Professional Documents
Culture Documents
Cost Estimates and Revenue Model For A Public Charging Station (PCS)
Cost Estimates and Revenue Model For A Public Charging Station (PCS)
By Nimesh Shah
Government of India recently released a notification titled ‘Charging Infrastructure for Electric Vehicles –
Guidelines and Standards -reg.’. Availability of adequate charging infrastructure is acknowledged as a key
requirement for accelerated electric vehicle adoption in the country. In accordance, setting up of Public Charging
Stations (PCS) has been de-licensed and any individual/entity is free to set up public charging stations, provided
the stations meet the technical as well as performance standards laid down.
Any individual/entity setting up a PCS will need to have the following minimum infrastructure as described in the
notification:
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 1/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Each charging station is required to have a minimum of three fast chargers: a CCS, a CHAdeMo and a Type-2 AC.
While the former two will be required to operate on 50kW/ 200-1000V, the Type-2 would be 22kW/ 380-480V.
Additionally, the charging station will also have two slow charge points - a Bharat DC-001 (15 kW/ 72-200V) and
a Bharat AC-001 (10 kW/ 230V).
A typical 50 kWh DCFC costs over Rs 1.5 million. Since present models of EVs sold in India cannot be charged
above 1C rate and batteries are 11kWh to 25kWh capacity, investment in DCFC of over 25 kWh would yield
unappealing returns, unless manufacturers roll out electric cars with batteries capable of fast charging with DC
output in the range of 400-500V or higher. This will eventually increase the capacity utilization at PCS and
enhance revenues for charging infrastructure providers, making investment in a public charging stations an
attractive option.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 2/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
All standards will co-exist in India: CCS-2, CHAdeMO and the Bharat chargers. Tesla cars, according to recent
reports will use CCS standard when launched in India.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 3/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Couple of Mahindra e2o Plus electric cars charging at Mumbai DC fast charger - DC-001
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 4/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
*The cost of swap station is considered to be borne by the swap station technology proprietor. PCS provides
space for a swap station in return of margin on sale of electricity.
**Land lease rental is assumed to be low as per Delhi EV policy guidelines on providing land at bare minimum
lease rentals to charging infrastructure providers.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 5/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
6. EVSE Management Software fee considered @10% of net margin on electricity tariff
As may be observed from Table 1 and 2, for an initial investment of Rs 2.95 million to setup a PCS, the net
cumulative return in 5 years is Rs 1.77 million under Scenario-A and Rs 1.53 million under Scenario-B. In both
the cases there is little or no incentive for third parties to setup and operate PCS. Levying a margin more than 3
rupees will make the EV tariff at par with commercial electricity tariff.
In the present scenario, PCS business is not viable for individuals/entities to invest.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 6/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
The government may fail to encourage third parties to set up public charging stations to accelerate electric
mobility adoption. However, in case of Delhi, as per Delhi Electric Vehicle Policy, GNCTD will provide a capital
subsidy covering cost of chargers and installation expenses. Considering the cost estimates in Table-1, if 100%
cost of chargers is subsidized, the IRR on setting up a public charging station in Delhi makes it an attractive
investment choice.
Table 3 - NPV & IRR of non subsidized PCS vs 100% charger cost subsidized:
Since business volumes in the initial years will be very low, attracting private investments for PCS network
creation can prove to be a challenge in the country; unless capex cost is partly or fully subsidized.
Also, it will be difficult to build EV charging network in India as a standalone business. Innovative business
models to incentivize the public charging infrastructure (PCI) providers and government will be required.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 7/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
237 Comments
Dear Sir,
Dear Sir,
You have given very good information Thanks.
We wish to establish PCS in Pune and Aurangabad, we want addresses of Indian Charging system
manufacturers who can join hand.
Reply
Sir, We EV CharZo provides consultancy & Solutions to set up Ev Charging Stations across
India . Get more information by sending WhatsApp message on +91-9888-9555-88
Reply
Thanks, Ev CahrZo, for your Brief Guidance , you helped Lot to Start our project with right
way the strategies citing few here .
LOCATION:- we selected highway , as you suggests for more EVs to come for Fast charger,
while in cities , the people will generally fill battery at home or office.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 8/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
the Right Mix of High Kilowatt DC Fast Chargers, as the Higher Power DC Chargers no
increse their Cost in same Proportions, so in One Value we can charge 3 EVs at a same
time , while in this price lower (KWH) chargers can recharge only Two Evs, & also slow....so
we installed of 180 KWh.
