U. S. NAVAL TECHNICAL MISSION TO JAPAN
CARE OF FLEET POST OFFICE
SAN FRANCISCO, CALIFORNIA
27 Decenber 1945
RESTRICTED
From: Chief, Naval Technical Mission to Japan.
To + Chief of Naval Operations.
Subject; Target Report - Japanese Land-Based Radar.
Reference: (a)"Intelligence Targete Japan" (DNI) of 4 Sept. 1945.
1. | Subject report, covering Target E-03 of Fascicle E-l of
reference (a), is submitted herewith.
2, The investigation of the target and the target report
were accomplished by Lieut. W. G. Lamb, USNR, assisted by Lieut. E.
E. Schwalm, USNR, and Lt.(jg) S. H. Kadish, USNR, as interpreter
and translator.
AOR
+ G. GRIMES
Captain, USNRESTRICTED
JAPANESE LAND-BASED RADAR
“INTELLIGENCE TARGETS JAPAN" (DNI) OF 4 SEPT. 1945
FASCICLE E-1, TARGET E-03
DECEMBER 1945
U.S. NAVAL TECHNICAL MISSION TO JAPANRESTRICTED
SUMMARY
ELECTRONICS TARGETS
JAPANESE LAND-BASED RADAR
Japanese land-based radar is discussed in general, and a brief
description of each of the moro important equipments is given. Enclosures (C)
to (J) are diserans of selected sets that can be considered typical.
As shown in Enclosure (K), "Summary of Land-Based Radar," the
development of the first Japanose radar was completed late in 1943. The
Search-light control rader was undoubtedly based on captured British equipment
and the AA fire control models were designed from captured American sets. It
wes stated that although no equipments were direct copies of German designs,
Valuable aseistance and suggestions were obtained fron German technical per—
sonnel.
NOJ-1+8-03Summary
RESTRICTED
TABLE OF CONTENTS
List of Enclosures and Tilustrations .......
Introduction
References
The Report
pert or
Part II
Part. IIT
Pert IV
v
vr
AA Barly Warning Radar 5...
Surface Search Radars
(Harbor and Shore Protection)
Searchlight Control Radar ..,
AA Fire Control Radar .RESTRICTED
LIST OF ENCLOSURES
AND ILLUSTRATIONS
List of Personnel Intervicwed ...
List of Documents Forwarded to Washington Docunent Center
‘through ATIS
Rader Mark 1 Model 4.
(c) Transmitter .
Figure Block Diagram «
Radar Type 2 Merk 1 Model 1 Modifications 2, 3 and 11-3-Kai
Figure 1(D) Transmitter Modification 2 . ee
Figure 2{D) Outline Wodirication 3 .
Figure 3(D) Block Diagram 11-3-Kal
Redas Type 3 Wark 2 Uodel 1 voditiontion 1
Figure 1(E\ Transmitter ......+
Figure Recolver «
Figure Indicator and Synchronizer’.
Figure Regulated Rectifier ees
Figure 5(E) Block Disgran
Radar Type 3 Mark 1 ifodel 3
Figure ‘Antenna
aaa
Receiver Power Supply «+.-
Blook Diagram
Model 3
External Wiring (Modification 1) .
External Wiring «.
Interconnection D:
‘Transmitter Photo
‘Tranamitter ...
Receiver Photo
Receiver
eiver Power Supply
Receiver Power Supply .
Indicator, Search Photo
Indicator, Search
Indicator, Range Photo’.
Indicator, Range «
Synchronizer Photo”.
Synohronizer
Indicator Power Suppiy Photos
Inddestor Power Supply «.
Tand & Indicator «
Antenna - Transmitter’.
Receiving Antenna Photo’...
Booronrvnhs
aig a
fee
-
BEBUEGEUSEB onvourunn®
seanaaaeasoacescoecs,
3Figure
Figure
Figure
Figure
Figure
Receiving Antenna . eoeeesesecees
Receiving Antenna Lobe Switcher . aoe
Inpedance Matohing Unit Details - Photo’...
