Professional Documents
Culture Documents
CM6206 Cmedia
CM6206 Cmedia
DESCRIPTION FEATURES
CM6206 is a highly integrated single chip USB USB spec. 2.0 full speed compliant
audio solution. All essential analog modules are USB audio device class spec. 1.0 and USB HID
embedded in CM6206, including 8CH DAC and class spec. 1.1 compliant
earphone buffer, 2CH ADC, microphone gain, PLL, IEC60958 spec. compliant (consumer format
regulator, and USB transceiver. It is very suitable S/PDIF input and output with loop-back support)
for high end USB external audio box, USB multi- SCMS (Serial Copy Management System)
channel headphone or USB audio interface multi- compliant
channel speaker set application. Dolby® digital audio streaming via S/PDIF
output interface
Many features are programmable with external USB remote wake-up support
EEPROM and MCU interface. In addition, 8 channel DAC output with 16 bit resolution
MCU/EEPROM/GPIO control can easily via HID 3.1 Vpp (1.1 Vrms) biased at 2.25V output swing
software interface. Better yet, CM6206 support Volume control and mute function
stereo MIC, phone jack sense, S/PDIF I/O 48 KHz Earphone buffer
sampling rate. Moreover, unique patent driver can Self power / Bus power selectable (by EEPROM)
support world’s first SPEAKER SHIFTER, Karaoke 2X interpolator for digital playback data to
and Dolby AC-3 real-time encoder functions. improve quality
2 channel ADC input with 16 bit resolution
BLOCK DIAGRAM
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 1/37
CM6206
High Integrated USB Audio I/O Controller
TABLE OF CONTENTS
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 2/37
CM6206
High Integrated USB Audio I/O Controller
9.4 10K loading (Line Out / Surround / Center LFE / Side Surround) Dynamic Range .... 31
9.5 32 ohm Headphone Loading Frequency Response / Passband Ripple.......................... 32
9.6 32 ohm Headphone Loading THD+N Curve / Dynamic Range ................................... 32
9.7 A-D Line in FSIV / THD+N Curve ............................................................................... 33
9.8 A-D Line in Frequency Response / Passband Ripple.................................................... 33
9.9 A-D Mic in FSIV / THD+N Curve................................................................................ 34
9.10 A-D Mic in Frequency Response / Passband Ripple..................................................... 34
Reference ........................................................................................................................................... 34
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 3/37
CM6206
High Integrated USB Audio I/O Controller
Many features are programmable with external EEPROM and MCU interface. In addition,
MCU/EEPROM/GPIO control can easily via HID software interface. Better yet, CM6206 support stereo MIC,
phone jack sense, S/PDIF I/O 48 KHz sampling rate. Moreover, unique patent driver can support world’s
first SPEAKER SHIFTER, Karaoke and Dolby AC-3 real-time encoder functions.
2 Features
USB spec. 2.0 full speed compliant
USB audio device class spec. 1.0 and USB HID class spec. 1.1 compliant
IEC60958 spec. compliant (consumer format S/PDIF input and output with loop-back support)
SCMS (Serial Copy Management System) compliant
Dolby® digital audio streaming via S/PDIF out S/PDIF output interface
USB remote wake-up support
8 channel DAC output with 16 bit resolution
3.1 Vpp (1.1 Vrms) biased at 2.25V output swing
Volume control and mute function
Earphone buffer
2X interpolator for digital playback data to improve quality
2 channel ADC input with 16 bit resolution
3.2 Vpp (or 4.0 Vpp programmed by vendor driver) biased at 2.25V input swing
Volume control and mute function
Additional headphone output with selectable source and phone jack sense
Isochronous transfer using adaptive synchronization with internal PLL
Stereo MIC support with 33dB maximum capability
Recording source select from S/PDIF, MIC, Line-in and summation of MIC, Line-in and front channel
MIC, Line-in monitor from front channel (all channels optional) with volume control and mute function
