5.2.4
Ds Jenbacher Ignition System
Documentation
SOT
.2 Ignition systom with 3-pickup design;
* Firing sequence:
The firing sequance is adjusted by adapting the ignition box.
+ Ignition pulse:
One pickup (camshaft timing gear) supplies the signal for ignition-TDC on cylinder no. 1
One pickup (fywheel) supplies the signal for TOC on cylinder no. 1
One pickup (staner pinion on the fywhees) is used to determine the engine speed,
These signals are processed by the ignition box, which then triggers the ignition in the: corresponding
cylinder.
The ignition box supplies the ignition energy to the ignition coils, which then generate the high tension
voltage for the spark plugs.
* Firing point:
‘The firing point is optimised by the engine management system depending an operating conditions and
type of fuel gas used. If the engine is designed for muti-gas operalion then there isa spectic firing point
pre-set for each type of fuel gas,
Pickup
Ignition coil
‘Camshaft timing gear
Spark plug
Fiywhee!
‘Starter pinton
(crankshaft)
ia.ne or SAM 4
(firing point)
Pickup (engine
speed)
Pickup (reset)1. Ignition system:
1.1 General
4.2 Designand function:
1.2.1 Ignition system with 1-pickup desig
1.2.2 Ignition system with 3-pickup design:
4. Ignition system:
4A
12
124
General:
GE Jenbacher gas engines are equipped with a micraprocessor-controlled capacitor discharge ignition
system
The ignition system is run with a supply voltage of 24 V DC.
Design and function:
Depending on the engine type. either a 1-pickup ar 3-pickup design is used.
Tha firing point is generally measured at cylindar no. 1 ['CA before TOC]
A scale is located for this purpose on the flywheel.
Ignition system with 1-pickup design:
+ Firing sequen
The firing sequence is adjusted by adapting the ignition bax,
* Ignition pulse:
A magnetic disc on the camshaft liming gearganerates pulses at the pickup, which then sends the signal
(firing point) cn to the ignition box
Thase signals are processed by the ignition box, which then triggers. the ignilian in the carrespanding
cylinder
The ignition Bax supplies the ignition eneegy ta the ignition eails, which then generate the high tension
voltage for the spark plugs.
+ Firing point:
Tha firing point is optimised by tha engine managemant system depending on operating conditions and
type of fuel gas used. Ifthe engine is designed for multi-gas operation then there is a specific firing point
pre-set for each type of fuel gas
sere Ignition coil
Pickup
Spark plug
dia.ne or SAM 4
(firs int)
Magnatic disc (on omar
camshall timing gear)
evans nteey Fem Geerton 3 reso Mecten AB 1
Megs hoe SEE EZOCE KE Vor: 291 ages 9 ASE LOE UREA La NMEA UBER SEND LAEET |
mat: Sathorn Chesed Sekumstatlon ai gm.