Installation Instructions for the NU-4750, 4850 models
Open door for a few minutes to ventilate the chamber and allow to humidity to escape.
Close the door if desired, turn off the unit and disconnect the power.
2 Remove the hosing from the CO, sensor, everything between the large capsule iter and the red-tagged return hose,
This red-tagged hose wil lead tothe cork (NU-4750), the RH injection solenoid (NU-4850) but in al cases leaveit behind,
See pictures and/or diagrams
10 cnn came ci
swe lia net
ve (Ted urrue vavE
7 Wane CPSIE FILTER
i meget vaaye $ x2 sec -cwinech SARE PRP
sw meet vue pe FUG Ta
_APS fe Leven swto#
ae pacer vaave
ee eeu rom
'NU-4750 and NU-4850 hosing isthe same for control systems in those models
‘After removal of tubing and CO, sensor
Remove the CO: sensor wiring, a gray data cable with blue connectors on both ends, and a pair of red and white wires for
‘the DC power from the TB3 terminal block. These wires will not be reused so it you wish to cut them to make it easier to
pull them from the wire harness you may do so. The wires will do no harm if left in place but may be confusing for future
service.
4, Remove the CO: sensor and the short plastic
‘780367 | Rev 4 June/2023 Page2of8
‘NuAlre, Inc. | 2100 Fernbrook Lane | Plymouth, MN 55447 | U.S.A | ph: 763.553.1270 | fx: 763.553.0458 | tf: 800.328.3352 | wow.nvalre.com
Escaneado con CamScanner