Voltage Regulator...
Waveneter ..+
Rader Type 2 Mark 1 Model 2 Modification 3
Figure i(H)
Figure 2(H)
‘External Wiring
Outline .
Rader Marke Vode) 2.
Figure
Figure
Figure
Figure
Figure
igure
Figure
Figure
Figure
Figure
Figure
Figure
Figure
Reder S
Figure
Pigure
Figure
Figure
Receivar
Indicator
Tndicator
Tndioator
Indicator + aa
Power Control Unit)
Test Scope .
Synehro Data transmission IND
outline «.
Receiver
Sunmary of Japanese Land-Based Radar
Page
Page
> Page
Page
1 Page
Page
Page
Page
Page
Page
PageRESTRICTED
INTRODUCTION
This report covers Japanese land-based radar in use at the end of
‘the war. Experimental and developmental equipments are described in NavToch
Jap Report, "Japanese Experimental Radar", Index No. B12.
‘The information and conclusions are based upon interrogation of
Tepanese naval and technical personnel and the inspsction of equipnent, in~
stallations, and experimental facilities.RESTRICTED
REFERENCES
Location of Target:
Navy Yard, SASEBO.
Anti-eiroraft installations ou the islands of KYUSHU and HONSHU.
Navy Yard, YOKOSUKA.
Second Naval Technical Institute, KANAZAWA.
Second Naval Technical Institute, Meguro Branch, TOKYO.
Naval Fighter Director Station, CHIGASAKI.
Naval Rader School (Aircraft), FUSISAWA,
Japanese Personnel Interviewed:
‘As Listed in Enclosure (A).RESTRICTED
THE REPORT
Part I~ GENERAL
lend-based navel radar can be divided into five group:
AA Early Warning « + 2 to 6 motors.
Surface Warning Ileteeeeres Wem!
Searchlight Control : TLS meters:
Ak Fire Control TIN $éem"to 175 meters:
Direction of Friendly Graft 5 600m to 2 meters.
AlL of these radars followed a definite design pattern; the equipments con
Sisted of separate units, usually performing the following functions:
Synchronizer (often combined with Range Unit)
Thdicator
‘ngo Unit.
Receiver
Modulator
Transmitter
Antenna.
Lobe Switcher (when required)
Power. Supplies and Voltage Regulators.
Most of these equipments operated on a fixed pulse repetition rate controlled
bya low frequency oseiilator in the synchronizer unit. This oscillator also
aoted as a tine base for the range measuring circults and its frequency was
determined by a tuning fork, crystal, or high Q IC circuit. Conventional wave
forming circuits were used in the indicators to produce linear, logarithate,
and sinusoidal sweeps. The technique of data presentation was’not developed to
a very high degres. "A" scans were used for search and range indication.
Where better accuracy of range measurement was desired, an expanded sinusoidal
sweep was employed. Pip matoning was used for bearing and elevation indication
in syevena with lobing antennae; maximin echo determined bearing in systems
without lob switehing, In conical scan systems, bearing and olevation were
indieated by a variation of the moving spot typo indicator. A pattern ap-
peared on the cathode ray tube to indicate an error in bearing or elevation,
and when this error had been corrected, the pattern closed down to a single
Spot centered on the tube face. No "B* scans or PPI indications were used on
Yand-based naval radar. Range marks were applied to the "A" sweeps either as
equally spaced pipa or as a single movablo mark, Induotive phase shifters
operating trom the synchronizing oscillator provided the tine delay circuits
for the range unite where movable Tange marks were used.
Tho receivers were of conventional design with double or single IF sections.
Intermediate frequencies in use ranged from 200 ke to 21.5 mc. In general,
the band wiath was equal to the reciprocal of the pulse length. ‘This would
give band widths of from 50 ke to 400 ke.