Power Transformer: as per your suggestions ,we installed 1200 KVA transformer , rather
two of 500 of each.
sorry for disclosing yours
(Ev CharZo) suggestions but really they are well advanced thinking & reserch based for
Good ROI
We ""Ev CharZo"" Gives consultancy to set up EV Charging Stations across the India. First
we Provide Process & Set up Guidance Booklet Cum Report, on the base of this Report even
a New Person to Business can start to set up the Charging station. although our support
offers support on following steps:- . . . . PCS Architectural & Design , No. & type of
EVSEs/DCFC, Installation criteria Charging /Parking Lay- Out plan................
Rules & regulations of different Govt. Agencies/Dept. For seeking approvals for PCS
establishment through,33/11Kv Power-Line...............
Decision process & strategies to procure & Installation of DC Fast Chargers.Specific-
Criteria on selection of Power(kWh) of DC Fast Charger , sync with Electric Power
Management for Control & supply through Power equipment...............
Reports on Financial feasibility ,CapEx. , OpEx.,BEP ,CUF% , on different level of
investment. Business strategies, development & Staff working /training
manuals.....................(ask More on whats App +91-9888-9555-88................
Intrested for Electric charging stations and neemuch indore udaipur bhilwara chittor
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 9/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
(2) We had framed various PCS modelling , EVEN a small PCS with Single DCFC can starts
to give profitability at crossing 25% Capacity Utilisation. Know more on www.evcharzo.com
(3) WE have “Business Modeling” for Ev Car Fleet operators (for specific single City) , just
like OLA & Uber. otherwise till now such operators were not at profitable because renting is
equal to running cost of ICE cars. But recently lunched Indian EVs makes it happening/
possible and very fastly growing with subsidies on Buying EVs. Also Module for E-Bus
Operators(Intercity) & for E-Auto fleet operators (Fix Route/Last Mile connectivity)to know
more Whats App +91-9888 9555 88
hello
sir my self manish kumar. i want to open. EV charging stn.kindly give me some information,
and how much the cost, and how much area required? and total expenses, i want to open
in Varanasi, utter pradesh
Thanks
I want to startup with Ev vehicle charging system and need detailed information about it.
Help me out for stating this.
I want ev station
How to gather more information? And what all the companies will help to setup the Ev
stations in Uttarakhand.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 10/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
We “EV CharZo” (+91-9888955588, whats app) PCS set up consultant not let a PCS
entangled into obsolete due to fast growing technology of EVSE & related supply equipment
. Setting up of PCS needs Smart planning(more than Governed by Norms laid by MoP C.
Govt. dt. 01.10.2019 ). Get Inside through our Consultancy , each & every excellent
technical aspect ,even start from Basic U/G Conduits of HDPE-DWC requirements to
synergy within PCS as a whole, ranging from all Power- equipment Infra. Viz. Liquid- cooled
,IP67 std. DCFC of 90 to 180 KwH, HT/LT Power distribution through XLPE-3C Cables to
match with High C-rate EVs , NSP/OCCP based functioning are to be kept at par of
international Std. For Smart & excellent PCS, through state of Art & seamlessly functioned
& monitored ,must be able to serve efficiently each next generation EVs to be Launch in
India .To keep lowest TCO(Total cost of Ownership ) & focuss on Queuing algorithm for
incoming EVs ,Maximize Power to serving Ratio & Pricing policy.
check Out our Report Why we are not recommending 50 kwh DC fast chargers , rather
recommending installed 120KWH Fast chargers , so that forthcoming Car Like E-KUV -100 ,E-
Wagon R, electric Kwid....all these car are coming with Accepting Fast charging...so only 120
KWh can fill in Half an hour...while Govt recommended will take 1 Hour.....check out more such
info & Strategies in our Consulting guidance..... ask on whats app +91-9888-9555-88
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 11/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
We are interested to purchase the Electric battery charging machine kindly send the
quotation norms and condition please very urgent
JD&CO please give your email ID or website and I'll send you the quote for the chargers we
have.