Master volume control by default; per-channel volume control by C-Media driver
Playback with soft-mute function
Support 48 / 44.1 KHz sampling rate for both playback and recording
MCU support with two-wire serial interface
Serial EEPROM support for customized VID/PID
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 4/37
CM6206
High Integrated USB Audio I/O Controller
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 5/37
CM6206
High Integrated USB Audio I/O Controller
3 Pin Descriptions
3.1 CM6206 LQFP 48Pin Table
2 XI 18 USBDP 34 RSOR
3 XO 19 USBDM 35 FROL
14 CS 30 AVSS1 46 MUTER
15 SK 31 HPOL 47 MUTEP
16 DR 32 HPOR 48 SPDIFO
AVDD1
VBIAS
AVSS1
RSOR
RSOL
VREF
FROR
HPOR
HPOL
FROL
LINR
LINL
36 35 34 33 32 31 30 29 28 27 26 25
AVDD2 37 24 MICR
SSOL 38 23 MICL
SSOR 39 22 AVSS3
CENO 40 21 DVDD1
LFEO
AVSS2
41
42
CM6206 20
19
REGV
USBDM
VOLUP
VOLDN
43
44
(LQFP48) 18
17
USBDP
DW
SPDIFI 45 16 DR
MUTER 46 15 SK
MUTEP 47 14 CS
SPDIFO 48 13 PHONES
1 2 3 4 5 6 7 8 9 10 11 12
PDSW
MCLK
XO
SCLK
LEDO
LEDR
DVSS1
SDAT
TEST
MINT
GPIO1
XI
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 6/37
CM6206
High Integrated USB Audio I/O Controller
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 7/37
CM6206
High Integrated USB Audio I/O Controller
Line out surround (rear) left channel (For Vista definition @ 7.1
33 RSOL AO
CH)
Line out side surround left channel (For Vista definition @ 5.1 /
38 SSOL AO
7.1CH )
Line out side surround right channel (For Vista definition @ 5.1 /
39 SSOR AO
7.1 CH)
S/PDIF output
48 SPDIFO DO
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 8/37
CM6206
High Integrated USB Audio I/O Controller
*Note 2: For LQFP 48 package, PWRSEL, PWRSEL1, MSEL1 and MSEL2 are internal bonding options; all of those 4 pins are
notbounded in default state.
4 Ordering Information
4.1 CM6206 (LQFP48)
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 9/37
CM6206
High Integrated USB Audio I/O Controller
5 Block Diagram
To access registers via HID interface, users should issue a “Set Output Report” HID request. The four
bytes of output report data is organized as below:
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 10/37
CM6206
High Integrated USB Audio I/O Controller
In addition to internal registers, users can also access external serial EEPROM by the same way:
15 14 13 12 11 10 9 8
7 6 5 4 3 2 1 0
14-12 Sampling_rate R/W SPDIF out sample rate (48K: 3’b010; 96K: 3’b110)
R/W SPDIF out category code depends on the equipment
11-4 Category code
type.
R/W SPDIFOUT emphasis. 1: emphasis-CD_type
3 Emphasis
0: Emphasis is not indicated
2 Copyright R/W 1: not asserted; 0: asserted
1 Non-audio R/W 1: non-PCM audio data (like AC3) 0: PCM-data
0 Pro/con R/W 1: professional format 0: consumer
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 11/37
CM6206
High Integrated USB Audio I/O Controller
15 14 13 12 11 10 9 8
7 6 5 4 3 2 1 0
14 SEL_CLK R/W For test. Select 44.1k source for DACs 1=from 22.58M
0=from 24.576M
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 12/37
CM6206
High Integrated USB Audio I/O Controller
15 14 13 12 11 10 9 8
7 6 5 4 3 2 1 0
2 EN_BTL R/W 1 = BTL mode enable. This bit only useful for 2ch mode.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 13/37
CM6206
High Integrated USB Audio I/O Controller
10: 6Mhz
11: 12Mhz
15 14 13 12 11 10 9 8
REQ[1]
7 6 5 4 3 2 1 0
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 14/37
CM6206
High Integrated USB Audio I/O Controller
15 14 13 12 11 10 9 8
7 6 5 4 3 2 1 0
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 15/37
CM6206
High Integrated USB Audio I/O Controller
15 14 13 12 11 10 9 8
7 6 5 4 3 2 1 0
2-0 T_SEL_DSAD R/W Select delta-sigma 1-bit input source to AD digital filter.
000: normal; 100: Front; 101: SSurround; 110: Cen/LFE;
111: RSurround
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 16/37
CM6206
High Integrated USB Audio I/O Controller
CM6206 supports two vendor specific requests. The formats of vendor requests are shown below:
1 bRequest 1 01
3 wValue_H 1 00
6 wLength 2 0000
1 bRequest 1 81
2 wValue 2 0000
There are only two registers can be accessed via vendor requests.
