ‘Cylinder 2 balancing
33 Off ‘Cylinder 3 balancing
34 Off ‘Cylinder 4 balancing
35 ‘Off Battory voltage
36 ‘OfF Glow plug indicator fight
Br Off Glow plug control contactor
38 Of reheating maniteringBlink code Indicator light Fault description Power reduction
ELECTRO-INJECTORS
51 Binking Cylinder 1 injector solenoid valve
52 Blinking Cylinder 2 injector solenoid vaive
53 Binking (Cylinder 3 injector sotenaid vaive
54 Blinking Cylinder 4 injector solenoid valve
57 Blinking Bank 4 (cylinders 1-4)
58 Blinking Bank 2 (cylinders 2 - 3)
ENGINE SPEED
64 Blinking Crankshaft sensor
62 Blinking Timing sensor =
64 Off Engine overspeed
FUEL PRESSURE
84 Blinking Fuel pressure control ‘
oF cutting out engine
82 Blinking _Fuel pressure sensor =
83 Binking Pressure regulator solenoid valve
85 On EGR monitoring
86 On EGR solenoid valve
B7 On _ Debimeter
Ba Of ‘Air temperature sensor (debimeter)
CONTROL UNIT
a4 Banking ‘Contiol unit error (Gate array) =
or cutting out engine
92 On Control unit error (EEPROM)
93 Blinking EDC — mobilizer communication
a4 On Main contactor
95 Off After run test
96 Blinking Engine Stop Test (ECU)
oF Blinking Sensor power supply “or culting out engine
oe Blinking ‘Control unit error (Checksum) Starling not possible
99 Blinking Control unit error (Operating system) | Cutting out engine
(") Cases when there is a power reduction.