Thanks,
Sushant
Reply
If You Really Venturing Fast Charging Station:: Attention: PLs Do Install 350 Kwh Fast Charger
or Above, in coming Years , within two year, the following EV-Ambiance from Technology will
steady state, VIZ.( 1) Li-iON Battery Recharging Rate 6-C, (2) Range of EV will be 500 KM, (3)
Life of Battery 15 years,
(4) Price of Battery will be 100 $ /kwh ,Pickup of Ev, Auto pilot will be improved with passage
of time ,while price of Ev will down Equal to Diesel Automatic Car. So what this means For
Ultra Fast Cahrger......Our Analysis shows only 350 Kwh & above Charger will be in demand &
Profitable, DC Charger below this will be Loss making Machines as No customer will opt such
Slower DCFC.........To Know more ask..EV CharZo..whats App +91-9888-9555-88
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 12/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Address:
JD&co
160 Coimbatore road,
Pollachi
Coimbatore District,
Tamil nadu
642 002
Phone 04259 223828
Cell 9443172635
We "Ev CharZo" recommending two Nos. DC Fast Chargers ,one of 180 kWh with ChaDeMo &
CCS & another one of 350 Kwh in contrast of Govt.'s recommendation two of 50 kwh DcFCs,
since forthcoming Even smalll EV Cars (40kwh /2-C Rate) will accept of Fast Cahrging in 30
Minutes , 50Kwh DCFC can not Juice it up in 30 minues (power limitation of 50
kwh).So………………….to know more Business Strategies in details( buy our PCS Set up Guide)
………………….read following points:-
(1) Now-a-Days World is seeing the Revolution-phase of Ultra Fast DC Chargers , the time
taken to fill up an Ev Car Battery had become Equal to Fuel dispensing Machine takes to full a
tank of ICE car. This is steady state phase. Now EVSEs of 350 Kwh , 450 Kwh DC Fast Charger
are quite popular ,can juice-up a Ev Battery in 5 to 10
Minutes.............................................................
(2) Another face of Coin of Development are in EVs , where the range of 450 Km & Battery's
acceptance of Fast Charging becomes Equal to optimum /matching time (5 to 10 min ) & 6-C
Rate Li-ion Battery are coming in High-end EVs Like TESLA -3, Audi E-Tron, Merc-EQC, jaguar
i-pace. While Mid range are Chevy Bolt, Hyundai Kona, Nissan Leaf & many
more.......................................................................
(3) The Indian Road will about to see from this year (Mostly) Small EVs Like E-WagonR, E-
Kuv100, E-Kwid, E-Xuv-300, BYD Small Ev.....all are having (average) 35- 40 Kwh Battery
pack, range 150-200 Km & 2-C rate of Batteries i.e. Can be charged upto 80% in 30
Minutes...............................................................
The More the Powerful DC Charger , Higher the Charging rates to EV Owners, simply for time
saving & Upper end investment (cost) of DCFC . Charging @2.5/km by 180Kwh & Rs. 3/km by
Charger of 350 Kwh will be prevail at PCS, where Energy Cost Fall around 8 Rs per Unit by
350Kwh ......for more ask Query , whats App +91-9888-9555-88
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 13/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
NAV Education
Required details for installing public charging system 'EV'. Please send all details including
cost involved & break up of expenses in P&L excel.
REgards
I want some information for opening pcs at Nagpur please provide contact address contact
cell no. For gaining information
You may read and waatch Video about , how charging station works, this will help you
understand about station.
Click on link below
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-
solution/
We can help you with the information. Please contact: anukrishna.cpa@gmail.com. This is a
consulting firm on renewable energy. Feel free to contact for research related to Business
Reply
Hello sir,
I am also interested to start this project in auraAurang but I don't have sufficient money so
can we start this project in partnership in Aurangabad..??
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 14/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Thank you.!!!
Reply
Dear Suryakant,
We are electro-medical devices manufacturing firm based in Pune and have recently ventured
in EV charging systems manufacturing. Let's get in touch and discuss further.
Reply
I am interested to join hands with you to start in chennai, I will be full supportive and make
more development in our business
Reply
Hello sir,
We can help you to set up ev charging station.
