Professional Documents
Culture Documents
114 English
114 English
Airway philosophy and anatomy of the nose and nasopharynx are covered in “airway Masterclasses” 1 and
2. This tutorial will cover the following topics:
Anatomy of the larynx
Laryngeal nerve injury (causes and consequences)
Needle and surgical cricothryoidotomy
Percutaneous tracheostomy
SELF ASSESSMENT
Before reading this tutorial, try and answer the following questions. Once you have been through the
tutorial, look at them again to confirm your answers in light of what you have read.
Q3. The following methods can block sensory input from the larynx:
a. local anaesthetic spray to the cords
What are the indications for performing a tracheostomy on the Intensive Care Unit?
THE LARYNX
Functions
The larynx acts as a protective sphincter of the respiratory tract, separating the trachea from the upper
gastrointestinal tract, preventing aspiration during swallowing. It contains the vocal apparatus, and so is
important in communication, but it is also required for an effective cough and to perform a valsalva
manoeuvre.
The larynx is located in the anterior part of the neck, anterior to the bodies of the fourth to sixth cervical
vertebrae and the laryngopharynx. On each side of the larynx is the carotid sheath and a lobe of the thyroid
gland. The latter are joined anteriorly by the thyroid isthmus that overlies the second to fourth tracheal
rings. Further anteriorly lies the superficial and deep fascia and platysma muscle.
The larynx is made up of 9 cartilages forming the laryngeal skeleton, these are joined by various ligaments
and membranes (Figs 1,2). It has three unpaired cartilages (thyroid, cricoid, epiglottis) and three paired
cartilages (arytenoid, corniculate, cuneiform).
The hyoid bone (level with C3) is not strictly part of the larynx but is attached by the thyrohyoid membrane
to the thyroid cartilage. Below this are the three unpaired midline cartilages:
1. Thyroid cartilage. This is the largest of the laryngeal cartilages, shaped like a ‘shield’, with two
laminae that are fused in the midline at an angle of 90°in men (120° in women) forming the
subcutaneous laryngeal prominence (Adam’s apple). The upper (C4) and lower (C5) borders comprise
superior and inferior cornua (horns). The superior border is attached to hyoid bone by the thyrohyoid
membrane. The inferior cornu articulates with the cricoid cartilage.
2. Cricoid cartilage. This is a complete ring of cartilage at level of C6, with a larger posterior lamina and
narrower anterolateral arch. It articulates laterally with the inferior thyroid cornua, and posteriorly with
the arytenoid cartilages. It is attached to the inferior border of the thyroid cartilage by the cricothyroid
ligament and to the superior border of the first tracheal ring by the cricotracheal ligament. Because it is
a complete ring, application of pressure anteriorly will compress the oesophagus that lies posteriorly –
a technique used during rapid sequence induction of anaesthesia to help prevent aspiration of
regurgitated gastric contents (cricoid pressure, Sellick’s manoeuvre).
3. Epiglottis. This is a “leaf-shaped” elastic cartilage, the inferior narrower end is attached to the thyroid
cartilage (to the back of the laryngeal prominence) by the thyroepiglottic ligament. It is attached
anteriorly to the hyoid bone by the hyoepiglottic ligament. The upper broader end is free to project
Thyrohyoid membrane – connects the thyroid cartilage and the hyoid bone.
Hypo-epiglottic ligament – connects the hyoid bone to the lower part of the epiglottis
Recurrent laryngeal nerve (RLN). On the right, leaves the vagus as it crosses the subclavian artery,
passes under the artery and ascends to reach the larynx, lying between the oesophagus and trachea. On the
left, leaves the vagus as it crosses the arch of the aorta, passes under the aorta and ascends as on the right.
Sensory supply to the subglottis and motor supply to all intrinsic muscles of the larynx (except
cricothyroid).
Glossopharyngeal (IX) cranial nerve. Sensory supply to the tongue base and vallecula (superior border
of epiglottis).
Local anaesthesia of the airway is essential for awake fibreoptic intubation as described in Airway
Masterclass 2, the simplest and commonest method to use is topical lignocaine (nebulised, gargled or most
commonly a ‘spray as you go’ technique). This method can be supplemented with a SLN block and a
transtracheal block (see below). The external branch of the SLN can be blocked below the greater horn of
the hyoid, through the thyrohyoid membrane. The internal branch of SLN can be blocked by placing
pledgets soaked in lignocaine in the pyriform fossa.
Transtracheal block.
SLN – external branch – may be damaged during thyroid surgery, as it lies with the superior thyroid
vessels. Loss of cricothryoid causes loss of vocal cord tension and hoarseness following unilateral damage.
