ARCAM DELTA
DELIA 9O INTEGRATED STLkEO AMPLIFIERBELT 90 SERVICE MANUAL
Precast Description Ise 26.2000
Dine Tap
EoH1 tteC.) cartridame. For moving Corl car tridece an nee
of the amplifier. The moving maanet and RIAA saual ization eee, a
based around @ NESTA low horse On-amo. Capacitors Chand Ce
dependent deedback for RIAA correction is pravided hy melunne
FS and CS at lew frequencies and Ro and CO at Regn tredeene ee
Capacitor CS provides hiah frequency stabilisation of the ie.
Input and Record Setection
Line Vevel stanal from the disc stage output or any other input can
be selected for amlitication by the listen tuiten, < h cenee
record switch andependently selects signals fur reiting co eee
outputs. Note that the record switch te wired tomrocent foe 1
input fron being fed tape 1 output to prevent. feedback wrobicee
£:. input signals are attenuated by KO sna RY to match ene ie
Signal passes via the listen switch and volume contrel to # line
anelitier stage which provides 16de of asin. Teansraters OF eed 2
Brovide gain which is Set by R16 and Ri%., Transistors Ge an hace
2 current source load for the cellecter oF OS
D.C. bios for this stage 15 provided by R220. RID) vie RIS.
Tone contral and direct amitch
# non-soverting tone contrel based around IC2 allows a jim ted
Tange boost and cut (approx. *-748) ‘oF bess and trebles Bat ang
treble control potentioncters vary the feedbach srenna tect ey
(romueys |The resistors on either ends oF wack potenti omceee
wiven the direct switch is out or directly trom the line sant iriee
shen the amitch is in. “To prevent. ewitching cliche fused be
gittering DC levels on C12 and C17, equal voltages. are mernt otned anThe Foner Amplitier tas @ single transistor input stage rather than
the more common luna tailed air. Signal on 0h base modul aves the
collector current and the resultant voltage variation drive chase a
amplitier 07 via emitter follower 06. Trancistor 69 1a lauded bys
current source 08. U7. fp A.C. signal equal in amplieude ta the
negative half cycles driver transistor G13 and output trancitor O15
provide the current handling capability to drive the lowsescater
Yoad. " Similariv on positive halt cycles U1? ond G14 provide the
Same function. “The amplifier operates im clace AB mole with 5
standing current of approximately Soma in the output meaue
Eransistors O13. O15. The output stage i= biessed in thie
condition by the voltage acrose Ra? which i= tet by current source
0G. G9. Preset potentiometer RVI allons adjustment uf the current
sotrce and consequently the output stage standin es
Resistors RSG and RSP Limit the possibility of the thermal runamay
Eogether with Of which is mounted adjacent tw the hestsink Co alice
thermal feedback: to the current source. Two identical protect ies
2 On O10 and B11 sense output curren: arrose RSG and Roo
overvaltaqe threatens ta damage the output tranuister a,
Feedback trom the amplifier output iz returned to the emitter et the
first ‘stage transistor Of via RSG, Resistors Ra. Se define the
Stability against nigh ¢requency osesilation in the amplifier i
maintained by C23, C21 and RS? and also C23.
There ts 4 D.C. servo 1-C.3 which provides D.C. bias to the input
Beane and maintains a low D.C. offant on the loudspeaker cutpor,
The circuit functions by having an extremely large gain at Beey but
the main servo time constant with residual filtering by Id. Te.3,
3s powered by the preamalifier ISV supplies.
Power for the input and class A stage is filtered by use of
215, C205 and D214, C204 to provide isclation from the cutoutThe amplifier output is connected to the output termnals via a
relay abich performs 2 functions. On sei tehing or the pacer there
15,2,5 second time delay before the relay clones, on cereceney the
relay opens immediately. “Bangs and pon are this precenen tet
reaching the speakers." the relay circuit ala monitor the Se
offset on Both loudsoeaker outputs and if this ie urecter eae
Jopranimately +-0.7 Volt the relava mill open, arotecr ney
Toudspeavers from Bc. current,
Commonents R215, C220 provide the switch on delay. When 6220
Eharaes to above 15.7 Volts U200 switches on and in tee oSae
Note that for C220 to charae up 9208 and 0207 must be off
D.C. offset on either power amilitier mill cause ene of tewe’
Signals from operating the circuit, .