Please contact me
9665626970
Reply
Reply
We are dealers of one of the reputed manufacturers of EV chargers. You can get in contact
with me on my Email ID to get more details.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 15/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Hello suryakant,
Reply
Kindly give your mail ID. we can offer European Certified EV Charging Station of any type as
per your requirements bvbaskaran@gmail.com
Reply
We “EV CharZo” (+91-9888955588, whats app) not let a PCS entangled into obsolete due to
fast growing technology of EVSE & related supply equipment . Setting up of PCS needs Smart
planning(more than Governed by Norms laid by MoP C. Govt. dt. 01.10.2019 ). Get Inside
through our Consultancy , each & every excellent technical aspect ,even start from Basic U/G
Conduits of HDPE-DWC requirements to synergy within PCS as a whole, ranging from all
Power- equipment Infra. Viz. Liquid- cooled ,IP67 std. DCFC of 90 to 180 KwH, HT/LT Power
distribution through XLPE-3C Cables to match with High C-rate EVs , NSP/OCCP based
functioning are to be kept at par of international Std. For Smart & excellent PCS, through state
of Art & seamlessly functioned & monitored ,must be able to serve efficiently each next
generation EVs to be Launch in India .To keep lowest TCO(Total cost of Ownership ) & focuss
on Queuing algorithm for incoming EVs ,Maximize Power to serving Ratio & Pricing policy.
Reply
Reply
Crging point required address.Kamgaon bas stand rood relye maldakka get rait said marata
tea corner 9834077250 tahacil Kamgaon distik buldana Maharashtra mo n 9834077250
Reply
You may read and waatch Video about , how charging station works, this will help you
understand about station.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 16/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-solution/
Reply
Reply
Reply
9810669096
Reply
Hi,
We can help you to setup ev charging station.
Connect me on 9770544318
Reply
Reply
I want to install power charging station at Ramchandrapur,Sonar pur, P.O.&P.S. Sonar our, Kol.
150.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 17/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
You may read and waatch Video about , how charging station works, this will help you
understand about station.
Click on link below
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-solution/
Reply
Reply
Laxmi Narayana , "Ev CharZo" Provides consultancy and set up solutions on setting up EV
Charging Stations. for more info. pls. send Message > Query-PCS < at whats App : +91-9888-
9555-88
Reply
Reply
Please call us we will definitely help you to provide charging stations at public places for 2+4
wheelers
Mobile no 7028641925
Mail id - vijaymurge@myevenergy.com
Reply
Want ev station
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 18/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Noted Dhruv.
Reply
Sir how much investment is needed in this work and how we open it
Reply
Investments starts from 50 Lacs INR. But we recommends for Upto INR 1.0 Crore, The Latest
DC Charger of 350 KWH must be installed for charge EV cars in 8 minutes. no one wants
waiting at charging stations if one need to get EV charged out side his/her Home. Procedure to
open is through Consultant like us EV Charzo 9888-9555-88 whats app only.
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
What are the terms and conditions to install electric charging station. I would like to take
dealership for electric motors hence kindly guide me how to get the electric charging station.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 19/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
It's good to get this but does any Indian firm is making all this if yes I will love to start charging
station
Reply
Reply
I would like to set up Electric Charging stations nearby Mumbai. Please give me the details
Presently Tata Power , Reliance Energy, NTPC Ev Motors are providing Charging Stations. Essel
Group ( controlling Zee Media) had announced to set up more than 5000 Charging stations in
coming year acroos india. Ev Motors are bringing 4500 PCS in next 4 years. there is early race
to get (lock) Location registered with Government ( see Norms) for set up Charging stations
across india, once E-KUV 100 & E-wagon R Car are settled we will see in india the scene Like
"EVGo" & "Charge Point" had settled in USA besides Super Chargers of TESLA . we have daily
query how to set up PCS and providing Financial Feasibility Report as well as all legal an
approval norms , Electrical equipments list & Architectual Lay-out plan.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 20/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
9911496017
how we can set up the EV in NCR. What is cost and other formalities required
I mean interested for installation charging stations in Noida On my high way land plz
contest me my no is 8630076867
Reply
get Our Consultancy to set up Public Charging Stations, get more Info from "EV CahrZo" ,
send request message on whats App no. +91-9888-9555-88
Reply
Would you please confirm the requirements of land and buildings for installation of such
electric charging station.
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
Wish to have the details for setting up EV station, please help in getting the same.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 21/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
We need details for setting up EV station and what are the terms and conditions to set up EV
station.Please let me know. Thanks
Reply
Reply
Great efforts.