This may be temporary as the opposite cricothyroid often compensates.
RLN – may be damaged during thyroid surgery, as it lies close to the inferior thyroid vessels. Due to the
long thoracic course of the nerve, it can be damaged by aortic aneurysms, enlarged right atrium, lung and
oesphageal cancer and enlarged lymph nodes.
If unilateral RLN injury occurs, the vocal cord adopts a midline position, resulting in voice hoarseness (this
may be the presenting complaint of serious underlying pathology), ineffective cough and recurrent
aspiration. In the case of bilateral RLN injury, vocal cord function is lost, resulting in life threatening
airway obstruction.
Emergency Airways
This is a life threatening emergency which, if managed badly, will lead to morbidity and death. Knowledge
of the anatomy of the larynx will aid in the safe and effective management of this situation. This tutorial
will cover the procedures of emergency needle and surgical cricothryoidotomy, but both skills should be
practiced where ever possible on a manikin. The advice given below is based on the use of what is felt to be
the most widely available equipment in hospitals, accepting that there are a variety of commercial pieces of
apparatus now available. It is essential that everyone should know the location of such equipment and be
familiar with how to use it in an emergency situation. For further guidance of CICV see Plan D of the
Difficult Airway Society guidelines (http://www.das.uk.com/guidelines/cvci.html).
Needle cricothyroidotomy
This is quicker and easier than a surgical cricothyroidotomy. It is performed via the cricothryoid
membrane that is relatively easily palpable, avascular and superficial.
• Prepare a 10ml syringe containing 5ml saline and attach to a large bore IV cannula (14-16G) .
• Extend the neck and identify the cricothyroid membrane. This is usually felt as the depression
between the thyroid cartilage and cricoid ring.
• Stabilise the trachea with the thumb and forefinger of one hand to prevent lateral movement of the
trachea.
• Puncture the skin vertically in the midline, directly over the cricothryoid membrane.
• Advance through the cricothyroid membrane in a slightly caudal direction. Withdraw the syringe
plunger gently, aspiration of air bubbles freely into the syringe comfirms tracheal placement of the
tip of the cannula.
• Angle the cannula at approximately 45 degrees and advance the cannula over the needle, taking
care not to advance the needle too far and risk perforating the posterior wall of the trachea (Fig
3a).
• Remove the needle and try to prevent the cannula from kinking (ask an assistant to hold it in
place) and being displaced as oxygen is delivered.
• Attach the cannula to high flow oxygen supply via oxygen tubing with a hole cut into the side of
the tubing or via a 3-way tap (Fig 3b) or “Y” connector. Intermittent ventilation can be achieved
by occluding the open hole cut into the oxygen tubing (or occlusion of one limb of the connector)
with your thumb. The usual recommendation is to insufflate oxygen by occlusion for one second
and releasing it for four seconds. The latter allows expiration to occur (and excess gas to be
vented) via the patient’s own airway, NOT the cannula. This is usually heard as vigorous bubbling
sound as gas escapes via this route during insufflation.
• An alternative is to use a device that delivers high flow oxygen, e.g. a Sander’s injector or
Manujet device. There is a high risk of barotrauma with these devices due to the high pressures
which can rapidly develop.
• Check for rise and fall of the chest.
• Plan for an emergency tracheostomy.
The technique described above is very useful if there is no commercial kit available to carry out a
cricothyroidotomy (e.g. Patil cricothyroidotomy kit, Cooke Medical, Fig 3c). However, when using a small
diameter device, there is a high risk of it becoming blocked or displaced.
A major disadvantage of this technique is when the upper airway is completely occluded and expiration and
escape of excessive gas volumes cannot occur via the patient’s normal airway. In these circumstances, only
small volumes of oxygen should be insufflated and arrangements made for an urgent surgical airway to
allow ventilation (see below). Simply inserting additional cannulas does not allow expiration to occur. (To
test this, take a clean 16G cannula and try to exhale through it!).
A number of other techniques of delivering oxygen via a transtracheal cannula have been described, (e.g.
16G cannula connected to ETT connector from 3.5 neonatal tracheal tube, 16G cannula connected to 10ml
syringe with plunger removed, size 7.0 ETT inserted into barrel and cuff inflated), these only allow
Surgical cricothyroidotomy
This technique allows insertion of a relatively small diameter cuffed tracheostomy tube via the cricothyroid
membrane. Purpose-made devices are available and usually rely on the Seldinger method for introduction
(Melker® emergency cricothyrotomy). However, a small diameter (6.0mm) tracheostomy tube can be
inserted as described below. Having inserted a relatively larger diameter cuffed tube, a normal breathing
system can be used to ventilate the patient, attachment of capnography and avoidance of barotrauma. An
alternative cuffless device is the Portex Mini-trach kit (4.0mm tube), but ventilation is less effective.