With the @.G+ power on. 6217 will be neaatively charged by Acc. trom
the transformer Secondary rectified by D207. On emttennte tole
ALG. disappears and C217 wocomes positively charged Mae
Transistor 0207 will switch on and! consequently the citccrt mill open
Preamplifier power supplies
Fositive and negative ¢4fteen volt supplies tor all preamplifier
Zigges and the D.C. servos are provided by to regulator ciscatts of
Eistlar configuration. "In the positive regulate: the man eases
supply of 44V is dropped to apprawimately So volte be eRDote
Transistor O201 is switched on by current through Roo? sey R203
and the emitter of 0201 rises in voltage until at snprontaatary. 15.7
volts D201 conducts and turns on 0202. Transi ton Boge tase ade
Evcrent from the base of O201 so that a staate operatic, sen Toe
Teached. Capacstor C208 provides high treauence state oor foe ee:
etreuit. The negative regulator operates in an sdentical weeHost of the conanents in the amplifier can if necessary be replaced
by similar types or manufacturer providing valtene, current and
tolerance ratings are equal or better. The main excepsions ¢9 this
are the driver and output transistors O12.13,14,15. These
Transistors ere gain matched 20 that if Qi? needs relac ng then G13
should alsa be changed. Similarly G18 and O18 should bo replaced
By replacing in matched pairs the distortion measurements wilt
remain low, also anv later failure by gartsal damage in the other
Gmvice mill be avaided.
SAFETY WARRING
This fuse promotes the main protection to the whole amplifier and
mist NEVER be replaced by a fuse of igher rating or mifterent type.
The (use value i= listed below
Supply Voltace Fuse rating
110 = 120¥ S.15AcT)
220 ~ 240v s.zsacryDise Input
10
Stecron
ler SWS
NB. FOR RIGHT HAND CHANNEL, ADO 1070 AL COMPONENT REFERENCE NUMBERS
* COMPONENTS ARE 1% TOLERANCE METAL UL
‘A&R CAMBRIDGE LTD,
[ARAM DELTA 80
‘mRCUTT DIKGAAM 1/6
ISSUES 9.267
SERIAL NOS 001 4.00Input and Record Switching
nous oureurs
Wea Twee1 co TUNER Tae THRE
‘ABR CAMBRIDGE LTD.
ARCAM DELTA 90
GIRCUT DIAGRAM 2/6
ISSUES 9.1287
‘SERIAL NOS 001 — 400Line Amplifier
Tone Controls
A&R CAMBRIDGE LTD.
ARCAM DELTA 90Power Amplifier
our
fe
@ sowvstienr
uescenr
oa
“ze
BR wecos
Toorrser
PROTECTION
waste
ReUy
&%e 9,13 maybe A958
Q7,Q12maybeC2168
oes
e] DC Servo
‘ire
8
‘ASR CAMBRIDGE LTD.
ARCAM DELTA 90On/Off Mute and DC Offset Speaker Protection
‘A&R CAMBRIDGE LTD,
‘ARCAM DELTA 90
GIRCUTT DIAGRAM 516
ISSUES 9.1267
SERIAL NOS 001 —4-€00Main Power Supply
+1V Discrete Regulators
p—eaisv
[tay
x0
a aaaneo0
Se
fuse
in raat
——
any
1
ves
w a
WAI FOR 204
NB FOR zav USE 0-110 0-110
.WINONGS WRED AS ABOVE
wring Fon zo
NB.FOR TOV USE 110.0-110
WRONGS WRED AS ABOVE
SAFETY Wasvan:
WAYS REPLACE WITH THE SAME FUSE RATING AND TYPE
‘SCONNECT SUPPLY BEFORE CHANGING FUSE
Q201 maybe C2168
Q203 maybe A958
$$ isy
‘A&R CAMBRIDGE LTD,
ARCAM DELTA 90
‘CRRCUTT DIAGRAM 6 6
SSUES 9.1287
SERIAL NOS 001 — 4800