Regards,
Pratik Singh
SPM-2013-15
Reply
Get Consultancy on PCS ...send whats app Message : Query on PCS on +91-9888-9555-88
Reply
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 22/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Our team myevenergy started project on providing charging stations at public places.
Reply
I want to set up EV charging stations in DHARWAD KARNATAK STATE ,do i get any information
with Blue print. Thanks
Reply
Please share your contact details, Im from Bengalore. you can reach me on 9916166089
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 23/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
I am from Surat I want to start charging station in Surat kindly suggest me all processes n
requirement my number 9879735184
Reply
Reply
Connect me on 9770544318
We provide ev chargers.
Reply
Hi Everyone,
Referring to all the discussion and the trend we are approaching towards the greener
environment, we started very late. Its always the situation that while other part of the globe
foresee the future and start adopting things for betterment we wait and watch. The process of
implementation of policies are cumbersome & always time consuming here.
Anyway things are moving now, that's the good part and as an Indian citizen I am very positive
now on this. We should contribute our bit to make things faster & smoother.
We should spread the benefits of adopting E-mobility and educate people on this, a mass can
better contribute things in positive direction if they are educated on that very matter.
Anyway what I have said is very well know to every one, now I would like to request the
members here to share the basic things on E-mobility and EVCS.
How this is going to bring the revolution to commercial fleet system and automobile industry, how
it will be taxing to the electrical network, what is the technology, how the EVCS works etc..
Thanks & Regards
Dipak Modak.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 24/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Why ev owner charge the car at pcs becose they can charge at home at low cost.
Secondly what would be the charging fee.
Reply
Highway Commuting/travelling Needs Range (Km) enhancement same as ICE engine Car need
to fill petrol tank, So Recharging, without delay of time demands PCS throughout the attached
of Long route highway/expressway .
2ndly. Local city commuting , sudden /emergency work etc will create demand fast Charging.
3rd. The Local city Taxi/cab need to recharge at Fast Charging as their running /revenue have
not let resting mode for lunch Ng hours for normal charging, will need very fast charging
through PCS. Tie up with E transporters , public vehicle will need fast charging on the way in
cities as well as in highway.
To know more reason & revenue generation/RoI etc, what's app+91-9888-9555-88
Reply
Reply
I am really looking forward to setup PCS in Delhi and Haryana. Need guidance, please advise me.
Reply
YOU Can have our PCS set up process & Installation Guide, we provide PCS setting up
solutions ,ask more ,whats app+91-9888-9555-88
Reply
Connect me on 9770544318
We provide ac/dc chargers.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 25/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
Reply
YES, you can have , DC Fast charger mount on floor wise, subject to safety of High voltage
carrying Cables are proper harnessed and EVSE have ambience free of physical vibrations
,electromagnetic effect may not hamper others.....know more ask us WhatsApp +91-9888-
9555-8
Reply
I have about 7000 sq.ft. carpet area of premises on one of the main road in Mumbai. Iam
interested in establishing charging station. Please guide me
Reply
Kindly provide your contact details.So, we can discuss on the charging station solution.
Reply
I want install fast electric charging point station in Tamil nadu at kaniyakumari
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 26/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Siva
8925407653
Reply
Reply
Reply
Reply
Reply
Hi,
I am an individual and am interested in being part of the Electric revolution and hence interested
in setting up a PCS in Puducherry.
Appreciate, if we could get in touch to understand the business viability for having a PCI.
Reply
I am working on the business model of EV charging station for my academic project in M.Tech. I
need one guidance from some who having knowledge of financial plus technical aspects.
My Queries are following:
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 27/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
1-What will be the transformer rating ,if my load is around 300Kw to 350kw in charging station.
2-what kind of LT Panel Should we select for the same load.
3-What are the other protection we need for the charging station.
Reply
Pls wend the details for establishment EV Charging station in tamilnadu and guidance.
9845114401
Reply
Thanks
Reply
Reply
Reply
Interested in PCS
Rajkot
Gujarat
9925049989
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 28/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
provide your contact details.So, we can discuss on the charging station solution.