Grid modulated transmitters were generally preferred in view of the low modu-
lator output required and the ease of synchronizing. The oscillators were of
from one to four tubeg tuned by parallel lines or L¢ circuits, or magnetrons
for micro-wave equipments.
Antenne design showed no advanced techniques. This was at least partially due
fo the indloation systens employed, as none of them called for narrow beam
widths or rapid scanning antennae, YAGI arrays were very popular, especially
7E03 RESTRICTED
Brraye weg used 2220,08 assonbly wore factors of importance. Large vedsyring
saeernaNOre used for inportant long-nave early warning radars. “Sosreee
antennae for transmitting and receiving were Used by ost or the p
Soehoueh Tecont designs and experimental equipments showed a nested wees
Pitonea Be, Use Of & Singke antenna and duplexing systems Lobine sao renim
Biiened either by contact, capacity, or inductive switching, with sontece
Topean Ne Peing preferred’ especially wiore only the recelvine autene noe,
lobed.
Phe ond wef nstionaly craft, air and surface, was in a state of development at
Radars Sache wer ead 4s, thoated in Navieohtap Report, "Tepancse Severn ee
That openeeee eet eee gg mmete,wOFE two Methods invuse ates to Peeper tty
“het operated in conjunction with the M-13 IP, and a d0cm conical ove ance
Tt 48 doubtful, however, that this would have
qualiziea gormsaues den developed. “Although the Japanese were theonseinctiy
Megaade eee eeeauee modern radar squipmont, production difficulties: secre
sogauste, test equipment, and the absence of czeative imginaéion soniding ic
models that compare with American equipment of 19i2°
Folnont, Geeeription of each of the more important lend-based radar oquipments
follows.
Part IT - AA EARLY WARNING RADAR
Mark 3 (RD), Ak Narly Warning Rader
Wavelength ..... oo 5 moters
Peak Power : SEI soo" Watts
Wave ai SII cont dauous
Osciistor’! il Grystai Controliea
Amplitier .. a RF Power
wove eegbpmont, of this radar was comploted lete in 1942. A few installations
Moaeaaadg but the opexation was generally unsuccessful and the protest ney
abandoned.
Be Mark 2, Model 4 (14), (See Enclosure c)
Wavelength .., Sooeno ae 6 moters
Peak Power Output ++ 100 kw
Pulse Length «... : 20 micz6" seconds
Pulse Repetition Rate 11.1222
Osciiiator Push-Pull, “back soupied) “para
Antenna s+ Single, for transmitting and resolving,
Raat having Bot 2oder of the long wave AA osrly warning radars, the develop-
maton yin been completed 1 Tune 1945. The antenna isa iaree’ stercwene
Sloneat Bete meters igh, snd 4.7 meters deep. It 1s compose of tower too
Gloment, ‘halr-wave Yaais with a similar array of full wavelonsth Sohiod it
acting ds a paranitic reflector. The sore yrosestet ine ooeee ee Man ty
maximum echo being used for bearing determinktion,
e
Wavelength .
Peal Power OuiRESTRICTED
uodifieation 1
Moditication 2 ¢ 5
Modification 3 221.11... posses eee (401 kw
Pulse Length .....» 19 aigz0" seconds
Pulse Repetition Rate
Modification 0 .... 1000 eps
Modifioation 1 ...ttt 1000 eps
Moaitication 2 lrriitcssecececes ops,
Woditieation 3 +... : eps
‘Tnis is one of the most widely used AA early warning radars; an early model
waa known a9 as the Guadalcanal Type. The first of theso was completed varly
(n'19h2 and minor modifieations in dosign wore made shortly thereafter. A
Aajor redesign was completed about the middle of 1943 and was designated
Tiggisisation 2." This redesigned equipmont was more ruggedly constructed and
had considerably more power output. Modification 3 is similar to Modification
2 put has a fey minor improvements, The appearances of the 11, 21-2, 11-2)
Sha li-3 were similar, being apeir Sf antennae on a large screen, 8 motors by
Si neters, mounted aidng with the control roon on a rotating structure. Aa
S3n"fypo presentation 18 used with maxinun echo for bearina indication,
D. 1s3-Kat (See Enclosure D)
Wavelength) :
Peak Power Output”!