This technique is usually associated with significant bleeding from blood vessels dilated as a result of
hypoxia and hypercapnia. Do not stop to try and secure haemostasis, most of the bleeding will abate once
the hypoxia has been corrected. In the presence of laryngeal trauma or swelling over the larynx, an
emergency tracheostomy is the technique of choice.
Percutaneous tracheostomy
PREPARATION
This is paramount, ensure decision to perform tracheostomy is appropriate and safe. Preparation of
equipment and patient takes time (Fig 4). A separate trained anaesthetist for managing both the airway and
anaesthesia of the patient is essential. They should be equipped with drugs and instruments for a
potentially difficult re-intubation. A total intravenous technique provides smooth anaesthesia for
performing the bronchoscopy and tracheostomy, though an inhalation technique is possible.
Ideally, ensure that the patient is fully monitored including end-tidal CO2. The patient should be
preoxygenated with 100% oxygen for at least 5 minutes before starting the procedure. The neck is extended
by placing a sandbag or similar under the patient’s shoulders and the head in a head ring. This brings as
much of the trachea as possible into the neck. The thyroid cartilage, cricoid cartilage and first three
tracheal rings are identified by palpation. The tracheostomy should ideally pass between the second and
third tracheal rings, although a space one higher or lower may be employed. Placing the tracheostomy next
to the cricoid, can cause tracheal erosion and long-term problems. Infiltrate the soft tissues of the chosen
site for tracheostomy with lidocaine 1% with 1:200,000 adrenaline to reduce bleeding.
PROCEDURE
Ideally, this procedure should be conducted with bronchoscopy as described below to increase the success
and reduce complications. If a bronchoscope is not available, great care must be taken to ensure that the
track created is into the trachea. The risk of misplacement is high, and if there is any doubt, a surgical
tracheostomy is a safer option.
Following induction of anaesthesia, the patient is prepped and draped. The bronchoscope is passed through
the tracheal tube and the anatomy of the airway visualised. The cuff of the existing tracheal tube is deflated
and the tube is withdrawn under direct laryngoscopy until the cuff is seen (necessary to allow unimpeded
passage of guide wire and dilator(s) into the trachea). The tracheal tube must then be secured to prevent
dislodgement and the cuff reinflated. The bronchoscope is then positioned in the tracheal tube to observe
or check that the point of entry of the needle is through the centre of the anterior tracheal wall. Care must
be taken not to damage the bronchoscope with the needle. A 2 cm horizontal incision is made with a
scalpel blade through the skin. The introducer needle and cannula is then slowly advanced in the midline,
through the incision, at 45 degrees to the skin, until air is aspirated from the trachea. The needle is
removed, leaving the cannula in the trachea and a J-tipped flexible guidewire is threaded through the
The track is now gradually dilated, using either a single tapered dilator or a series of gradually increasing
diameter dilators. If a dilator does not pass easily, often it is the skin that impedes progress, and the incision
has to be widened slightly with the scalpel. Once the track is maximally dilated, the tracheostomy tube is
inserted over the wire and the wire removed. With the tracheostomy tube in place, the tracheal tube is
removed and the ventilator is connected to the tracheostomy. The chest is auscultated for adequate
ventilation and the ventilator checked for appropriate tidal volumes and airway pressures. The
tracheostomy is then secured with a tie, and the lumen aspirated to remove blood and secretions. Presence
of surgical emphysema at the site is also watched for, and chest X-ray is performed to check for tube
position and pneumothorax. Alternatively, a bronchoscope can be inserted via the tracheostomy tube into
the trachea, and satisfactory position can be confirmed without the need for CXR.
Complications
Early
Late
• Oxford Handbook of Anaesthesia 2nd edition. Allman KG, Wilson IH Oxford University Press 2006.
• Concise anatomy for Anaesthesia. Andreas Erdmann.
• Update in Anaesthesia: Percutaneous tracheostomy. Professor A Rudra. Issue 15 (2002) Article 16
• www.frca.co.uk
• www.das.uk.com Difficult Airway Society homepage, access to their guidelines.
• www.cookmedical.com (shows examples of commercially available emergency cricothyroidotomy
kits)
The authors would like to thank Anaesthesia UK for permission to reproduce figures 1 and 2.