Professional Documents
Culture Documents
WIRING INSTRUCTIONS
MODEL: LED-2GS118S
PAGE: 1/2
Step 3. Remove or bypass the ballast in the existing light fitting. The LED 2G11
lamps have a built in LED driver that operated directly from the mains voltage
(85-265VAC). DO NOT SWITCH ON THE POWER SUPPLY UNTIL THE ELECTRONIC/
MAGNETIC BALLST IS ELECTRICALLY ISOLATED.
Step 4.Connect the Live (L) wired to the outer pin and Neutral (N) to the opposite
outer pin. The two pins in the middle should NOT be connected to any electrical
wire.
Step 5.Switch on the power supply, the LED lamp will light on.
PAGE: 2/2