Professional Documents
Culture Documents
ABHD - 105 - 3 PAI-CAT-Sequence
ABHD - 105 - 3 PAI-CAT-Sequence
Well ABHD_105_3
Table of Contents
1. LOGGING OBJECTIVE.........................................................................................................................................3
2. WELL COMPLETION SCHEMATIC...................................................................................................................3
3. TOOL STRING DIAGRAM....................................................................................................................................4
4. WELL TRAJECTORY............................................................................................................................................5
5. WELL HISTORY.....................................................................................................................................................6
6. PVT DATA...............................................................................................................................................................6
7. CONVEYANCE.......................................................................................................................................................6
8. LOGGING PROCEDURE......................................................................................................................................6
1. Logging Objective
PAI-CAT to be run to identify multi-phase downhole flow profile across the horizontal openhole section.
GR
CCL
Pressure
Temperature
XY-caliper
PIA
4. Well Trajectory
5. Well History
ABHD-105 an active ARBB horizontal single lateral oil producer producing at a gross rate of 4.5 MBD at 73%
WC.
6. PVT Data
BO : N/A
GOR : N/A
API : N/A
Pb : N/A
Tb : N/A
Oil density : N/A
Water salinity : N/A
7. Conveyance
Conveying with a CT 2”
8. Logging Procedure
Flowing:
Continue record stabilization (As per Aramco Requirements ∆P < 5 psi/hr)
Perform vertical spinners calibration passes from 7400 ft to 7500 ft at 30, 50 and 70 ft/min
Record while RIH 7400 – 12350 ft
Record main down pass at 30 ft/min from 12350 ft to 14760 ft.
Record up main pass at 30 ft/min from 14760 ft to 12350 ft with stations at 14760ft (deepest
depth), 14500ft, 14200ft, 13900ft, 13600ft, 13300ft, 13000ft, 12700ft and 12350ft. This to be done
in time mode without overlap (RTS will confirm these stations after LQCing the main down pass).
Perform horizontal spinners calibration passes from 12600 ft to 12700 ft at 30, 50 and 70 ft/min
(This can be changed based on the main passes).
Stop at 12350’ and record for 15 minutes then shut-in the well.
Shut-in:
Record up main pass at 30 ft/min from 14760 ft to 12350 ft with stations at 14760ft (deepest
depth), 14500ft, 13900ft, 13300ft, 12700ft and 12350ft. This to be done in time mode without
overlap (RTS will confirm these stations after LQCing the main down pass).
POOH while recording 12350 – 7400 ft
Perform vertical spinners calibration passes from 7400 ft to 7500 ft at 30, 50 and 70 ft/min
POOH to surface while recording.
Note: Stationary measurement depths should be considered with respect to PAI-SAT and additional offset
should be added as per tool string.
Reduce speeds at restrictions