Professional Documents
Culture Documents
Bolt Data of Different Grade
Bolt Data of Different Grade
Note : -
1) b for length (l ≤ 125mm)
2) (125mm < l ≤ 200mm) b is 6mm more.
3) (l > 200mm) b is 9mm more.
Bolt Diameter, Pitch and Edge Distance as per IS 800 - 2007
Minimum Edge Distance
Diameter of Oversize or
Nominal Diameter of Bolt Diameter of Hole
Slotted Hole For Sheared or Rough For Rolled, Sawn or Planed
Edge Edge
mm mm mm mm mm
12 13.0 15.0 22.0 18.0
14 15.0 17.0 26.0 23.0
16 18.0 20.0 31.0 27.0
18 20.0 22.0 34.0 30.0
20 22.0 24.0 37.0 33.0
22 24.0 26.0 41.0 36.0
24 26.0 30.0 44.0 39.0
27 30.0 35.0 51.0 45.0
30 33.0 38.0 56.0 50.0
Above 36 Bolt Diameter + 3mm Bolt Diameter + 8mm 1.7 x Hole Diameter 1.5 x Hole Diameter
Note : -
1) The edge distances in above table, which are for standard holes, Increased if oversize or slotted holes are used.
2) Edge distance (Maximum) = (12 x t x ε)……….Where ε = (250 / fy)0.5
3) Pitch (Minimum) = (2.50 x Nominal diameter of bolt )
4) Pitch (Maximum) = (32 x t or 300mm )
a ) Parts in Tension = (16 x t or 200mm whichever is less)
b ) Parts in Compression = (12 x t or 200mm whichever is less)