Pulse Length «+. ...-
Pulse Repetition Rate .
‘Antenna .... es
‘This rader was a redesign of the Type 2, Wark 1, Wodel 1 series and although
completed in June 1945, 4¢ was not yet in use. ‘Although # single antenna was
Used for tranamitving nd receiving, lobing in the horizontal plane was
eaployed only while receiving. The accuracy in bearing was stated to be plus
Creminus 1°,” Tt was further atated that the single lobe (when transmitting)
Cirowed better frequency stability and also that sone difficulty was experi-
Snoed in bullding @ high power lobe switcher. This equipment is similar in
Sppeazance to the 11 series, the antenna and control room being mounted on a
Beating structure. ‘Three indicators were used: "A" scan for warning, pip
hatebing for bearing, end an expanded sinusoidal scan for range.
B. Type 3, Merk 1, Model 1 (12-K). (See Enclosure 5)
Wavelength - 5 Soon + 2 meters
: ee 210 ke
1°20"miero seconde
HIN we eeeees 500 ope
ig) for" tzdadaliting and’ receiving.
‘This was a medium size AA early warning radar designed for shore installations
The antenna was couposed of an array, 5 dipoles high and 4 wide, on a rotating
Structure. The control room and unite of the equipment are usudlly installed
Shderground adjacent to the antenna. "A" type indication is used with maxima
echo indication for bearing.
F. Type 3, Mark 1, Model 3 (13). (See Enclosure F)
Wavelength ......- Soon oooaooeoEeD + 2 meters
Pook Power Output ‘ ee
Pulse Length «sss... Geeg00 T'i0'aisioseconts
Pulse Repetition Rate +... eeedeeeaa 500 ops
Entonna sscrtereeseeeeceese Single, for trananitéing and receiving.
ry
‘his is one of the more Popular AA warning radars, being light weight and£-03 : RESTRICTED
easily installed. An "A" type indlostor was used with maximum echo indication
for bearing. Although the design of this radar was completed in October 1943,
Qroogaiderabie quastity wie found 4a storese and inatatied on lend and on ‘ahip-
oar.
@. Type 2, Mark 1, Model 2, Wodirications 0, 2, and 3. (See Enclosure G)
Wavelength - seeseseees 2 motors (modification 0 - 1.5 meters)
Peak Power Output 2.12: aE
Pulse Length +-..seeee THU ib"aieze’seconas
Pulse Repetition Rate 171000" apa"(nodizieation 3 ~ 500 eps)
Entennae s...-s++eeececeee Soparate, for transmitting end receiving
This is a light weight, low power, mobile equipment. Modification 2 employed
2 duplexing systen to allow the use of a eingle antenna for transmitting and
Fecelving, but this was evidently unsatisfactory as recent drawings have been
Tovised £0 show two separate antennae. This equipment was very similar to and
uses @ number of units common to the Type 2, Mark 2, model 1, a shipboard
fader, "A" type indieetion and maximum echo for bearing is ised.
H. Mark 6, Moder 3 (63
Wavelength .. 3 meters
Peak Power Output i kOe
Pulse Length «.-... 20 aicro’ seconds
Pulse Repetition Rate ....st2:
Antenna seseeseeee Sinisa,
An experimental radar with broad band antenna. This radar is described in
Navfochsap Report, "Japanese Experimental Radars," Index No. 2-12.
Part III - SURFACE SEARCH RADARS
(HARBOR AND SHORE PROTECTIONS —
‘hese radars were designed primarily as shipboard equipments. The basic
charecteristics are listed here for reference; a more deteilea description
‘ill be found in NavTechJap Reports "Japanese Submarine and Shipboard Radars",
Index No. E-Ol, and "Japanese Experimental Rader", Tndex No. E-12.
