Professional Documents
Culture Documents
Toyota Camry covering Solara (1999-2001), Camry (1997-2001), Avalon (1997-2001), and Lexus ES 300 (1997-2001) Haynes
Online Manual
Note:
The hood is somewhat awkward to remove and install, at least two people should perform this procedure.
2 Disconnect any cables or wires that will interfere with removal. Disconnect the windshield washer tubing from
the nozzles on the hood.
3 Make marks around the hood hinge to ensure proper alignment during installation (see illustration) .
4 Have an assistant support the weight of the hood and, on Avalon models, detach the support struts by prying
out the clips at the top (see illustration) .
https://reader.haynes.com/en-us/cars/toyota/camry/1997-2001/MOL92007/manual/ 1/3
9/8/23, 7:50 PM Haynes Online - Toyota Camry covering Solara (1999-2001), Camry (1997-2001), Avalon (1997-2001), and Lexus ES 300 (1997-2…
6 Installation is the reverse of removal. Align the hinge bolts with the marks made in Step 3.
Adjustment
7 Fore-and-aft and side-to-side adjustment of the hood is done by moving the hinge plate slot after loosening
the bolts or nuts. Note: The factory bolts are “centering” type that will not allow adjustment. To adjust the hood
in relation to the hinges, these bolts must be replaced with standard bolts with flat washers and lock washers .
8 Mark around the entire hinge plate so you can determine the amount of movement.
9 Loosen the bolts and move the hood into correct alignment. Move it only a little at a time. Tighten the hinge
bolts and carefully lower the hood to check the position.
10 If necessary after installation, the entire hood latch assembly can be adjusted up-and-down as well as from
side-to-side on the radiator support so the hood closes securely and flush with the fenders. Scribe a line or mark
around the hood latch mounting bolts to provide a reference point, then loosen them and reposition the latch
assembly, as necessary (see illustration) . Following adjustment, retighten the mounting bolts.
https://reader.haynes.com/en-us/cars/toyota/camry/1997-2001/MOL92007/manual/ 2/3
9/8/23, 7:50 PM Haynes Online - Toyota Camry covering Solara (1999-2001), Camry (1997-2001), Avalon (1997-2001), and Lexus ES 300 (1997-2…
11 Finally, adjust the hood bumpers on the radiator support so the hood, when closed, is flush with the fenders
(see illustration) .
12 The hood latch assembly, as well as the hinges, should be periodically lubricated with white, lithium-base
grease to prevent binding and wear.
https://reader.haynes.com/en-us/cars/toyota/camry/1997-2001/MOL92007/manual/ 3/3