7 6 5 4 3 2 1 0
UNENCRDATA
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 17/37
CM6206
High Integrated USB Audio I/O Controller
7 6 5 4 3 2 1 0
3 MSEL2 --
7 6 5 4 3 2 1 0
CHIP-ID
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 18/37
CM6206
High Integrated USB Audio I/O Controller
7 6 5 4 3 2 1 0
CHIP-ID
7 6 5 4 3 2 1 0
FDBK1
7 6 5 4 3 2 1 0
FDBK2
7 6 5 4 3 2 1 0
FDBK3
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 19/37
CM6206
High Integrated USB Audio I/O Controller
CM6206 has one input pin ‘SCLK’ to get serial clock from MCU, and one open-drain output pin ‘SDAT’ to
send or receive serial signal to/from MCU. As shown below, ‘SDAT’ should be stable when ‘SCLK’ is high,
and can have transition only when ‘SCLK’ is low.
START and STOP conditions shown below are the exception. Every transaction begins from a START, and
ends with a STOP, or another START (repeated START).
The figure below demonstrates a transaction example. After every 8 bits sent by the transmitter, the
receiver should send one bit low for positive acknowledgement or one bit high for negative
acknowledgement. After the negative acknowledgement, a STOP or repeated START should follow.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 20/37
CM6206
High Integrated USB Audio I/O Controller
The figure below shows typical transactions between MCU and CM6206. After a START, MCU should send
7-bit slave address (7’b0111000) first, and then the 8 th bit denotes a read transfer when it’s high; or a
write transfer when it’s low.
MCU write:
S 8’h70 0 8’h01 0 Byte[1] 0 Byte[2] 1 P
MCU read:
S 8’h70 0 8’h00 1
In a write transfer, MCU keeps acting as the transmitter. CM6206 regards the first DATA byte as start
register address. The second and third DATA bytes are the content that MCU writes to the register
addresses.
In a read transfer, two transactions are necessary. MCU resets start register address by the first
transaction. Then MCU changes to be the receiver during the second transaction to get four bytes of data.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 21/37
CM6206
High Integrated USB Audio I/O Controller
Address = 0 16’h434dX
Address = 1 Vendor ID
Address = 2 Product ID
Address = 3 String 1,String 0
Address = 4 String 3,String 2
Address = 5 String 5,String 4
Address = 6 String 7,String 6
Address = 7 String 9,String 8
Address = 8 String 11,String 10
Address = 9 String 13,String 12
Address = 10 String 15,String 14
Address = 11 String 17,String16
Address = 12 String 19,String 18
Address = 13 String 21,String 20
Address = 14 String 23,String 22
Address = 15
Address = 16
Address = 17
Address = 18
Address = 19
Address = 20 {8’dx,MString 0}
Address = 21 {8’dx,MString 1}
Address = 22 {8’dx,MString 2}
Address = 23 {8’dx,MString 3}
Address = 24 {8’dx,MString 4}
Address = 25 {8’dx,MString 5}
Address = 26 {8’dx,MString 6}
Address = 27 {8’dx,MString 7}
Address = 28 {8’dx,MString 8}
Address = 29 {8’dx,MString 9}
Address = 30 {8’dx,MString 10}
Address = 31 {8’dx,MString 11}
Address = 63 16’hXXXX
Users can program serial EEPROM via HID interface, as described in the former section. The first word is a
magic code. Only when it matches, CM6206 will regard the serial EEPROM valid.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 22/37
CM6206
High Integrated USB Audio I/O Controller
To meet un-configured current specification of USB, CM6206 provides a control signal PDSW to turn off
external components. PDSW would be active when USB host does not configure CM6206. PDSW would also
be active when CM6206 is suspended. If serial EEPROM is exist, notice that it should not be powered off
anyway because it contains Vendor ID and Product ID which should be returned to USB host before CM6206
