Professional Documents
Culture Documents
LYA Vinyl Heat Press Manual
LYA Vinyl Heat Press Manual
I
E-mail: vipsupport@lyavinyl.com
,,,ttoi�
1.Preparation before Using:
1. Check the connection between power plug and electrical socket of electrical cabinet.Be
sure to operate with safe ground wire!!!
2.Heat press element must be securely plugged into the machine before you switch the
machine on.Plug your electrical cord into the machine. Plug electrical socket into wall
plug.Turn the power on by flipping the On/Off Switch on.( Nominal voltage:220\/,
Rotate the heat transfer board + Max.input power:l 250W )
to the side.
2.Set temperature required
Set the temperature and time according to the table below and get the specific corresponding
temperature and timing setting.(Temperature is measured in Degrees Fahrenheit.)
I
Mugs 230 (110 °C) 330 (165°C) 40
\
g
'II /J I
clothes,use high temperature resistant tape to
fix the pattern.And put the white Teflon cloth. ) Metal board 230 (110°C) 300 (150°C) 40
Sublimation paper:30-S0s
T-shirt 230 (110 °C) 355 (180°C)
T-shirt Paper:l 0-20s
Turn this adjustment switch C.Proper Heating Time Setting (Range:0-999 sec.)
to adjust the pressure.
Press the "MODE" button for THE THIRD TIME;see the" time light" turning red.
Then press the "plus or minus key" to set the proper heating time.
05 06
Replace Baking Cap Mat Replace Baking Coaster
•
�
,.
�� Pluck the plug.
\\
\\
II
II
II
II
II
Shaped hat
11 12
Replace Baking Coaster Replace Baking Coaster
iiii
♦
�
"I
Use the screwdriver 4 to tighten the 2 screws
just removed and put the cap on.
ii -,-
�
,
\cf'"'-�
Tighten the bottom screws. Shaped cup
13 14