Mark 2, Model 2 Modifications 1, 2, 3, and 4 (22-kai 1, 2, 3, 4)
Maxk 3, Model 1 (220)
dark 3, Model 2 (32 or 10582)
Wavelength 7 seeses 10 om
Poak Power Gutput”: 2 ew” (23"kaii-500m)
Pulse Length « eo ++, 10 micro seconds
Pulse Repetition Rate .....+1 2500 ops (22-Kal 3-600 eps)
Part IV - SEARCHLIGHT CONTROL RADAR
Mark 4, Nodel 3 Modifications 0, 1, and 2 (Iy, Lg, 13) (See Enclosure G)
Wavelength a
Peak Power Sutpat
+ 4 mlero seconds
III 3 micro seconds
peaeteeesececeeees 3 micro seconds
10RESTRICTED
Pulse Repetition Rate — ono sve+2 1000 ops
Antenna, SLIT separate; “for trananitting” and receiving
The transmitting antenna and the bearing and elevation indicator were mounted
ona searchlight controller. The receiving antenns, composed of four Yagis,
Joveswitcher, transmitter, and transmitter power supply, are mounted on the
Searchlight which 19 servo-operated from the controller. The other unite were
usually installed underground nearby. The later models of this equinaent
employed an "A" scope for search, an expanded "AY sweep for range, and an
{haieator similar to the moving Spot scope for bearing and elevation. Tt was
stated that accuracies of plus or minus 1.5° were obtained in bearing and
elevation, This equipment was probably copied from an carly British design.
Part V - AA FIRE CONTROL RADAR
Mark 4, Model 1 (S3). (See Znclosur
Mork k, Model 2.(S2h). (See Znolosu
Wavelength . + 1.5 meters
Peak Power output ie 13 ow
Pulse Length «-...1.. IIIS aiezo"seconas
Pulse Repetition Rate 1000 eps.
‘Antennae... Son separate
imese two radars were quite similar, the x difference being in the antennas.
The 33 had three antentae; one for transmi 1g, one for elevation, and one
for Bearing. It waa very similar to the U Army SCR266. The 52h has two
antennae, one for transmitting and one for >eiving. (Lobing is employed on
the receiving antennae. Accuracies of plu ¢ minus 1° can be expected in both
bearing and elevation. An "A" scope was u. for range and search, and pip
matohing was used for bearing and olevatio.
Be SBA
Wavelength eooucooaca
Peak Power tee ee
Pulse Width... 1215 micro’ seconds
Pulse Repetition fi 3750 eps.
S8B (Mark 6, model 1)
Wavelength co
Peak Power Gutput -
Pulse Width .
Pulse Repetition Rate.
‘These two radars are experimental conical scan equipments and are treated in
detail under NavTechJap Report, "Japanese Experimental Radars," Index No. £12.
Part VI - RADAR FOR DIRECTION OF FRIENDLY CRAFT
Mark 6, woder 2 (62
Wavelength ... f + 2 meters
Poak Power Output’: fees 10 low
Pulso Length «... 16° aigze” seconds
Pulse Repetition Rate’: 500 eps
Antenne sissssesseeeeee 7 - singleRESTRICTED
9
Wavelength ....... + 1.5 meters
Peak Power Output : PEI 23 ow
Puls IIIT 6 niéz6"Seconaa
a 1000 eps
DIL etngle
Those two radars were used in conjunction with the M-13 IFF for direction of
friendly craft. A broad band antonna was used to allow reception on a slightly
aitterent frequency trom that of transmission. These radars are described 1
NavfechJep Report, "Japanese Experimental Radars," Index No. 12.RESTRICTED
ENCLOSURE (A)
Nome
Vice Adm. T. NAWA
Capt. NW, TAKAHARA
capt. & Dr. Y. 170
capt. (Tech) XY. YATTA
Capt. I. ARTSAKA
Capt. K. NAGAT
Tt, Comir. (Tech) T. HYODO
Lt. Comix. (Tech) 8. KATSURAT
Lt. Conds. (Tech) S. WORT
Lt. Comdr. (Tech) H. TSUSTTA
Lt. Comdr. K. KAMIYA
OF PERSONNEL INTERVIEVED
Imperial University
Blectric Engineering Section
Chemical Enginooring Section
Selence Section
School and Year
of Graduation
Tokyo I.U,(£,2,S.)1917
studied Chemistry in
Tokyo T.U,(S.S.)1919-1922
Naval Acadeny 1919,
Tohoku I.U.(B.E.S+)1932
Tokyo I.U.(E.,S.)1924
Technische Hochschule
Dresden, Germany 1927
Tohoku I.U+(E.E.S.)1924
Naval Acadeny 1923
Tohoku I.U.(H.2.S.)1934
Naval Acadeny 1924
Tokyo I.U. (C.x-5.)1936
Tokyo T.U. (B.B.S.)1936
Tokyo I.U, (E.E.8,)1937
Kyoto I.U.(S.S.Physics)
1936
‘Tohoku I.U. (E-E.S.)1936
Specials:
Chief of the Rader
and Communication
Department.