is configured.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 23/37
CM6206
High Integrated USB Audio I/O Controller
7 Volume Control
7.1 DAC Volume Control
Note: VOL_*_ stands for VOL_REC_L_ and VOL_REC_R_. The volume control is in log scale.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 24/37
CM6206
High Integrated USB Audio I/O Controller
VOL_*_<4:0> Scale (log) VOL_*_<4:0> Scale (log) VOL_*_<4:0> Scale (log) VOL_*_<4:0> Scale (log)
00 +12.0dB 08 0.0dB 16 -12.0dB 24 -24.0dB
Note: VOL_*_ stands for VOL_MICM_L_, VOL_MICM_R_, VOL_LINEM_L_, VOL_LINEM_R_. The volume control is in log scale.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 25/37
CM6206
High Integrated USB Audio I/O Controller
8 Electrical Characteristics
8.1 Maximum Ratings
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 26/37
CM6206
High Integrated USB Audio I/O Controller
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 27/37
CM6206
High Integrated USB Audio I/O Controller
-0 -0
-0.012 -0.009
-0.5 -0.5
-0.949-1 -0.949-1
-1.5 -1.5
d -2 d -2
B B
r -2.5 r -2.5
A -3 A -3
-3.5 -3.5
-4 -4
-4.5 -4.5
-5 -5
-5.5 -5.5
-6 -6
20 50 100 200 500 1k 2k 5k 10k 19.998k
20k 20 50 100 200 500 1k 2k 5k 10k 19.998k
20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2 Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2
1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *-0.949 dBr A *-0.012 dBr A 1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *-0.949 dBr A *-0.009 dBr A
1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left -0.950 dBr A -0.014 dBr A 1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left -0.949 dBr A -0.015 dBr A
-0 -0
-0.015 -0.01
-0.5 -0.5
-0.949-1 -0.949-1
-1.5 -1.5
d -2 d -2
B B
r -2.5 r -2.5
A -3 A -3
-3.5 -3.5
-4 -4
-4.5 -4.5
-5 -5
-5.5 -5.5
-6 -6
20 50 100 200 500 1k 2k 5k 10k 19.998k
20k 20 50 100 200 500 1k 2k 5k 10k 19.998k
20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2 Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2
1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *-0.949 dBr A *-0.015 dBr A 1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *-0.949 dBr A *-0.010 dBr A
1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left -0.949 dBr A -0.014 dBr A 1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left -0.949 dBr A -0.014 dBr A
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 28/37
CM6206
High Integrated USB Audio I/O Controller
9.2 10K loading (Line Out / Surround / Center LFE / Side Surround) Passband Ripple
+0.4 +0.4
+0.3 +0.3
+0.2 +0.2
+0.1 +0.1
d d
B +0.044 B +0.045
r +0 r +0
A -0.1 A -0.1
-0.2 -0.2
-0.234 -0.234
-0.3 -0.3
-0.4 -0.4
-0.5 -0.5
20 50 100 200 500 1k 2k 2.93555k 5.79492k
5k 10k 20 50 100 200 500 1k 2k 2.93555k 5.79492k
5k 10k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2 Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2
1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left +0.045 dBr A -0.234 dBr A 1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *+0.045 dBr A *-0.234 dBr A
1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left *+0.044 dBr A *-0.234 dBr A 1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left +0.045 dBr A -0.234 dBr A
+0.4 +0.4
+0.3 +0.3
+0.2 +0.2
+0.1 +0.1
d d
B +0.045 B +0.043
r +0 r +0
A -0.1 A -0.1
-0.2 -0.2
-0.234 -0.235
-0.3 -0.3
-0.4 -0.4
-0.5 -0.5
20 50 100 200 500 1k 2k 2.93555k 5.79492k
5k 10k 20 50 100 200 500 1k 2k 2.93555k 5.79492k
5k 10k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2 Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2
1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *+0.045 dBr A *-0.234 dBr A 1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *+0.043 dBr A *-0.235 dBr A
