Professional Documents
Culture Documents
3. In the circuit shown below, voltages VIN is 3V, VB1 is -1V and VB2 is 1V. Assume both
diodes are identical. The cut-in voltage of the diode is 0.7V. Forward bias resistance is
10Ohm. The voltage Vout is:
A. 0.6V
B. 1V
C. 1.7V
D. 2V
4. What is the role of the faculty advisor during the competition?
A. Officially receiving trophies during the award ceremony.
B. Doing the on-site team registration.
C. Accompanying the team’s car through scrutineering.
D. None of the above.
7. During the Business Plan Presentation, Team K goes over the limit. What happens to
Team K?
A. Team K gets 0 points.
B. Team K gets a 10 point penalty.
C. Team K gets de-registered from the competition.
D. Team K gets stopped without any penalty.
8. I have 4 CU that wants to communicate at the same time on a 1Mbit/s CAN line, which
one wins the arbitration ?
A. CU1
B. CU2
C. CU3
D. CU4
9. What is the push bar:
A. The part of the chassis that supports the suspensions
B. The part of the chassis between the front bulkhead and the front hoop
C. The device for jacked up the vehicle
D. The device for moving the vehicle in the pit lane and in the dynamic area
10. If a full cylinder has a Moment of Inertia of J = 1,08 kg/m^2, what is the Moment of
Inertia of a full cylinder with the same mass but half the diameter?
A. 0.16 kg/m^2
B. 0.27 kg/m^2
C. 0.73 kg/m^2
D. 0.84 kg/m^2
11. Consider having an axle power of 400 hp to overcome aerodynamic drag. What is the
maximum achievable speed if S=1,5m and c_x=0,3? Give the answer in mph without
reporting decimal digits.
A. u=183 mph
B. u=160 mph
C. u=145 mph
D. u=195 mph
12. How many people can enter in the dynamic area?
A. 4 people including the driver
B. 5 people, because there are 4 dynamic vests and one driver that shouldn’t wear
the dynamic vest
C. 4 team members that wear the dynamic vests and every driver that wear the
pilot suit
D. 3 team members and one driver that must always sit in the car
15. How many sets of tires are allowed to be used during all dynamic events
A. Only one set of tires per type (dry / wet) may be used during all the dynamic
events. The brake test, practice area and the static events are included from
this regulation.
B. Only one set of tires per type (dry / wet) may be used during all the dynamic
events. The brake test, practice area and the static events are excluded in
this regulation.
C. None of the above
D. Not restricted and tire set choice is based on track condition.