Reply
Respect Sir
Regards
7032679184
9703042121 WhatsApp
Reply
I am interested to install an electrc charging station in Punjab.Which will be the most appropriate
place to install the same.Name and address of the true consultant in this regards.An early reply
will be highly appreciated.Thanks and regards.
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 29/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Reply
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
I am interested to install EV charging station in jaipur, Rajasthan at Ur land which is on NH, Pls
send me best possible proposal with ROI calculation, warranty to my no +91-7062525716,
WhatsApp available.
Thanks
Jitendra
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 30/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
Reply
Reply
Reply
Reply
Dear sir,
I am interested to setup electronic charging station at my land which is on Valsad ..so, help to
further process either send the concern person detalis whom I talk and get the idea ...
My what's up no
+919833353338
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 31/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Any one interested in charging setup south india, we will provide technical details for installation
and maintenance of EV charging station.
Reach me on 9916166089
Reply
Hello, I would like to setup couple of charging points in Hyderabad. If possible will fix an
appointment and discuss further. Thanks
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler
vehicle
Reply
Hello sir,
Mail- vijaymurge@myevenergy.com
Reply
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 32/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Hello sir,
Our team myevenergy started project on providing charging stations at public places
email- vijaymurge@myevenergy.com
Reply
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
Reply
Sir, I would like to open a EV charging station in Bangalore , please sombody ping me to join the
hands.
Mob no : 9480778990
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 33/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
sir I am from Udupi and interested setup EV charging centre in udupi. Is it possible dor me. give
suggestion to my whatsapp no 9449388911. any interested to join me please call.
Reply
Reply
Anyone needs to install EV Charging station in Tamilnadu kindly drop us a mail or call
9894282030.
Reply
I was looking Forward to install EV Charging Station In Indore and Bhopal (M.P.)
Reply
I was looking Forward to install EV Charging Station In Bangalore & Entire Karnataka Pls Share
Details 9341700700 / cj@galaxydigital.live
Reply
Our team myevenergy provide charging stations at public places for 2 and 4 wheeler vehicle
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 34/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
We wish to establish PCS in kolhapur and Aurangabad, we want addresses of Indian Charging
system manufacturers who can join hand.
Reply
Hello sir,
Reply
All roses are good without thorns, sorry to have an explanation that
incase of main distribution of pwershortages and often now experiencing in many states.
Does this affect the revenue of the investor ? whether these too subsidized by the authorities ?
Reply
Reply
Hello,
I have just established my EV Fast charging station at Ludiana for 43 % of the cost just stated
above. I bought it from https://charzing.com
Reply
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 35/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
17000 sqft area in Siwna Bihar please provide details on whatsapp for ev charging station
8887324669
Reply
vijaymurge@myevenergy.com
Reply
You have considered a margin on the electricity. Is that allowed ? The policy mentions the tariff
cant be higher than 15% of average cost of supply for Discoms. Are the charging stations free to
determine the price they sell the charging at ?
Reply
Instead, it mentions service charge on the tariff,which I guess wont be more than 20%. So,
assuming tariff is ~ Rs 6/kWh, a 20% service charge would give only Rs 1.2/kWh to the
station owner.
Reply
Hi i m interested to open own EV charging station , please share all details, procedure, where i
am purchased EV station kit, cost, approval and condition.
Reply
Our team myevenergy provide charging stations, currently we are available in pune.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 36/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Sir , how much area required and cost also.is there subsidy from government
Reply
Hello sir,
Approximately 6feet×8feet for one vehicle, you can place multiple chargers depend on you place.
Cost depends on changers. Which type of chargers you are providing to vehicles. As per Gov. Rule
you should provide CCS. CHAdoMo, DC001, AC00, Type-2. You can provide one of the chargers
from list. If you provide this all type of chargers then minimum 50 lak required.
Government has decided some subsidy. But we don't know all things about it, because document
are not clear
Reply
I want to setup a fast charging station on highway, can someone tell me the process and share
me the detailed report about cost and procedure. I am new in business field so detailed
information is appreciated.
Reply
Our team will help you to provide public charging stations for electrical vehicle. You can join
with us
Mail- vijaymurge@myevenergy.com
Contact no- 7028641925
Web- www.myevenrgy.com
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 37/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Reply
Sir I want to set up public charging station at guntur AP what will the cost my mobile number &
wattsup no 8500418613
Reply
Reply
I want to set up EV charging station in Haldia(WB). NEED COMPLETE SOLUTIONS with monetary
benefits.