1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left +0.045 dBr A -0.234 dBr A 1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left +0.044 dBr A -0.235 dBr A
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 29/37
CM6206
High Integrated USB Audio I/O Controller
9.3 10K loading (Line Out / Surround / Center LFE / Side Surround) THD+N Curve
+0
-40
-10
-50 -20
-60 -30
-40
d -70
B d -50
r -80 B
r -60
A -90 A -70
-80
-100
-90
-110
-100
-110
20 50 100 200 500 1k 2k 5k 10k 20k
Hz -120
20 50 100 200 500 1k 2k 5k 10k 20k
Hz
Sweep Trace Color Line Style Thick Data Axis Comment
Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Cyan Solid 2 Anlr.THD+N Ampl Left
1 2 Yellow Solid 2 Anlr.THD+N Ampl Left 1 1 Cyan Solid 2 Anlr.THD+N Ampl Left
1 2 Yellow Solid 2 Anlr.THD+N Ampl Left
+0 +0
-10 -10
-20 -20
-30 -30
-40 -40
d -50 d -50
B B
r -60 r -60
A -70 A -70
-80 -80
-90 -90
-100 -100
-110 -110
-120 -120
20 50 100 200 500 1k 2k 5k 10k 20k 20 50 100 200 500 1k 2k 5k 10k 20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Cyan Solid 2 Anlr.THD+N Ampl Left 1 1 Cyan Solid 2 Anlr.THD+N Ampl Left
1 2 Yellow Solid 2 Anlr.THD+N Ampl Left 1 2 Yellow Solid 2 Anlr.THD+N Ampl Left
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 30/37
CM6206
High Integrated USB Audio I/O Controller
9.4 10K loading (Line Out / Surround / Center LFE / Side Surround) Dynamic Range
Audio Precision A-A FFT SPECTRUM ANALYSIS 10/20/06 16:37:17 Audio Precision A-A FFT SPECTRUM ANALYSIS 10/20/06 16:36:49
+20 +20
+0 +0
-20 -20
-40 -40
d -60 d -60
B B
V V
-80 -80
-100 -100
-120 -120
-140 -140
2k 4k 6k 8k 10k 12k 14k 16k 18k 20k 2k 4k 6k 8k 10k 12k 14k 16k 18k 20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Yellow Solid 1 Fft.Ch.1 Ampl Left 1 1 Yellow Solid 1 Fft.Ch.1 Ampl Left
1 2 Cyan Solid 1 Fft.Ch.2 Ampl Left 1 2 Cyan Solid 1 Fft.Ch.2 Ampl Left
Requires DSP. Analog Analyzer input is A-D converted and analyzed with the FFT Digital analyzer. Signal source may be Requires DSP. Analog Analyzer input is A-D converted and analyzed with the FFT Digital analyzer. Signal source may be
Generator or external. Click "Sweep Spectrum/Waveform" swap button to switch between frequency and time displays . Generator or external. Click "Sweep Spectrum/Waveform" swap button to switch between frequency and time displays .
+20 +20
+0 +0
-20 -20
-40 -40
d -60 d -60
B B
V V
-80 -80
-100 -100
-120 -120
-140 -140
2k 4k 6k 8k 10k 12k 14k 16k 18k 20k 2k 4k 6k 8k 10k 12k 14k 16k 18k 20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Yellow Solid 1 Fft.Ch.1 Ampl Left 1 1 Yellow Solid 1 Fft.Ch.1 Ampl Left
1 2 Cyan Solid 1 Fft.Ch.2 Ampl Left 1 2 Cyan Solid 1 Fft.Ch.2 Ampl Left
Requires DSP. Analog Analyzer input is A-D converted and analyzed with the FFT Digital analyzer. Signal source may be Requires DSP. Analog Analyzer input is A-D converted and analyzed with the FFT Digital analyzer. Signal source may be
Generator or external. Click "Sweep Spectrum/Waveform" swap button to switch between frequency and time displays . Generator or external. Click "Sweep Spectrum/Waveform" swap button to switch between frequency and time displays .
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 31/37
CM6206
High Integrated USB Audio I/O Controller
-0.5 +0.3
-0.447
-0.952-1 +0.2
-1.5
+0.1
d -2 d
B B +0.045
r -2.5 r +0
A -3 A -0.1
-3.5
-4 -0.2
-0.235
-4.5 -0.3
-5
-0.4
-5.5
-6 -0.5
20 50 100 200 500 1k 2k 5k 10k 19.998k
20k 20 50 100 200 500 1k 2k 2.93555k 5.79492k
5k 10k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2 Sweep Trace Color Line Style Thick Data Axis Comment Cursor1 Cursor2
1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left -0.952 dBr A -0.462 dBr A 1 1 Cyan Solid 1 Fasttest.Ch.1 Ampl!Normalize Left *+0.045 dBr A *-0.235 dBr A