Head of Fourth
Section (radar inter~
copter, radio
deacons & dir. find.)
Head of First & Soc=
ond Section (Funde-
mental researches)
Secretary to T. NAWA
Head of Production
Section.
Head of Third section
of Communication
Dept. (Radio equip.)
Member of Adminis~
tration Dept.
Researcher on Kater~
‘ala and Componente
for High Frequency
Use.
Researcher on Land
and Airborne Radera
(type 51, 61, 63).
Researcher on ship-
borne radar(em. wav
viz. 22)
Researcher on air-
dorne radar (meter
wave, i.e. FY-3,
FEAL, Fak, 5-65.
Researcher on com
ponents and tubes
for high frequency.RESTRICTED
ucLosopR (41, continued
Sohool and Year
emo of Graduation Spectartie
Comix. (Teoh) 0. OKAMURA Tokyo 1.U.(Z-H.S) 1940 Researcher on tubee
Condr. S. MATSUI Naval Academy 1934 Head of Research in
Osaka I.U.(S-S.Physies) Yokosuka Branch (re~
1942 search on installation
of ship-borne and lend
based radio and radar).
omar. (Tech) W. SUGIYAMA Waseda University(Z.E.S.) Researcher on high
191 frequency cable in
‘Yokosuka Br.
(Tech) K. OGATA ‘Tohoku I.U.(E.2,8.)1941 Researcher on land
based radar (cm. wave;
viz. 61)
(mech) S. KAWAZT Tokyo I.U.(E.E.S.)1941 Researcher on land
based radar (moter wave
ive. 14,62)-
(Tech) S. YAMANE Kyoto I.U.(E.E.S.)1942 Researcher on airborne
radar, counter mea-
K, MORT Naval Acudeny 1940 Teacher in Rader
‘Training School.
K. TAKAYANAGT Kuramae Teoh. College Consultant to 7. NAWA,
1921 Hoad of hind Séetion
Radar
Waseda University 1933 Researcher on radars
(.E.S.) (meter wave i.e. L-2,
L=3, 9-3, S-2h, N-6,
u-13)
Tokyo I.U.(S-S.Physics) Researcher on high
1933 frequency circuits for
om. wave,
‘Tokyo Physical School roher on airborne
1929 sr wave N-6)radar.
Washington University Researcher on airborne
U.S.A. 1934 radar intercepter and
shipborne direction
finder.