Reply
I'm a dealer of EV chargers. I'm looking for type 2 AC charger suppliers. I have a 2-3 customers
ready for type 2 AC units.
Reply
I want to start up every vehicle charging system and need to detailed information about it
HELP ME OUT FOR STARTING
Thank you
Arasuengineering.in
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 38/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Dear Sir,
need to know the how much land required for it with any specifications if any and the total cost of
establishing each stations excluding Lands Mobile/ Whatsaap# +91-9897968393
Reply
I WANT TO SET UP EV CHARGING STATATION IN AP.PL SEND ME THE DETAILED PROJECT REPORT
Reply
is there any system or software where I can track or lock the battery charging, (if I lease out the
battery to third party).. If yes what is the software and how much it will cost?
Reply
Reply
hello
sir my self Gts bhaarathi, i want to open. EV charging stn.kindly give me some information, and
how much the cost, and how much area required? and total expenses, i want to open in
Coimbatore, Tamil Nadu
Thanks
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 39/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
I want to set up a PCS in Kolkata how much space is required and what will be the cost .
Thanks
Reply
Reply
required details for installing public charging system 'EV'. Please send all details including cost
involved & break up of expenses in P&L excel.
REgards
Reply
Reply
Any one interested in set-up EV charging station at there premises can contact us. We can set-up
station on rental basis as well ownership basis as per your requirement. For more details kindly
contact us at raghuvir@efill.co.in.
Reply
Dear Sir,
Dear Sir,
You have given very good information Thanks.
We wish to establish PCS in Mathura, we want addresses of Indian Charging system
manufacturers who can join hand.
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 40/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Hi,
we can provide charges from one of the reputed manufacturer. kindly send me your details on
hemang@vrajmachinetools.com
Reply
Reply
Reply
dear SIr,
regards,
Hemang Parikh
Reply
Dear Team, Please give me A call we want to stablish the stations in Gorakhpur and eastern UP.
CALL 7880634047
Reply
We require details for installing public charging system 'EV'. Please send all details including cost
involved & break up of expenses
Whatsapp 9841138545 Chennai
Regards
Mohan
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 41/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Dear, Anybody interested in Business development Active partner for Installation of EV system
kindly contact me on my email id.
Thanks,
Reply
Reply
Reply
Reply
i want to intresting to ev charging station.we have place in SH5 please guide me how to i do for
this project
my mob no
9994718801
Reply
Hi All ,
First of all , am so happy my country is going green and the developments and transformation
happening here.
I have a lot of idea about the distruptions happening in our country. My first focus on solar , EV ,
AI. I Dont want to focus on one but all. I am 8 years experienced person if anybody looking out
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 42/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
for a trusted person to help set up your ev stations or expanding your business across pan india.
I am a very ambitous person and very much interested to set up ev station in bangalore , if any
investors ready to start ev stations in bangalore. Please contact me.
Sandiphr555@gmail.com
Thanks
Sandip
9845898627
Reply
Dear sir,
I am having a covered plot size: 18×75 sq. Ft in prominent place of shastri nagar, delhi -52, to
startacharging points for e- rickshaw looking for assistance in this field.
Cont: 9667319752, whatsapp: 9399852453
Email:ag003@rediffmail.com
Kind regards
Anil gautam
Reply
I want to install the electric charging station in my land. So please help me out. My address is
Shop no. 4 DDA market masoodpur Vasant Kunj New Delhi. 110070 . Pho:- 011 - 26121700.
MOB:- 9911800940
Regards.
Somvanshi Battery
Reply
want to install the electric charging station in pune, Aurangabad, Jalna., So please help me out
for process & Cost and what is required for the same,
9923962222
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 43/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Daund kedgoan chuffula we are interested to start charging station. Please tell me the process
and
Please contact 9890423382 dipak jagtap
Reply
Reply
Reply
Which forms are required to start the charging station and where to meet to take permission of
starting it???
Plz reply on Whatsapp if possible:-7990557354
Reply
Reply
Dear sir,
I am very much interested in EC Station for location Jamshedpur
further i need complete information regarding this project.