1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left *-0.952 dBr A *-0.447 dBr A 1 2 Yellow Solid 1 Fasttest.Ch.2 Ampl!Normalize Left +0.045 dBr A -0.234 dBr A
Audio Precision 10/16/06 15:33:48 Audio Precision A-A FFT SPECTRUM ANALYSIS 10/20/06 16:13:03
+20
+0
-10 +0
-20
-20
-30
-40
-40
d -50 d -60
B B
r -60 V
-80
A -70
-100
-80
-90 -120
-100
-140
-110
2k 4k 6k 8k 10k 12k 14k 16k 18k 20k
-120 Hz
20 50 100 200 500 1k 2k 5k 10k 20k
Hz Sweep Trace Color Line Style Thick Data Axis Comment
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 32/37
CM6206
High Integrated USB Audio I/O Controller
Audio Precision A-D THD+N vs AMPLITUDE 10/16/06 12:02:36 Audio Precision A-D THD+N vs FREQUENCY 10/16/06 12:03:32
dx=-859.4 mVrms
+0 +0
-10
-20 -20
-30
-40
-40
d -50 d
B B -60
-60
F F
S -70 S
-80
-80
-90 -100
-100
-110 -120
-120
0 147.6m 500m 1.007
1 1.5 2 2.5 3 20 50 100 200 500 1k 2k 5k 10k 20k
Vrms Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Yellow Solid 1 DSP Anlr.THD+N Ampl A Left 1 1 Yellow Solid 1 DSP Anlr.THD+N Ampl A Left
1 2 Cyan Solid 1 DSP Anlr.THD+N Ampl B Left 1 2 Cyan Solid 1 DSP Anlr.THD+N Ampl B Left
Audio Precision A-D FREQUENCY RESPONSE 10/16/06 12:11:54 Audio Precision A-D FREQUENCY RESPONSE 10/18/06 18:06:40
dx=3.30250 kHz dy=+0.252 dB
+0.5 +0.5 +0.5 +0.5
+0 +0 +0 +0
d -1 -1 d d -1 -1 d
B B B B
F F F F
-1.5 -1.5 -1.5 -1.5
S S S S
-1.788
-2 -2 -2 -2
-2.04
-3 -3 -3 -3
20 50 100 200 500 1k 2k 5k 10k 20k 20 50 100 200 500 1k 2k 3.32k 5k
6.6225k10k 20k
Hz Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Yellow Solid 1 DSP Anlr.Level A Left 1 1 Yellow Solid 1 DSP Anlr.Level A Left
1 2 Green Solid 1 DSP Anlr.Level B Right 1 2 Green Solid 1 DSP Anlr.Level B Right
1 3 Cyan Solid 1 DSP Anlr.Level B Left 1 3 Cyan Solid 1 DSP Anlr.Level B Left
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 33/37
CM6206
High Integrated USB Audio I/O Controller
Audio Precision A-D THD+N vs AMPLITUDE 10/16/06 11:57:37 Audio Precision A-D THD+N vs FREQUENCY 10/16/06 11:55:16
dx=-859.4 mVrms
+0 +0
-10
-20 -20
-30
-40
-40
d -50 d
B B -60
-60
F F
S -70 S
-80
-80
-90 -100
-100
-110 -120
-120
0 147.6m 500m 1.007
1 1.5 2 2.5 3 20 50 100 200 500 1k 2k 5k 10k 20k
Vrms Hz
Sweep Trace Color Line Style Thick Data Axis Comment Sweep Trace Color Line Style Thick Data Axis Comment
1 1 Yellow Solid 1 DSP Anlr.THD+N Ampl A Left 1 1 Yellow Solid 1 DSP Anlr.THD+N Ampl A Left
1 2 Cyan Solid 1 DSP Anlr.THD+N Ampl B Left 1 2 Cyan Solid 1 DSP Anlr.THD+N Ampl B Left
+0 +0 +0 +0
-0 .5 -0 .5 -0.5 -0.5
d -1 -1 d d -1 -1 d
B B B B
F F F F
-1 .5 -1 .5 -1.5 -1.5
S S S S
-2 -1.862
--12 . 9 9 2 -2 -2
-2.114
-2 .5 -2 .5 -2.5 -2.5
-2 .7 5 2
-3 -3 -3 -3
20 50 100 200 500 1k 2k 5k 10k 2 0 2k 0 k 20 50 100 200 500 1k 2k 3.32k 5k
6.6225k10k 20k
Hz Hz
Sw eep T ra c e C o lo r L in e S ty le T h ic k D a ta A xis C om m ent Sweep Trace Color Line Style Thick Data Axis Comment
Reference
USB-IF, USB Specification, Revision 1.1 and 2.0, and USB Audio Device Class Specification, Revision 1.0.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 34/37
CM6206
High Integrated USB Audio I/O Controller
炼End of Specifications炼
FAX烉+886-2-8773-2211
E-MAIL烉sales@cmedia.com.tw
Disclaimer:
Information furnished by C-Media Electronics Inc. is believed to be accurate and reliable. However, no responsibility is assumed by C-Media Electronics Inc. for its use, nor for
any infringements of patents or other rights of third parties that may result from its use. Specifications subject to change without notice. No license is granted by implication or
otherwise under any patent or patent rights of C-Media. Trademark and registered trademark are the property of their respective owners.
www.cmedia.com.tw
Copyright © C-Media Electronics Inc. Rev. 2.3 災 Page 35/37