Professional Documents
Culture Documents
2. Composition/information on ingredients
3. Hazards identification
Page 1 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
4. First-aid measures
Inhalation
Remove to fresh air and keep victim warm and at rest. If respiratory problems are
present, administer artificial respiration. If victim is unconscious, place him in the
recovery position and seek immediate medical advice.
Skin Contact
Immediately remove contaminated clothing. Wash off promptly and flush
contaminated skin with soap and water. Do NOT use solvents or thinners.
Eye Contact
Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash
eyes with plenty of water while lifting the eyelids. Get medical attention immediately if
symptoms occur after washing.
Ingestion
Get immediate medical attention. Do NOT induce vomiting.
Extinguishing Media
Use: alcohol resistant foams, carbon dioxide (CO2). Dry chemicals, sand, dolomite,
powdered talc etc. Do not use water if avoidable.
Anyone with a history of skin sensitisation must on no account handle such products.
Handling
Handle in well-ventilated areas.
Page 2 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
Never open the packages under pressure.
Fire prevention
Prevent access by unauthorised personnel.
Storage
Keep the container tightly closed in a dry place. Store in a cool, dry and well ventilated
place, away from sources of heat and direct sunlight. Keep away from sources of
ignition, oxidizing agents and corrosive materials.
ACGIH TLV:
TWA: 100 ppm
STEL: 150 ppm
NIOSH REL:
none listed
Ventilation
Page 3 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
No specific ventilation requirements noted, but forced ventilation may still be required
if air contamination exceeds acceptable level.
Respirators
Where exposure cannot be adequately controlled by engineering measures (e.g. by
ventilation), suitable approved respirators should be worn.
Protective Gloves
If contact with the hands is unavoidable, wear impervious gloves; consult glove
suppliers for appropriate types.
Eye Protection
Use safety eyewear designed to protect against liquid splashes. No contact lenses
are allowed.
Skin Protection
Cotton and/or synthetic overalls are normally suitable. Grossly contaminated clothing
should be immediately removed and the affected skin areas thoroughly rinsed with
soap and water. Do not use solvents and thinners.
Information pertaining to the health effects and toxicity of the “pure” form of the hazardous
components identified in section 2 is presented below. This information reflects the known
hazards associated with the component and may not reflect that of the purchased material due to
concentration (dilution) effects.
Page 4 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
Acute toxicity:
High boiling High boiling Aromatic Hydrocarbon is a petroleum-derived complex
Aromatic substance.
Hydrocarbon
Naphthalene CAS# 91-20-3:
LD50/LC50:
Draize test, rabbit, eye: 100 mg Mild;
Inhalation, rat: LC50 = >340 mg/m3/1H;
Oral, mouse: LD50 = 316 mg/kg;
Oral, rat: LD50 = 490 mg/kg;
Skin, rabbit: LD50 = >20 gm/kg;
Skin, rat: LD50 = >2500 mg/kg;
Carcinogenicity:
ACGIH: Not listed.
California: carcinogen, initial date 4/19/02
NTP: Suspect carcinogen
IARC: Group 2B carcinogen.
Carcinogenicity:
CAS# 95-63-6: Not listed by ACGIH, IARC, NTP, or CA Prop 65.
Other Studies:
Distillates CAS# 64742-46-7:
Page 5 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
(Petroleum) LD50/LC50:
Solvent Skin contact, (rabbit) >2000 mg/kg [CONCAWE];
Ingestion, (Rat) >2000 mg/kg [CONCAWE]
Inhalation, Non-classified
Carcinogenicity:
Xylene - IARC: Group 3 (not classifiable)
Other Studies:
Do not allow run-offs to flow into drains and watercourses, or dispose in areas where
ground or surface waters may be affected.
Wastes, including emptied containers are controlled wastes and should be disposed
of in accordance with regulations made under the Control of Pollution Act and the
Environmental Protection Act. Using information provided in this PSDS, advice should
be obtained from the Waste Regulation Authority to determine if the special waste
regulations apply.
ICAO/IATA Class: 3
UN-number: 1210
Technical name: Printing ink related material
Packaging group: III
Page 6 of 7
DIC( VIETNAM) CO LTD
31 Street 6, Vietnam Singapore
Industrial Park, Thuan An, Binh
Duong. Vietnam.
Tel: 84 – 6503 – 767357
Fax: 84 – 6503 – 767356
Transport only in accordance with ADR for road, RID for rail, IMDG for sea and
ICAO/IATA for air. Kindly refer to DIC Asia Pacific Pte Ltd if further information is
required.
Product codes:
Since the user’s working conditions are not known by us, the information supplied on this
safety data sheet is based on our current level of knowledge and on national and
community regulations.
The product must not be used for any purposes other than those specified under section 1
without first obtaining written handling instructions.
It is at all times the responsibility of the user to take all necessary measures to comply with
legal requirements and local regulations.
The information given on this safety data sheet must be regarded as a description of the
safety requirements relating to our product and not a guarantee of its properties.
DISCLAIMER
While DIC Asia Pacific Pte Ltd believes that the data contained herein are factual and the
opinions expressed are those of qualified experts regarding the results of the tests conducted,
the data are not to be taken as a warranty or representation for which DIC Asia Pacific Pte Ltd
assumes legal responsibility. They are offered solely for your consideration, investigation and
verification. Any use of these data and information must be determined by the user to be in
accordance with applicable local laws and regulations.
Page 7 of 7