Professional Documents
Culture Documents
Are Ds
Are Ds
ARE SERIES
FERRORESONANT CHARGER
24, 48 & 130VDC | 144 to 6500W
10-320
For utility applications
•For
24-,utility
48- andapplications
130-volt Models • Low Noise Levels
• 6 to 50 Amperes Output • Current Limiting
• 24-, 48- and 130-volt Models • Low Noise Levels
• High Efficiency • Easily Maintained
•• 6 to 50 Amperes Output •• Current Limiting
• 24-,
High48- and 130-volt
Power Factor Models Low Noise Levels
•• High Efficiency
6 to 50 Amperes Output •• Easily
CurrentMaintained
Limiting
•• High
High Power Factor
Efficiency • Easily Maintained
• High Power Factor
www.unipowerco.com
North America & CALA: +1 954-346-2442 • EMEA: +1 561-990-3830 • sales@unipowerco.com
ARE Series - 2
P O W E R I N G T E C H N O L O G Y
ARE SERIES FLOAT RECTIFIERS During operation, the maximum output eight-hour capacity rating of four times
voltage transient does not exceed the rectifier current rating.
Controlled ferroresonant float rectifiers
have many inherent advantages …. 5 percent of the initial steady-state
voltage for sudden load changes For 130-volt models, the filtering provided
voltage regulation, short circuit protection,
between 20 percent and 100 percent of produces a ripple level of less than 30
low operating costs (a combination of high millivolts rms when connected to a
rated output. Recovery takes less than
efficiency and high power factor), easy battery with an eight-hour capacity
200 milliseconds. Operation off the
maintenance and high reliability. battery is stable under all conditions of rating of four times the rectifier current
line and load (within stated limits). rating.
The ARE Series of float rectifiers combines
these inherent advantages with advanced
Turn-on under all conditions of line and The total dynamic response of the
rectifier, control and filter circuitry, and
load has a “soft-start” characteristic control circuitry permits all ARE rectifiers
user-oriented packaging. Designed
without overshoot. to operate as power supplies (at
specifically for utility and communication
increased ripple levels) when the
applications, the ARE Series rectifiers are
REGULATION CURVE batteries are removed for service.
easily adjusted to meet your specific
operating requirements and will provide 2.33
EQUALIZE EFFICIENCY AND POWER FACTOR
years of low-maintenance service. 2.2
FLOAT 100
POWERFACTOR
2.0
INPUT
VOLTS PER CELL
EFFICIENCY
80
All transformers are dual wound for either 1.6
120, 208, 240 volts (-12, +10 percent) or for
60
208, 240, 480 volts, single phase, 60 Hz ±5
1.2
percent.
40
REGULATIONS 0.8
0 20 40 60 80 100 120
DC voltage is maintained within ±1/2 20
percent at any load from no load to full
load with ±10 percent variation (or ANSI ELECTRICAL NOISE
standard ranges) in the AC input voltage For 24- and 48-volt models, the filtering 0 20 40 60 80 100 0
% LOAD
while floating rated number of cells. provided produces a ripple level of less
than 30 millivolts rms with electrical
Control is accomplished with a single noise less than 22 dBrn with C message
control board with operation on or weighing on a type 3A noise measuring
off a battery. set when connected to a battery with an
AC Supply
120/208/240/480 60 Hz +/- 3 Hz
PRINCIPLES OF ▼
CONTROLLED FERRORESONANT OPERATION AC High
Circuit Voltage Alarms
The conventional ferroresonant transformer has inherently good Breaker
◄
Shutdown
◄ ◄
Power XFMR
Its high reactance provides protection against overload and short ►
Constant Voltage ► Resonant
Capacitor
Resonant
Control
Ferroresonant
circuit of the output. The output voltage does vary with changes ▲
in load and frequency. The output winding is on the same leg of
the core as the resonant winding, and the resonant capacitor Electronic ◄
Voltage
acts to maintain this core section at a high level of saturation, Current
◄
Control
resulting in a constant voltage. To provide a precise constant ▲
start of the resonant capacitor charge cycle and switches the Shunt
thyristor on to interrupt the cycle. The point of interruption is
delayed by a signal fed back from the output to allow the ▼
DC
voltage to rise to the preset level. In the event the current Circuit
exceeds a preset level, the signal from the shunt overrides the Breaker
Cabinet A B C D
12.25 in 17.00 in 14.00 in 5.00 in
12
311 mm 432 mm 356 mm 127 mm
24.50 in 17.00 in 14.00 in 5.00 in
24
622 mm 432 mm 356 mm 127 mm
30.00 in 20.50 in 15.00 in 6.00 in
30
762 mm 521 mm 481 mm 152 mm
36.00 in 20.50 in 18.00 in 10.63 in
36
914 mm 521 mm 457 mm 270 mm
• 17-inch (432 mm) wide cabinets can be used in 19- • Rack angles mount at rear for wall mounting.
inch (483 mm), 23-inch (584 mm) or 30-inch (762 • Floor brackets are available for all models instead of relay
mm) relay racks. rack mounting angles when ordered with charger.
• 20.5 inch (521 mm) wide cabinets can be used in 23-
inch (584 mm) or 30-inch (762 mm) racks only.
24-volt output
Recommended Circuit Approx.
Model Input AC DC Cabinet DC cable size breaker ship. wt.
Volts amps amps AWG DC lb kg
ARE24AC6E 120/208/240 2/1.1/1 6 12 14 10 65 30
ARE24AC12E 120/208/240 4/2.3/2 12 12 10 20 72 33
48-volt output
Recommended Circuit Approx.
Model Input AC DC Cabinet DC cable size breaker ship. wt.
volts amps amps AWG DC lb kg
ARE48AC6E 120/208/240 4/2.3/2 6 12 14 10 72 33
ARE48AC12E 120/208/240 7/4/3.5 12 12 10 20 95 43
130-volt output
Recommended Circuit Approx.
Model Input AC DC Cabinet DC cable size breaker ship. wt.
volts amps amps AWG dc lb kg
ARE130AC6F 120/208/240 8.5/5/4 6 12 14 10 100 46
ARE130AC12F 120/208/240 18/10/9 12 24 10 20 170 77
ARE130AC16F 120/208/240 22/13/11 16 24 10 20 185 84
ARE130AC25F 120/208/240 35/20/17 25 30 8 40 325 148
ARE130AC35F 120/208/240 50/29/25 35 36 8 50 460 209
ARE130CE25F 208/240/480 20/17/8.5 25 30 8 40 325 148
ARE130CE35F 208/240/480 29/25/12.5 35 36 8 50 460 209
ARE130CE50F 208/240/480 40/35/17.5 50 36 4 70 600 273
are-legacy-ds-revF-0919.indd