Waseda University 1930 Consultant to H. TAKA-
HARA (researcher of
radio freq. instruments
in Electro Technical
Laboratory of Japanese
Government).RESTRICTED
ENCLOSURE (4), continued
School and. Year
of Graduation
| Ute university 1932
Shectalttes
Interpreter (had 20
relation to Second
Nav. Tech. Inst. up to
the end of the war;
Belongs to Electro:
Tech. Lab. of Japanese
Governnent )RESTRICTED
ENCLOSURE (B)
LIS? OF DOCUMENTS FORWARDED 0 WDC THROUGH ATIS
HavTechyap No. ATT Wo. Title
21-6073 3328 |, Instruction Book, Temp. Desig. Mark 1 Radar
6074 3329 Modification and Repair, Temp. Desig. Mark
1 Radar
6075 3330 Instruction Book, Temp. Desig. Type 3,
Mark’ 1, Yodel 1 Redex
6076 3332, Installation Reports, Temp. Desig. 2:
Nodei 1 Radar
6077 3332 Installation Instructions, Temp. Desig.
Wark 1, ‘Model 1 Rader
6079 3334 Installation Modifications, Temp. Desig.
‘Type 3, Mark 1, Model 1 Radar
6080 3335 Instruction Book for Transmitter, Receiver
and Indicator for Temp. Desig. Type 3, Mark
1, Model 1 Radar
3336 Installation Instructions, Temp. Desig.
lark 1, ‘Woder 2 Rader
3337 Modification Reports, Type 2, Wark 1, Model
2, Modirication 2 Redar
3938 Modification Report#, Type 2, Mark 1, Model
2 Antenna
3339 Operating Instructions, Temp. Desig. Mark 1,
Model 2 and Mark 2, Model 1 Radars
3340 Instruction Book for KO(A) Model 1 Tnateator
used with Type 3, Mark 1, uodel 3 Radar
33K2 Instruction Book, Type 3, Mark 1, Model 3
Tand~Based Radar
3343 Installation and Maintenance, Temp. Desig.
Mark 1, Model 4 Radar
33 Instruction Book Antenna Switching Device
used with Temp. Desig. Type 3, Mark 2,
Moder'"1 Radar
39K5 Antenna Coupling Device used with Type 2,
Mark 2, Model 1 Radar
3347 Instruction Book for Receiver used with
Temp. Desig. Type 3, Mark 3, Model 1 Radar
3372 Instruction Book, Temp. Desig. Mark 2,
Model 2 Radar
3349 Operating Instructions, wark 2, Model 2,
Modification 2 Radar
16RESTRICTED
ANCLOSIRE (2), continued
avTochTap No. ATES No. mitre
6096 3350 Operating Instructions, Mark 2, Model 2,
Modification 3 Radar
6097 3352. Instruction Book, Mark 4, Model 1 Radar
6098 3352 Instruction Book, Temp. Desig. Mark 4,
Moder 3 Radar
6099 3353 Instruction Book, Mark 4, Model 3, Moairi-
cation 1 Radar
6106 3385 Rader uaintenancs
6155 3357 Installation Drewings, Mark 1, Model i,
Modification 2 Radar
6156 3358 Receiver Operating Instructions, Mark 2,
Model 2, Modification 2 Radar
3359 Indicator, Type 3, Mark 2, Model 1 Rader
3360 Operating Instructions, Mark 4, Model 1
Rader
339% Radar and Radar Intercept Receiver
Installation Instruct ions
3395 Table of Naval Radar
3h22 Instructions for Handling on Land the Type
3, Mark 6, Model 4 and Type 3, Model 4
‘Aatenna
3404, Experimental Report, Type 2, Mark 1, Model
2, Modification 3 Radar and Rader Using
Submarine Antenna
340k Ingtallation Report, Type 3, Wark 1, Model
2 (21K) Radar
340%, Report on Tuning the S3 Radar Installed at
CHICHITTUA
340d, ‘Tuning Procedure for Mark 4 Rader
3368 ‘Trouble Shooting Table for Temp. Desig.
‘Type 3, Mark 2 Radar, June 1945
3407 Instructions for Installing Radar and Radar
Intercept Equipment (Proposed) Land Instal-
lations, April 1945
3367 Modifications in Installing Temp. Desig.
Type 3, Mark 1, Model 2 Radar, Fob. 1945
3409 Experiments on the Temp. Desig. uark 6,
Vodel 1 Radar
17‘WavTeohJep No.