Please share my mail id sumit@sarojhardware.com
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 44/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
Hello Team,
I'm intersted to purchase the Battery charging filling station...and open electronic station on my
location could you please assist me how can i open and what is the procedure need to follow &
kindly send the details, norms, terms and conditiion and price on my e-mail id and contact on my
number.
Best Regards
Abhinav Rastogi
9045366070
Reply
Dear Sir,
You have given very good information Thanks.
We wish to establish PCS in Pune and Aurangabad, we want addresses of Indian Charging system
manufacturers who can join hand.and full procedure of PCS SYSTEM
Reply
Want to install the electric charging station in Shirdi, Nashik, Sangamner., So please help me out
for process & Cost and what is required for the same.
Contact- 9404346339
Reply
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 45/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
What are the terms and conditions to install electric charging station. I would like to take
dealership for EV charging in indore , bhopal .hence kindly guide me how to get the electric
charging station.
Reply
Reply
we are interested to start electrical two wheeler charging station at pimpri chinchwad link road.
Reply
We have electrical vehicle charging stations Manufacturer unit in pune. Please contact us
Reply
Thanks for your kind information, require to start pcs in mumbai, require more information on
area required and investments.
Kindly send the details
8655996685
Reply
How to gather more information? And what all the companies will help to setup the Ev stations in
Vadodar. ( Gujarat )
Reply
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 46/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Reply
I am interested to setup electronic charging station at my land which is on Valsad ..so, help to
further process either send the concern person detalis whom I talk and get the idea ... my
con.9824112084 & whatsup Detalis
Reply
You may read and waatch Video about , how charging station works, this will help you
understand about station.
Click on link below
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-solution/
Reply
Reply
Reply
Hi,
i am interested in setting up a EV station in delhi. My contact no is +91-9711154232 . So kindly
provide the process & Cost and other details.
Reply
You may read and waatch Video about , how charging station works, this will help you
understand about station.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 47/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-solution/
Reply
I want to open EV Charging station at Durgapur in WB. Please arrange to guide myself in W No
9775301703
Reply
You may read and waatch Video about , how charging station works, this will help you
understand about station.
Click on link below
https://emobilitydrive.com/sun-mobility-startup-battery-charging-station-swapping-solution/
Reply
This is very informative. Thanks for sharing your informative article with us. Keep up the fantastic
work.
TNR e vehicles industry provides the most sensational revolution in Electric Vehicles. Tnr Vehicle
industry proves great features such as No license required, No registration required facilities to
give you the driving experience.
Reply
Sir,please tell me
1) How much amount necessary to start this station.
2) How many land required approx?
3) How many HR required ?
4) Is there any scheme from company?
5) Latur Maharashtra,I need this
Reply
Dear Sir,
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 48/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
please contact me on hemang@vrajmachinetools.com for all these details. We can support you
with required details.
Reply
Dear sir
My self Manoj singh,.I want to set up an. EV charging station for business purpose. kindly give
me some information, and how much the cost, and h ow much area required? and total expenses,
i want to set up at Andal gram near Durgapur (WB) ,
Thanks,
,
Reply
Standalone PCS shall be a reality. Very soon we will see such PCS coming up at Metro stations.
33KV/66KV Lines. Higher currents. All Fast charging. Its going to give a huge uplift to EV market.
I am sure all of us shall buy nothing else but EV from 2021 end onwards.
Reply
Leave a Reply.
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 49/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
Name (required)
Website
Comments (required)
Categories
All
Ask Your EV Guru
Blogs From Heart & Soul
Charging Stations
Clean Energy
Commercial Vehicles
Community Initiatives
Electric Bikes
Electric Bus
Electric Cars
Electric MotorCycles
Electric Scooters
Events
EV Expos & Exhibitions
EV Industry News
EV Technology
EV Travelogues
How To Guides
Interviews
Podcasts
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 50/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
RE:LIVE Events
Student Projects
Surveys
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 51/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
RSS Feed
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 52/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 53/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 54/56
6/16/2020 Cost Estimates and Revenue Model for a Public Charging Station (PCS)
PLUG IN INDIA
About us
Advertise with us
Contact us
Privacy Policy
Terms of Service
SUPPORT US
Get access to exclusive perks
Become a YouTube member
Become a Patreon
email address
Subscribe
https://www.pluginindia.com/blogs/cost-estimates-and-revenue-model-for-a-public-charging-station-pcs 56/56