6279
6285
RESTRICTED
ICLOSURE (8), cont tnued
Titie
Tomp. Desig. Mark 4, Model 4 Rader
Radar and Radar‘Intercept InstallationsENCLOSURE (C) _
CONNECTION DIAGRAM OF TRANSMITTER a A
CTYPE 14) k —H
RESTRICTED
ENGL. att)
MARK | MODEL 14
TRANSMITTERBKCLOSURE {C), RESTRICTED
POWER SOURCE
OUTER, CHASE
tir paer. reemivatls
Pr arrests
Aco PAT reeinaLal
AR PagT-TERMINAL 2
\bourpur, |
5 | 22 FP RBUC ST |
th Y
—TELESHONE >
RECEIVER,RESTRICTED sNCLOSURE (v), continued
ewe per
Borrom vaw
MARK 1 MODEL 4
INDICATOR
Figure 300)
“70?‘vctosone (C), continuea
Figure 4(0)
LTROTCATOR POWER SUPPLY
evans
Figure 5(0)
‘Lock DIAGRAY
22z
3
eave |
(0 eusg aang 30 9enT YT ody,
Wars AKL
RESTRICTEDRESTRICTED
-RyCLOSORE (C), continued
laa 2 2
‘gaaSRR:
ag 8288
(a £288
a8
:
g
i
: Ree
SRR
‘THPE-AL RADAR
3
i
i
i
:
5
AaagaaaANA RTT ER TARY
489 RAR EYE BAAR
a8 83 3 aaa
a8 8RESTRICTEDRESTRICTED
SNCLOSURE (0), conttnued
LAND BASsEO
scounacrs 11mg 2°
ftanoes 200 em PULSE LeMeTH: 20 n8,
- =_th
a
PATTER
fle QA
wren 5464 es: a
joo as
reanesairrer
7
ocx Disaew 11-9-841|
ENCLOSURE (E) RESTRICTED
ANTENNA 1 DESIGNATION a NOTES
co [Por TERMINAL, [PLATE Cl, CIR. OPEN COmL Taiiea
[COUPLING CONDENSER [ANT. COUR COIL reausa
SRE [ss TERMINAL FOR ABOVE
Fil, HEATER TRANSFORMER Wi FREQ. CHOKE COIL ers
SEH PERNA Suse
[BY-PASS COND FOr {se (JUNC TION PANE LCroRRWIRY |
TATTICE WORK CE i ME AS ABOVE.
By- Fas COND. FOR
[ovTPUT TRANSFORMER
PLATE RESISTANCE,
VOUrAGE DROP RES! STANGEIC.
SAME AS BOY,
BY-PASS COND. FOR ABOVE
AM PLIFIE Fe a
dtteG)
SCREENING LAT. w/ ra
5
zs
a
sR ABSVE
PLATE FOWGUPP RECTBE
VOLTAGE" DROP RESIST. le: Fit HEATER TRAN,
BY: PASS COND. FDR. ABOVE: [9P-c36|
ir=307
CONTRO. LATIN RESIS.
PROTECTIVE GonDE/sERO-C3101
lowe
cn BSenaneen er Z27.
SETS arr Sooor
Ti aE
7 HANGE SW
comes
is
ABOVE (ALOR
HANGE OVER SW. FAR ABOVE: HxRESTRICTED ANCLOSURS (8), continued
‘ms fenteaione oxtesonty
aly aunt
3
g
5
RESTRICTEDRESTRICTED
‘BNCLOSORE (8), continuedRESTRICTED
ENCLOSURE (F)
Figure 107)
ARENA 9
33RESTRICTED
iRESTRICTED ENCLOSURE (¥),. continuedFACLOSthe (P), cont tnued RESTRICTED
cures
T
i6—d—d— =
4200¥ #230¥
gure iF)
acarvin RESTRICTED
ca ENGL.D(4)
TYPE 3 MARK | MODEL 3